Mazda CX-5 Service Bulletins (2013)
824 manufacturer communications on file.
- June 24, 2016•Document ID: 10092941Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- 09-041-16-3212
- Date Added:
- February 25, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES MAY EXPERIENCE A RATTLE NOISE FROM THE FRONT DOOR GLASS WHEN DRIVING WITH THE WINDOW OPEN APPROX. 1/2 TO 4 INCHES (1 - 10 CM).THE RATTLE NOISE MAY BE CAUSED BY INSUFFICIENT HOLDING FORCE OF THE GLASS RUN CHANNEL. TO INCREASE THE HOLDING FORCE, THE SHAPE OF GLASS RUN CHANNEL HAS BEEN CHANGED AND NON-WOVEN PADS HAVE BEEN ATTACHED TO THE GLASS RUN CHANNEL.
Associated Products (4)Associated Documents - June 24, 2016•Document ID: 10092922Service Bulletin/Repair InstructionsVISIBILITY:SUN/MOON ROOF ASSEMBLY
- Mfr Comm. #:
- 09-040-16-3214
- Date Added:
- February 24, 2017
- Manufacturer:
- MAZDA
SummarySOME CUSTOMERS MAY COMPLAIN THAT IN EXTREME COLD WEATHER CONDITIONS, THE SUNROOF MAY SUDDENLY OPEN BY ITSELF WHEN THE HEATER IS ON. THIS CONCERN MAY BE DUE TO A SHORT IN THE SUNROOF SWITCH (A) CAUSED FROM CONDEN-SATION GENERATED BETWEEN THE ROOF PANEL AND THE SEAL. TO ELIMINATE THIS CONCERN IN THE FUTURE, A PROTECTIVE FILM HAS BEEN INSTALLED TO THE SWITCH AND A PAD INSTALLED TO THE HARNESS.
Associated Products (9)Associated Documents - June 24, 2016•Document ID: 10092724Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 1080M
- Date Added:
- February 23, 2017
- Manufacturer:
- MAZDA
SummaryIF AN ENGINE ASSEMBLY IS REPLACED AFTER A CATASTROPHIC INTERNAL MECHANICAL FAILURE, CLEAN THE INTAKE MANIFOLD INTERNALLY BEFORE INSTALLING A REPLACEMENT ENGINE ASSEMBLY. IF THE INTAKE MANIFOLD IS NOT CLEANED PROPERLY, THE REPLACEMENT ENGINE MAY FAIL PREMATURELY.METALLIC DEBRIS FROM THE OLD ENGINE (WITH CATASTROPHIC INTERNAL MECHANICAL FAILURE) MAY REST INSIDE THE INTAKE MANIFOLD. WHEN THE NEW ENGINE ASSEMBLY IS INSTALLED, DEBRIS IN THE INTAKE MANIFOLD WILL BE INGESTED INTO THE NEW ENGINE AND CAUSE INTERNAL DAMAGE.CLEAN THE INTAKE MANIFOLD INTERNALLY TO REMOVE ANY DEBRIS FROM OLD ENGINE BEFORE INSTALLING THE NEW REPLACEMENT ENGINE ASSEMBLY.IF THE INTAKE MANIFOLD CANNOT BE PROPERLY CLEANED INTERNALLY, REPLACE IT.
Associated Products (71)2017 Mazda Mazda22017 Mazda Mazda32017 Mazda Mazda62016 Mazda CX-32016 Mazda CX-52016 Mazda CX-92016 Mazda Mazda22016 Mazda Mazda32016 Mazda Mazda52016 Mazda Mazda62016 Mazda MX-52015 Mazda CX-52015 Mazda CX-92015 Mazda Mazda22015 Mazda Mazda32015 Mazda Mazda52015 Mazda Mazda62015 Mazda MX-52014 Mazda CX-52014 Mazda CX-9+ 51 moreAssociated Documents - June 24, 2016•Document ID: 10092719Service Bulletin/Repair InstructionsSERVICE BRAKES
- Mfr Comm. #:
- 1079M
- Date Added:
- February 23, 2017
- Manufacturer:
- MAZDA
SummaryIN CERTAIN CONDITIONS, SMART CITY BRAKE SUPPORT (SCBS) MAY OPERATE UNINTENTIONALLY. THE OWNER'S MANUAL PROVIDES 7 EXAMPLES: OBJECTS ON THE ROAD AT THE ENTRANCE TO A CURVE.VEHICLES PASSING IN THE OPPOSITE LANE WHILE MAKING A CURVE.METAL OBJECTS, BUMPS, OR PROTRUDING OBJECTS ON THE ROAD.WHEN PASSING THROUGH A TOLL GATE.WHEN PASSING UNDER A VINYL CURTAIN OR FLAG.PLASTIC OBJECTS SUCH AS PYLONS.TWO-WHEELED VEHICLES, PEDESTRIANS, ANIMALS OR STANDING TREES.THIS M-TIP ARTICLE PROVIDES 2 ADDITIONAL EXAMPLES:A. THERE IS FOGGING ON THE INNER SURFACE OF THE WINDSHIELD.B. THERE IS/ARE FOGGING/WATER DROPS ON THE OUTER SURFACE OF THE WINDSHIELD.THE NEAR INFRARED LASER BEAM IS A LIGHT BEAM AND IS REFRACTED BY WATER DROPS OR FOREIGN MATERIAL ON THE WINDSHIELD. IN THIS CASE, THE NEAR INFRARED LASER BEAM MAY NOT DETECT AN OBSTRUCTION AHEAD CORRECTLY.
Associated Products (16)Associated Documents - June 24, 2016•Document ID: 10092071Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR; VISIBILITY:GLASS, SIDE/REAR
- Mfr Comm. #:
- 09-041-16-3212
- Date Added:
- February 17, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES MAY EXPERIENCE A RATTLE NOISE FROM THE FRONT DOOR GLASS WHEN DRIVING WITH THE WINDOW OPEN APPROX. 1/2 TO 4 INCHES (1 - 10 CM).THE RATTLE NOISE MAY BE CAUSED BY INSUFFICIENT HOLDING FORCE OF THE GLASS RUN CHANNEL. TO INCREASE THE HOLDING FORCE, THE SHAPE OF GLASS RUN CHANNEL HAS BEEN CHANGED AND NON-WOVEN PADS HAVE BEEN ATTACHED TO THE GLASS RUN CHANNEL.
Associated Products (4)Associated Documents - June 24, 2016•Document ID: 10092070Service Bulletin/Repair InstructionsVISIBILITY:SUN/MOON ROOF ASSEMBLY
- Mfr Comm. #:
- 09-040-16-3214
- Date Added:
- February 17, 2017
- Manufacturer:
- MAZDA
SummarySOME CUSTOMERS MAY COMPLAIN THAT IN EXTREME COLD WEATHER CONDITIONS, THE SUNROOF MAY SUDDENLY OPEN BY ITSELF WHEN THE HEATER IS ON. THIS CONCERN MAY BE DUE TO A SHORT IN THE SUNROOF SWITCH (A) CAUSED FROM CONDEN-SATION GENERATED BETWEEN THE ROOF PANEL AND THE SEAL. TO ELIMINATE THIS CONCERN IN THE FUTURE, A PROTECTIVE FILM HAS BEEN INSTALLED TO THE SWITCH AND A PAD INSTALLED TO THE HARNESS.
Associated Products (9)Associated Documents - June 24, 2016•Document ID: 10085289Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 1080M
- Date Added:
- December 1, 2016
- Manufacturer:
- MAZDA
SummaryIF AN ENGINE ASSEMBLY IS REPLACED AFTER A CATASTROPHIC INTERNAL MECHANICAL FAILURE, CLEAN THE INTAKE MANIFOLD INTERNALLY BEFORE INSTALLING A REPLACEMENT ENGINE ASSEMBLY. IF THE INTAKE MANIFOLD IS NOT CLEANED PROPERLY, THE REPLACEMENT ENGINE MAY FAIL PREMATURELY.METALLIC DEBRIS FROM THE OLD ENGINE (WITH CATASTROPHIC INTERNAL MECHANICAL FAILURE) MAY REST INSIDE THE INTAKE MANIFOLD. WHEN THE NEW ENGINE ASSEMBLY IS INSTALLED, DEBRIS IN THE INTAKE MANIFOLD WILL BE INGESTED INTO THE NEW ENGINE AND CAUSE INTERNAL DAMAGE.CLEAN THE INTAKE MANIFOLD INTERNALLY TO REMOVE ANY DEBRIS FROM OLD ENGINE BEFORE INSTALLING THE NEW REPLACEMENT ENGINE ASSEMBLY.IF THE INTAKE MANIFOLD CANNOT BE PROPERLY CLEANED INTERNALLY, REPLACE IT
Associated Products (71)2017 Mazda Mazda22017 Mazda Mazda32017 Mazda Mazda62016 Mazda CX-32016 Mazda CX-52016 Mazda CX-92016 Mazda Mazda22016 Mazda Mazda32016 Mazda Mazda52016 Mazda Mazda62016 Mazda MX-52015 Mazda CX-52015 Mazda CX-92015 Mazda Mazda22015 Mazda Mazda32015 Mazda Mazda52015 Mazda Mazda62015 Mazda MX-52014 Mazda CX-52014 Mazda CX-9+ 51 moreAssociated Documents - June 24, 2016•Document ID: 10085288Service Bulletin/Repair InstructionsSERVICE BRAKES
- Mfr Comm. #:
- 1079M
- Date Added:
- December 1, 2016
- Manufacturer:
- MAZDA
SummaryIN CERTAIN CONDITIONS, SMART CITY BRAKE SUPPORT (SCBS) MAY OPERATE UNINTENTIONALLY. THE OWNER'S MANUAL PROVIDES 7 EXAMPLES: OBJECTS ON THE ROAD AT THE ENTRANCE TO A CURVE.VEHICLES PASSING IN THE OPPOSITE LANE WHILE MAKING A CURVE.METAL OBJECTS, BUMPS, OR PROTRUDING OBJECTS ON THE ROAD.WHEN PASSING THROUGH A TOLL GATE.WHEN PASSING UNDER A VINYL CURTAIN OR FLAG.PLASTIC OBJECTS SUCH AS PYLONS.TWO-WHEELED VEHICLES, PEDESTRIANS, ANIMALS OR STANDING TREES.THIS M-TIP ARTICLE PROVIDES 2 ADDITIONAL EXAMPLES:A. THERE IS FOGGING ON THE INNER SURFACE OF THE WINDSHIELD.B. THERE IS/ARE FOGGING/WATER DROPS ON THE OUTER SURFACE OF THE WINDSHIELD.THE NEAR INFRARED LASER BEAM IS A LIGHT BEAM AND IS REFRACTED BY WATER DROPS OR FOREIGN MATERIAL ON THE WINDSHIELD. IN THIS CASE, THE NEAR INFRARED LASER BEAM MAY NOT DETECT AN OBSTRUCTION AHEAD CORRECTLY.
Associated Products (15)Associated Documents - June 20, 2016•Document ID: 10092916Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 01-011-16-3139A
- Date Added:
- February 24, 2017
- Manufacturer:
- MAZDA
SummaryWHEN THE ENGINE IS STARTED FOR THE FIRST TIME AFTER PARKING THE VEHICLE OVERNIGHT IN COLD CONDITIONS (BELOW 32 DEGREES FAHRENHEIT / 0 DEGREES CELSIUS), SOME VEHICLES MAY EXHIBIT A ROUGH IDLE AND/OR THE CHECK ENGINE LIGHT ON WITH ANY OF THE FOLLOWING DTC(S) STORED IN MEMORY.P0300 - RANDOM MISFIRE DETECTEDP0301 - CYLINDER NO.1 MISFIRE DETECTEDP0302 - CYLINDER NO.2 MISFIRE DETECTED P0303 - CYLINDER NO.3 MISFIRE DETECTED P0304 - CYLINDER NO.4 MISFIRE DETECTED THIS MAY BE CAUSED BY FROZEN WATER ACCUMULATED IN THE MAIN SILENCER, RESTRICTING EXHAUST FLOW.
Associated Products (10)Associated Documents - June 20, 2016•Document ID: 10092062Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 01-011-16-3139A
- Date Added:
- February 17, 2017
- Manufacturer:
- MAZDA
SummaryWHEN THE ENGINE IS STARTED FOR THE FIRST TIME AFTER PARKING THE VEHICLE OVERNIGHT IN COLD CONDITIONS (BELOW 32 DEGREES FAHRENHEIT / 0 DEGREES CELSIUS), SOME VEHICLES MAY EXHIBIT A ROUGH IDLE AND/OR THE CHECK ENGINE LIGHT ON WITH ANY OF THE FOLLOWING DTC(S) STORED IN MEMORY.P0300 - RANDOM MISFIRE DETECTEDP0301 - CYLINDER NO.1 MISFIRE DETECTEDP0302 - CYLINDER NO.2 MISFIRE DETECTED P0303 - CYLINDER NO.3 MISFIRE DETECTED P0304 - CYLINDER NO.4 MISFIRE DETECTED THIS MAY BE CAUSED BY FROZEN WATER ACCUMULATED IN THE MAIN SILENCER, RESTRICTING EXHAUST FLOW.
Associated Products (10)Associated Documents - June 16, 2016•Document ID: 10092783Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 01-009-16-3172B
- Date Added:
- February 24, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES MAY EXPERIENCE A ROUGH IDLE WITH THE CHECK ENGINE LIGHT ON AND DTC P0015 / P0524 STORED IN MEMORY.P0015:00 - EXHAUST CMP TIMING OVER-RETARDEDP0524:00 - ENGINE OIL PRESSURE TOO LOWTHIS IS CAUSED BY A DROP IN ENGINE OIL PRESSURE DUE TO A PIECE OF FOREIGN OBJECT STUCK ON THE OIL PUMP PRESSURE RELIEF VALVE OR OIL CONTROL VALVE (OCV). THE TEMPORARY ENTRY OF THE FOREIGN OBJECT TRIGGERS A CHECK ENGINE LIGHT ON, BUT ROUGH IDLE WILL NOT BE PRODUCED UNTIL A LATER TIME.
Associated Products (13)Associated Documents - June 16, 2016•Document ID: 10092061Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 01-009-16-3172B
- Date Added:
- February 17, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES MAY EXPERIENCE A ROUGH IDLE WITH THE CHECK ENGINE LIGHT ON AND DTC P0015 / P0524 STORED IN MEMORY.P0015:00 - EXHAUST CMP TIMING OVER-RETARDEDP0524:00 - ENGINE OIL PRESSURE TOO LOWTHIS IS CAUSED BY A DROP IN ENGINE OIL PRESSURE DUE TO A PIECE OF FOREIGN OBJECT STUCK ON THE OIL PUMP PRESSURE RELIEF VALVE OR OIL CONTROL VALVE (OCV). THE TEMPORARY ENTRY OF THE FOREIGN OBJECT TRIGGERS A CHECK ENGINE LIGHT ON, BUT ROUGH IDLE WILL NOT BE PRODUCED UNTIL A LATER TIME.
Associated Products (13)Associated Documents - June 10, 2016•Document ID: 10092781Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:IGNITION
- Mfr Comm. #:
- 01-014-16-3208
- Date Added:
- February 24, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES MAY EXPERIENCE A LACK OF ENGINE POWER/ROUGH IDLING AND THE CHECK ENGINE LIGHT ON WITH ONE OR MORE OF THE MISFIRE RELATED DTCS OF P0300:00, P0301:00, P0302:00, P0303:00 AND P0304:00. THIS CONCERN MAY BE CAUSED BY AN INTERNAL FAILURE OF THE IGNITION COIL(S) DUE TO A HIGH DIFFERENCE BETWEEN COLD AND WARM AMBIENT TEMPERATURES. THE PRODUCTION METHOD OF THE IGNITION COIL HAS BEEN CHANGED TO ELIMINATE THIS CONCERN.
Associated Products (12)Associated Documents - June 10, 2016•Document ID: 10092026Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 01-014-16-3208
- Date Added:
- February 16, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES MAY EXPERIENCE A LACK OF ENGINE POWER/ROUGH IDLING AND THE CHECK ENGINE LIGHT ON WITH ONE OR MORE OF THE MISFIRE RELATED DTCS OF P0300:00, P0301:00, P0302:00, P0303:00 AND P0304:00. THIS CONCERN MAY BE CAUSED BY AN INTERNAL FAILURE OF THE IGNITION COIL(S) DUE TO A HIGH DIFFERENCE BETWEEN COLD AND WARM AMBIENT TEMPERATURES. THE PRODUCTION METHOD OF THE IGNITION COIL HAS BEEN CHANGED TO ELIMINATE THIS CONCERN.
Associated Products (12)Associated Documents - May 27, 2016•Document ID: 10092322Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 1102M
- Date Added:
- February 21, 2017
- Manufacturer:
- MAZDA
SummaryWORKSHOP MANUAL EVAP SYSTEM LEAK INSPECTION USING THE M-MDS HAS BEEN DISCONTINUED FOR SOME MODELS. INSTEAD, THE WORKSHOP MANUAL EVAP SYSTEM LEAK INSPECTION USING EVAP LEAK TESTER WILL BE USED TO TROUBLESHOOT EVAP SYSTEM LEAKS.
Associated Products (46)2017 Mazda CX-32017 Mazda Mazda62016 Mazda CX-32016 Mazda CX-52016 Mazda CX-92016 Mazda Mazda32016 Mazda Mazda52016 Mazda Mazda62016 Mazda MX-52015 Mazda CX-52015 Mazda CX-92015 Mazda Mazda22015 Mazda Mazda32015 Mazda Mazda52015 Mazda Mazda62014 Mazda CX-52014 Mazda CX-92014 Mazda Mazda22014 Mazda Mazda32014 Mazda Mazda5+ 26 moreAssociated Documents - May 10, 2016•Document ID: 10093288Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 09-009-16-3150A
- Date Added:
- March 1, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES MAY EXHIBIT BLUETOOTH® HANDS-FREE AND/OR TEXT MESSAGING RELATED CONCERNS. TO IMPROVE THE HANDLING OF BLUETOOTH® HANDS-FREE AND/OR TEXT MESSAGING CUSTOMER CONCERNS, MAZDA CRE-ATED A SPECIAL SERVICE AND PARTS EXCHANGE PROGRAM AS OF FEBRUARY 2010.CUSTOMERS EXPERIENCING RELATED CONCERNS SHOULD HAVE THEIR VEHICLE AND/OR DEVICE INSPECTED ACCORDING TO THE FOLLOWING PROCEDURE.
Associated Products (53)2016 Mazda CX-32016 Mazda CX-52016 Mazda CX-92016 Mazda Mazda32016 Mazda Mazda52016 Mazda Mazda62016 Mazda MX-52015 Mazda CX-52015 Mazda CX-92015 Mazda Mazda32015 Mazda Mazda52015 Mazda Mazda62015 Mazda MX-52014 Mazda CX-52014 Mazda CX-92014 Mazda Mazda32014 Mazda Mazda52014 Mazda Mazda62014 Mazda MX-52013 Mazda CX-5+ 33 moreAssociated Documents - May 10, 2016•Document ID: 10093276Service Bulletin/Repair InstructionsSEATS
- Mfr Comm. #:
- 09-031-16-3205
- Date Added:
- March 1, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES EQUIPPED WITH A 40:20:40 SPLIT TYPE REAR SEAT MAY BE UNABLE TO LOWER THE REAR SEATBACK (A) WHEN PULLING THE LEFT (B) AND/OR RIGHT (C) REMOTE HANDLES. ALSO, THE SEATBACKS MAY NOT FULLY LATCH (LOCK) WHEN PLACED IN THE UPRIGHT POSITION.THIS CONCERN MAY BE CAUSED BY EITHER OF THE FOLLOWING:INSUFFICIENT REMOTE CABLE TENSION DUE TO INCORRECT ADJUSTMENT POSITION (A) OF THE REMOTE CABLE.THE CABLE BALL (B) GETS SEIZED ON SHARP EDGES INSIDE THE CYLINDER.
Associated Products (4)Associated Documents - May 4, 2016•Document ID: 10092237Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- RF-16-03
- Date Added:
- February 18, 2017
- Manufacturer:
- MAZDA
SummaryTHE 2016 CX-9 WITH THE SKYACTIV®-G 2.5T ENGINE REQUIRES A UNIQUE OIL FILTER (PY8W-14-302) WHICH IS NOT INTERCHANGEABLE WITH OTHER SKYACTIV® OIL FILTERS. THE UNIQUE OIL FILTER CAN BE IDENTIFIED WITH TWO WHITE BANDS AS SHOWN BELOW.
Associated Products (15)Associated Documents - May 4, 2016•Document ID: 10092235Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- RF-16-02
- Date Added:
- February 18, 2017
- Manufacturer:
- MAZDA
SummaryTHERE IS AN EARLY AND LATE STYLE REAR HUB (D-CODES 26-112 / 26-112Z) AS SHOWN BELOW. AS STOCK IS EXHAUSTED OF THE EARLY HUBS THEY WILL BE PLACED IN A C (COMPONENT) SUPERSESSION SO THAT A NEW HUB AND ANY ADDITIONAL PARTS THAT MAY BE NEEDED ARE SHIPPED AT THE SAME TIME. WHEN GEPC VIN LOCK IDENTIFIES AN EARLY PART NUMBER, AS WITH ALL C (COMPONENT) SUPERSESSIONS, ORDER THAT PART NUMBER. DO NOT ORDER A NEWER PART LATER IN THE SUPERSESSION CHAIN. IF YOU ORDER THE EARLY PART SPECIFIED BY THE VIN, A NEW PART AND ANY ADDITIONAL PARTS THAT MAY BE NEEDED WILL SHIP. IF YOU ORDER A NEWER PART, JUST THE NEWER PART WILL SHIP. NO ADDITIONAL PARTS THAT MAY BE NEEDED WILL SHIP.
Associated Products (3)Associated Documents - April 29, 2016•Document ID: 10086522Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SA288
- Date Added:
- December 17, 2016
- Manufacturer:
- MAZDA
SummaryIF YOU ENCOUNTER A VEHICLE WITH DTC P0137 (CIRCUIT LOW INPUT), CHECK THE REAR HARNESS AT THE RED CIRCLED AREA IN THE FOLLOWING DIAGRAM. IF AN AFTERMARKET ALARM SYSTEM IS INSTALLED, THE REAR HARNESS MIGHT HAVE RECEIVED DAMAGE FROM ELECTRO-TAP CONNECTORS (A) OR TO THE PROTECTOR TUBE (B). THIS DAMAGE IS NOT COVERED UNDER WARRANTY.
Associated Products (13)Associated Documents