Mazda RX-8 Complaints (2004)

490 consumer complaints on file.

#11770948October 13, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2004 Mazda RX-8. The contact stated that while the vehicle was being serviced at Valvoline for a scheduled oil change, the contact was informed that fuel was leaking. The contact was advised not to drive the vehicle. The dealer was contacted and notified of the failure. The vehicle was taken to the dealer, where a diagnostic evaluation revealed a fractured fuel system discharge pipe. The contact was informed that the fuel pump required replacement. The contact associated the failure with NHTSA Campaign Number: 17V354000 (Fuel System, Gasoline), which was completed on the VIN in 2009. The manufacturer was notified of the failure and informed the contact that the repair was not covered under warranty. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736604May 8, 2026
FUEL/PROPULSION SYSTEM
No worries — here it is trimmed to under 2,000 characters: I am reporting a recurring safety defect on my 2004 Mazda RX-8 (VIN: [XXX] a repair under NHTSA Recall 1017E (Fuel Pump Ring / Discharge Pipe). Recall 1017E was completed on my vehicle on September 19, 2017. The same fuel leak has since recurred, with fuel vapor now entering the passenger cabin. Only a few thousand miles have been driven since the recall repair. The vehicle is currently at Della Mazda, Queensbury, NY at approximately 72,000 miles. On May 8, 2026, I contacted Mazda Customer Experience Center. Mazda confirmed the dealer submitted a pre-authorization request for recall coverage, which Mazda corporate denied, stating the recall was previously completed and further repairs are my responsibility. I have a chat transcript documenting this. A recall remedy that fails to correct the covered defect should not be considered complete. I am requesting NHTSA review whether Recall 1017E has produced recurring failures, direct Mazda to honor the recall remedy, and advise on available consumer reimbursement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675012July 21, 2025
AIR BAGS
For a year I have responded to every notice for a recall repair (7 total) Mazda has not repaired my vehicle or scheduled its repair. My recall ID is 016742248 and my Campaign Number is 100409. My car has a DO NOT DRIVE status and Mazda tells me I MUST drive the car 2 hours to get it repaired each way. And they refuse to transport y vehicle even thought I have told them in phone conversations about my cars do not drive status. The latest attempt for filing for a repay was 7-21-25 at 9:40am central time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11590479May 23, 2024
ENGINE
The contact owns a 2004 Mazda RX-8. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the engine. The dealer determined that the engine had no compression. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11571290February 11, 2024
STEERING
The electric power steering randomly pulls hard to one side while driving. There are brief spasms of forceful jerks each jerk is 1-2 seconds the series of jerks lasts 10-20 seconds and usually stops with power steering failure all while driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11514483March 29, 2023
ENGINE
Engine naturally wears out especially after 200k miles due to friction in the natural design of the Rotary engine, resulting in losing its overall function such as turning off in the middle of a drive due to loss of compression from worn Apex Seals of the Rotary. The rotary engine requires a replacement of the Apex Seals to continue functioning normally to avoid any unpredictable accidents due to engine failure. An event occurred where my RX-8 went into limp mode in the middle of the freeway as i was commuting due a misfire from poor compression, this is more then likely a common event nowadays for RX-8 owners starting at the S1 2004 models with newer models soon to follow the same incident as me. This is completely unsafe especially traveling at 65 MPH
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498663December 23, 2022
FUEL SYSTEM, GASOLINE
The contact owns a 2004 Mazda RX-8. The contact stated that while the vehicle was parked, he noticed a strong gasoline odor originating from the vehicle. There was no warning light illuminated. The contact stated that the failure persisted. The vehicle was taken to the dealer where it was diagnosed that the fuel pump was fractured and needed to be replaced. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 17V354000 (Fuel System, Gasoline); however, the recall repair failed to fix the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they would follow up with him. The failure mileage was approximately 86,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11427511August 2, 2021
FUEL/PROPULSION SYSTEM
Fuel fumes are leaking into passenger compartment and leaking from tank. Previous recall failed to fix
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11414240April 28, 2021
AIR BAGS, UNKNOWN OR OTHER
FRONT PASSENGER AIRBAG CRACKED DASH AND PUSHED OUT GLOVE BOX.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11405160March 27, 2021
UNKNOWN OR OTHER
I NOW HAVE REPLACEDCLUTCH PEDAL THE FORTH TIME. IM WRITING THIS TO SEE IFI CAN STILL GET ONE FACTORY REPAIR OF THE PART THE PEDAL WILL BREAK IN WELD SPOT REGARDLESS OF MY TRYING NOT PUT TO MUCH PRESSURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11397667February 24, 2021
STEERING
JULY 2017 WHEN I START THE CAR THE STEERING GEAR TURN TOO THE RIGHT ALL THE TIME. FEW MILE THE STEERING GET HARD AND START SHACKING BY IT SELF. NOW THE STEERING IS HARD WITH ABS AND CONTROL TRACTION LIGHT ON. I SEND IT TOO A MECANIC TOO CHECK THE WIRING AND RACK AND PINON AND THE MECANIC INDICATE THAT IS THE TORQUE SENSOR AND I HAVE TOO CHANGE THE RACK AND PINON.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11397284February 22, 2021
FUEL/PROPULSION SYSTEM
RECENTLY PURCHASED THE CAR FROM SOMEONE ELSE AND NOTICED THAT THE CABIN SMELLS LIKE FUEL. I THOUGHT MAYBE HE SPILLED SOME INSIDE IT BUT IT'S BEEN A WEEK AND THE SMELL IS STILL THERE. I DON'T KNOW WHY AND I'M WORRIED ABOUT THE CAR CATCHING FIRE OR ME GETTING CARBON MONOXIDE POISONING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11308311February 10, 2020
POWER TRAIN
CLUTCH PEDAL BROKE DRIVING DOWN THE ROAD
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11282643November 27, 2019
STEERING
STEERING TURN ALONE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11278260November 5, 2019
UNKNOWN OR OTHER
PASSENGER DASH COVER HAS LOST INTEGRITY/CRACKED ALONG THE LINES WHERE THE AIRBAG DEPLOYS AND AM CONCERNED THAT THE FORCE OF POTENTIAL AIRBAG DEPLOYMENT COULD BE AFFECTED AND NOT WORK AS DESIGNED OR DEPLOY WITH TOO MUCH FORCE TO CAUSE INJURY OR DEATH TO THE OCCUPANT IF THE AIRBAG COVER SHOULD FLY OFF UPON DEPLOYMENT. THIS IS AN ISSUE WITH THE DASH OF MANY MAZDA VEHICLES AND SHOULD AT A MINIMUM BE REVIEWED. THE CAR HAS NOT BEEN IN ANY ACCIDENTS AND THE AIRBAGS RECALL HAS RECENTLY BEEN PERFORMED BY A MAZDA DEALER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11269947October 21, 2019
STRUCTURE:BODY, SERVICE BRAKES, ENGINE
SEAT BUILTS NEED TIGHTING
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11269971October 21, 2019
AIR BAGS
ON 10/19/19 THE VEHICLE WAS INVOLVED IN A CRASH WHEN SWERVING TO AVOID A DEER ON THE ROAD. TWO TREES WERE HIT AND THE VEHICLE WAS FLIPPED ON ITS SIDE. NO AIRBAGS DEPLOYED DURING THIS ACCIDENT AS I WAS EXPECTED. PICTURES SHOW THE FRONT DAMAGE AND INTERIOR.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11267777October 10, 2019
STEERING
WHILE DRIVING MY 2004, MAZDA RX8 THE ELECTRIC POWER STEERING MODULE FAILED, AND JERKED THE CAR AGGRESSIVELY TO THE LEFT INTO THE ONCOMING LANE OF TRAFFIC. THE FORCE WAS SO STRONG THAT IT CAUSED MOMENTARY LOSS OF CONTROL. FORTUNATELY, THERE WASN'T ANY ONCOMING TRAFFIC AT THAT MOMENT ON THAT PARTICULAR STRETCH OF ROAD. WHEN REVIEWING THE MAZDA FORUM THERE WERE SEVERAL OTHER OWNERS THAT EXPERIENCED THE SAME LOSS OF CONTROL OR FAILURE. ADDITIONALLY, MAZDA HAD POWER STEERING ASSIST RECALLS FOR THE SAME PROBLEMS, REF. MAZDA3/MAZDA5 POWER STEERING RECALL NOTIFICATION 6010H.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11258660September 27, 2019
STEERING
MY POWER STEERING INTERMITTENTLY GOES OUT FROM TIME TO TIME. I HAVE TAKEN IT TO THE SHOP 4 TIMES. THERE IS SOMETHING SERIOUSLY WRONG WITH THIS DESIGN AND THE VEHICLE IS VERY DANGEROUS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11233495July 19, 2019
STRUCTURE:BODY
SEVERE OUTSIDE PAINT DEGREDATION WITH 54,000 MILES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mazda RX-8