Lincoln Aviator Complaints

125 consumer complaints on file.

#11734097April 27, 2026
VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS
On 12/4/25, I visited Corley's Lincoln and reported several issues. One issue was that the vehicle would accelerate or decelerate while using cruise control. There were several other issues, but the following two issues are safety issues. I visited again on 3/5/26 with several of the same issues, although the speed issue was not listed on the work order. They could not find any issues, but I encountered the same issues on my drive home. I immediately returned to the dealer, and they kept the vehicle from 3/6/2026 to 4/2/26. Again, the speed issue was not listed on the work order. At this point, I began to keep a log. On 4/19/26, I set the speed at 56 MPH while driving on [XXX] , and within a short time the speed increased to 65 MPH before I stepped on the brakes. I have tested the cruise control several times since with the same result. Also on 4/19/26. I was braking to a stop on [XXX] , when the crash warning was activated. There was no one in front of me and no cross traffic. The only cars were in the opposite left-turn lane, 6 lanes away and completely stopped. This has happened several times, usually while slowing to a stop. I did not report the crash alert to the dealer until 4/20/26. As of 4/27/26, I am still awaiting to hear of a resolution from the dealer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733297April 23, 2026
BACK OVER PREVENTION
The contact owns a 2023 Lincoln Aviator. The contact stated while reversing, the rear-view camera did not function as intended. The contact stated that the rear-view camera display flipped the image to the front of the vehicle. In addition, the rear-view camera system did not alert the contact. The contact's vehicle crashed into a trailer. No injuries were sustained. No police report was filed. The contact vehicle sustained damage to the rear of the vehicle. The vehicle was taken to the dealer and the contact was informed that the back hatch needed to be replaced. The vehicle was being repaired. The contact later received a recall notification, NHTSA Campaign Number: 24V368000 (Back Over Prevention) however the parts were unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 24,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11730568April 11, 2026
UNKNOWN OR OTHER
Lincoln Way App team bricked (some) users by deploying an App update early Feb 2026 that was not backwards compatible for use of basic features/function. I last used App Jan 2026 while car was at dealer but when I picked up car 2/13/26 I was BRICKED with no ability to use App since. Checked Lincoln website & compatibility reqmt stated IOS 16.0 is min req’d, updates are optional & not required to continue use for basic features like lock/unlock, remote start, chk tire pressure, etc. (see screenshot attached). Opened case w/Lincoln Way App team 2/17/26. Ops mgr confirmed my iphone was compatible & iOS 16.0 was still min. reqmt. Said he’d escalate. Suddenly, wks later Lincoln updated website & changed compatibility requirements with NO NOTICE TO USERS (before or since) they’ve changed compatibility reqmts (they have users names, email, addr & phone #s since they’re req’d upon setup). In addition, NONE of the App version release notes shown in App Store indicate any change to Min compatibility reqmts. Development team is negligent & Lincoln needs to fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730564April 11, 2026
VISIBILITY/WIPER
REF RECALL 26V117 (Wiper Motor failure) & MY (2) PRIOR NHTSA COMPLAINTS; 11681607 & 11688314 (Autosense wiper operation failure). Autosense wiping does not clear wIndshield enough for visibility & therefore can’t be relied upon for safe driving. The only way to get MANUAL INTERMITTENT wiper operation is to go to SYNC settings & turn off auto wiper while driving in rain on Hwy at 65+ mph. Seriously?! THIS IS DISTRACTED DRIVING AT ITS WORST. Took dealer 2+ yrs to discover the shipping protective film used on wiper sensor was NOT removed by Chicago assembly plant prior to installing the sensor. Apr 2025, dealer replaced my sensor however it failed again by Aug 2025. Dealer had car 10/28/25-12/22/25 to fix multiple issues incl Autosense wiping. No codes appear & they can’t ID root cause of problem. Took car back for service 12/29/25-2/13/26 (multiple issues incl this) & they still can’t ID root cause. Given there’s now also a recall for wiper motor failure I requested a loaner from Lincoln CHQ but they have refused. I’M REQUESTING NHTSA REQUIRE LINCOLN TO PROVIDE LOANERS UNTIL THEY FIX ALL WIPER OPERATION FAILURES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730557April 11, 2026
STRUCTURE:BODY
REF C PILLAR RECALL & NHTSA Complaint # 11713372 by another owner on 11/18/25. NHTSA NEEDS TO ISSUE RECALL FOR A PILLARS. Have had wind noise issue on front passenger side since I bought car. Dealer looked at numerous times in 3 yrs & always stated ‘unable to recreate condition’ (likely due to not testing on Hwy at 65mph which is when this noise can be heard). Took car in for C Pillar recall fall 2025. Dealer said they weren’t loose so didn’t replace them. Left w/car 12/22/25 & immed heard wind noise on Hwy. Returned to service & this time, DEALER INSPECTED A PILLARS & FOUND RIGHT SIDE WAS LOOSE so replaced both. Tried to charge me (was 2 wks out of warranty) but given multiple attempted repairs during warranty & my open case w/CHQ they split repair cost. Thankfully A pillars didn’t break loose & injure human or another driver in past 3 yrs. Dealer told me Ford had A pillar recall but Lincoln’s weren’t included in it. There appears to be a pervasive issue with failure of the adhesive used for many parts by the assembly plant.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730549April 11, 2026
VISIBILITY/WIPER, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING, LANE DEPARTURE: BLIND SPOT DETECTION
THIS REQUIRES A RECALL ASAP. Dealers are well aware of this problem as is Lincoln CHQ but Lincoln refuses to address it. Rear camera cannot differentiate between steady rain & an object which then causes car to engage the collision avoidance system which then prevents ability to drive in reverse gear. There have been many rearview camera recalls on this car & each has made things worse. The ONLY way I can drive car in reverse (in rain) is to TURN OFF collision avoidance system (insane). Having to turn off this safety feature when it’s needed the most (in rain) is VERY dangerous. I tapped a person backing out of a parking spot. He was walking in blind spot, couldn’t see him on rearview camera, parking sensor alerts failed, collision avoidance was off because I can’t drive in reverse in rain. Thank God he wasn’t injured. BEGGING NHTSA TO FORCE A RECALL BEFORE A HUMAN GETS RUN OVER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728513April 1, 2026
SUSPENSION, SERVICE BRAKES, POWER TRAIN
My 2023 Lincoln Aviator has a grinding noise when I back up. Also a rattle has begun at all speeds. I had vehicled check and the axles were found to be totally rusted. Prior to having it towed to the detail i did some research and found the following -- A 2023 Lincoln Aviator recall regarding a "rusted" or breaking axle generally refers to a serious issue where the rear axle bolt can fracture, causing the rear subframe to disconnect, potentially leading to a loss of control or rollaway . This issue often stems from stress corrosion, prompting recalls for subframe inspections and repairs. [XXX] +4 Key Information regarding 2023 Lincoln Aviator Recalls: Safety Risk: A fractured rear axle bolt can cause the axle to disconnect, causing sudden power loss, severe vibration, and increased crash risk. Scope: While often associated with the 2020-2022 Ford Explorer/Aviator, owners should check for 2023 model year issues relating to rear axle subframe integrity. What to Do: Visit the official Lincoln Recall Page and enter your 17-digit Vehicle Identification Number (VIN) to check for this or other active recalls. Repair: Authorized Lincoln Dealerships will inspect the axle bolt and rear subframe, performing necessary repairs at no cost to the owner. I had vehicle towed to dealer and was told that there is no recall for this issue. see video link of axles. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724850March 17, 2026
INTERIOR LIGHTING
Interior front reading lights turn on and off randomly when driving and when not driving. This is incredibly distracting especially at night.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722796March 8, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
The vehicle is intermittently braking on its own while driving. The issue has become significantly worse over the course of a month. The dashboard message reads, “brake applied, power reduced”. This is a danger to both myself and other drivers as we are unable to control the speed of the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716405February 7, 2026
SUSPENSION
My car start making a very loud squeaking noise when I turn or hit any small bumb in the road. So I took it to the shop and was told both front lower ball joint boots are broken the exact same way. Now what bother me is what the mechanic said next. I quote " some type of suspension problem always happens on these cars. So my question is were there any recall about suspension on these cars? Online says yes. While my vin doesn't show one
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713372January 26, 2026
UNKNOWN OR OTHER
Regarding safety recall notice 25S66/NHTSA recall 25V407 - we took our car to the local Lincoln dealer in Lubbock (Gene Messer Ford/Lincoln) in late November for the repair of the recall "C-Pillar Applique Delamination." There was considerable wind/rattle noise coming from the passenger side, which is a component of the recall. After completing the recall we noticed the wind/rattle noise is still there and even slightly worse. We have contacted the service representative at Gene Messer Ford/Lincoln regarding this and have yet to receive a reply. We are reaching out to you for a solution to the noise problem. Any help is much appreciated! Thanks for your time, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712909January 23, 2026
FUEL SYSTEM, GASOLINE, ENGINE
The contact owns a 2022 Lincoln Aviator. The contact stated that while driving at 35 MPH and entering the on-ramp, the vehicle stalled. The vehicle was restarted. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was towed to the local dealer, but the vehicle had not been diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 47,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709130January 6, 2026
BACK OVER PREVENTION
The contact owns a 2023 Lincoln Aviator. The contact stated that while attempting to reverse, the rear-view camera displayed a glitching screen. The vehicle was serviced under the NHTSA Campaign Number: 23V022000 (BACK OVER PREVENTION) by the previous owner; however, the repair failed to fix the vehicle. The contact stated that failure had occurred after the recall repair the first time, and the failure had occurred on several occasions. The manufacturer was not notified of the failure. The failure mileage was 43,300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707901December 30, 2025
POWER TRAIN
I purchased a brand new 2025 Lincoln Aviator on 9/27/25, with 33 miles on it. I do not even make it home from the dealer before it started making a scrubbing/grinding noise, which subsequently led to the replacement of the transfer case and transmission on a vehicle with approx 180 miles on it. It calls into question the safety, reliability and quality of the vehicle
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707659December 29, 2025
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
I have taken my car more times than I can count for recalls in the little time that I have owned my can bought new. My work requires me to drive a lot covering 6 states. Scheduling recall repairs has become a serious issue for me in a two year old car. As it seems that most of the recalls have been fixed except one small one where it sounds like wind is blowing in and the rear view camera and display work whenever it wants. A lot of time the screen just goes dark when it’s needed the most. I just recently took my car to the dealership bec the engine light came on and my car started sputtering g while driving. Ford serviced it and within a week it did the same thing and light was back on. This time it started not cranking easy time I had to get gas. As I was driving on hwy after fuel up my car started jerking and just shut down engine. I rolled over to shoulder and it took a hand full of tries to start and I got it home asap. I took back to ford and they said it was due to a fuel pump and needed to go to Lincoln. It’s been weeks now and my car is getting worse. I dont trust it to drive as I have had now two stalls and multiple hard starts where engine won’t turn over. With me on highway a lot and no recall repairs i. Sore as Lincoln said I’m not sure what to do. This is very dangerous. I was lucky I wasn’t in Heavy traffic or crossing over lanes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706296December 20, 2025
ENGINE, FUEL/PROPULSION SYSTEM
On July 25, 2025 my 2022 Lincoln Aviator Hybrid Grand Touring Edition stalled while driving on Interstate 25 in Colorado Springs. I lost partial control of the vehicle but was able to guide it onto the shoulder and allow it to coast to a stop. I had this vehicle towed to the dealership (where it was purchased new): Phil Long Lincoln, Motor City in Colorado Springs, Colorado. It has been there ever since (almost 5 months) and has not been repaired. The service department suspects that the current safety recall issued July 8, 2025 (NHTSA Recall number: 25V455) was the root cause. They claim they could find nothing in the logs but they cannot rule out this as a problem. This is a life threatening issue with this vehicle and I have also been without my car for almost 5 months with repair available or capable by the dealer or Lincoln. This a very unreasonable amount of time and has been an undue burden upon me. I have sought to get a vehicle buy back under both the Lemon Law and the duration of this safety recall and they have refused (Lincoln corporate and the dealership). Please help.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705685December 17, 2025
VISIBILITY/WIPER
The driver-side front window regulator failed and was replaced on October 4, 2025. The passenger-side window regulator also failed and was removed and replaced on November 21, 2025. At the time each incident, the window would not raise using the car controls and remained stuck in the down position. Two window regulator failures on opposite sides of this vehicle just seven weeks and within roughly 2,400 miles apart does not indicate typical wear. It reflects a pattern failure consistent with a component defect. At the time of the October incident, I was actively driving the vehicle and the November incident when was while the car was parked, when the window failed and would not raise. After parking and then restarting my vehicle, the window remained fully or partially down and could not be returned to a closed and secured position. This created multiple safety and security risks, including: • Inability to secure the vehicle against theft or intrusion • Exposure to weather, rain, or debris • Increased cabin noise due to broken window • Risk of vehicle damage while parked without protection. The vehicle was left parked and unsecured solely due to the window malfunction. No police or insurance inspection occurred, as the incident did not involve a collision or theft, though the vehicle was left unsecured. The failure was diagnosed and confirmed by the manufacturer, Lincoln and independent service center Firestone Complete Auto Care, who completed the repair. There was No warning lamps or dashboard messages that appeared prior to or during the failure. Both window regulator failed suddenly and without warning. In my research, numerous Aviator owners have publicly reported identical regulator failures, (Reddit and YouTube) which further reinforces that this is a systemic issue, not an isolated event.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705135December 15, 2025
STRUCTURE:BODY
Rear door trim came loose and fell off while driving. Had the service department at the local dealership look at the missing trim on the rear of the car and they noticed multiple of the plastic clips holding the trim on the rear were broken and remained in the area where the trim was attached.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702357December 1, 2025
ENGINE, VISIBILITY/WIPER
1.) Exhaust System Failure (Flex Pipe / Catalytic Converter) The vehicle’s exhaust system—specifically the flex pipe connected to the catalytic converter—cracked and malfunctioned. This component is available for inspection upon request. As a result of the failure, exhaust fumes entered the cabin, creating a significant safety risk due to potential exposure to carbon monoxide. Prior to the failure, I noticed a persistent rattling noise at low speeds and while the vehicle was idling. The issue was inspected and confirmed by the dealership; however, I was informed that the repair falls outside of warranty coverage. I would like to know if this falls under safety hazard for emissions. 2.) Sunroof Glass Shattering Incident While driving, the sunroof glass suddenly shattered and appeared to implode outward. According to the dealership technicians, this may have been caused by thermal stress or frame-related tension. The glass is no longer intact but the remaining components and frame can be inspected upon request. The incident posed an immediate safety hazard to both myself and other road users due to the sudden loss of glass and the potential for debris. I did not observe any warning lamps, messages, or symptoms prior to the failure. After researching the issue, I found that similar sunroof glass failures have been reported across various Ford/Lincoln models, suggesting this may be a known manufacturer defect. The dealership has confirmed the damage but no inspection by the manufacturer, police, or insurance representatives has been conducted at this time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700095November 18, 2025
STRUCTURE:BODY
In addition to the recall for the C-pillar appliques and window division bars (NHTSA ID Number: 25V407000), the chrome trim piece directly below the window also suffers from insufficient adhesive bonding. See the photo below. It came lose while driving at high speeds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Lincoln Aviator