Lincoln Aviator Service Bulletins (2020)
328 manufacturer communications on file.
- September 12, 2022•Document ID: 10220380Service Bulletin/Repair InstructionsPOWER TRAIN; ELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 22-2342
- Date Added:
- September 23, 2022
- Manufacturer:
- FORD
SummarySome 2020-2022 Explorer/Aviator/Police Interceptor Utility vehicles equipped with a hybrid powertrain may exhibit an illuminated MIL with diagnostic trouble code (DTC) P2D40. This may be due to the chiller not interpreting the correct cooling value of the high voltage battery chiller. To correct the condition, follow the Service Procedure to diagnose the cause of the incorrect value.
Associated Products (6)Associated Documents - August 18, 2022•Document ID: 10218605Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; POWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- SSM 51032
- Date Added:
- August 22, 2022
- Manufacturer:
- FORD
SummarySome 2020-2022 Explorer/Aviator vehicles may exhibit automatic transmission fluid (ATF) contamination in the engine cooling system due to the transmission cooler. If the cooling system becomes contaminated with ATF, the system must be flushed clear of the contamination after the source of the contamination has been repaired. It is generally not necessary to replace the following components due to ATF contamination in the cooling system: radiator, heater core, de-gas bottle, water pump, auxiliary water pump, coolant control valves, temperature sensors, thermostat, turbocharger, heat exchangers, tubes, gaskets/O-rings/seals (unless removed), or rubber coolant hoses (unless swollen).
Associated Products (6)Associated Documents - August 8, 2022•Document ID: 10218619Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 22-2316
- Date Added:
- August 23, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Aviator Plug In Hybrid (PHEV) vehicles built on or before 14-Jan-2022 may exhibit a 12-volt battery discharged while the vehicle is plugged in during high voltage battery charging and/or inoperative level 2 charger (220/240 volts) at customers residence but charging performance operates as intended at a dealership or other locations. This may be due to the software in the battery charger control module (BCCM) (also known as secondary on-board diagnostic module SOBDM). To correct the condition, follow the Service Procedure to reprogram various modules starting with the PCM.
Associated Products (3)Associated Documents - August 1, 2022•Document ID: 10217830Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- SSM 50982
- Date Added:
- August 15, 2022
- Manufacturer:
- FORD
SummarySome 2018-2022 Ford/Lincoln vehicles equipped with a wireless charging pad may exhibit one of the following if the customer is using a Magsafe iPhone (iPhone 12 or 13): slow charging, inoperative, notification that the phone has been mispositioned on the charging pad and/or the phone charging icon in the center screen display is not showing. This may be due to a compatibility issue between the customer's phone and the wireless accessory charging module (WACM) that may make it difficult for Ford and Lincoln vehicles to wirelessly charge these specific phones. The phone can still be charged using the USB cable if the vehicle experiences the above symptoms. If the customer is using a Magsafe iPhone such as an iPhone 12 or 13, verify the wireless charging pad works with a Qi certified phone prior to any part replacements.
Associated Products (41)2021 Ford Bronco2021 Ford Bronco Sport2021 Ford Edge2021 Ford Escape2021 Ford Expedition2021 Ford Explorer2021 Ford F-1502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford Mustang Mach-E2021 Ford Transit Connect2021 Lincoln Aviator2021 Lincoln Corsair2021 Lincoln Nautilus2021 Lincoln Navigator2020 Ford Edge2020 Ford Escape2020 Ford Expedition+ 21 moreAssociated Documents - July 29, 2022•Document ID: 10217028Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 50975
- Date Added:
- August 2, 2022
- Manufacturer:
- LINCOLN
SummarySome 2017-2022 Ford/Lincoln customers may experience a notification in the FordPassÃÂÃÂÃÂî/LincolnWayÃÂÃÂÃÂî app indicating Vehicle Has Entered Deep Sleep Mode. This occurs when the vehicle has not been started for 14 consecutive days, battery voltage is at/below 9.5 volts or the body control module (BCM) 12 volt battery state of charge (SOC) drops below 50%. A warning may also set if the telematic control unit (TCU) has received an over the air update. The TCU powers down all communication when in this mode and app features are disabled. Manually start the vehicle to wake if from mode. More information is located in the app under: Account > Help > search 'Deep Sleep' in the entry box. If the condition remains, check the BCM 12v SOC. If the SOC does not change after charging the battery or after BMS reset is performed, continue with normal battery and/or BMS sensor diagnostics.
Associated Products (119)2022 Ford Bronco2022 Ford Bronco Sport2022 Ford Edge2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford GT2022 Ford Maverick2022 Ford Mustang2022 Ford Mustang Mach-E2022 Ford Ranger2022 Lincoln Aviator2022 Lincoln Corsair2022 Lincoln Nautilus2022 Lincoln Navigator2021 Ford Bronco2021 Ford Bronco Sport+ 99 moreAssociated Documents - July 27, 2022•Document ID: 10216956Service Bulletin/Repair InstructionsLATCHES/LOCKS/LINKAGES:DOORS:LATCH
- Mfr Comm. #:
- SSM 50967
- Date Added:
- August 2, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Aviator vehicles may exhibit a door ajar or door fault warning message present in the message center with diagnostic trouble codes (DTCs) B1175:19, B1176:19, B11C0:19 and/or B11C1:19 present in door latch control module E (DCME), door latch control module F (DCMF), door latch control module G (DCMG) and/or door latch control module H (DCMH). This may be due to low battery voltage and DTC thresholds being too low and not a fault in the door latch assembly. To correct the condition, reprogram and re-configure the the affected module using the latest level of the Ford Diagnosis and Repair System (FDRS). For claiming use causal part 54264A27 and applicable labor times found in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (3)Associated Documents - July 22, 2022•Document ID: 10216544Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- SSM 50959
- Date Added:
- July 29, 2022
- Manufacturer:
- LINCOLN
SummarySome 2019-2022 Edge/Nautilus, 2018-2022 Expedition/Navigator, 2020-2022 Explorer/Aviator vehicles equipped with a family entertainment system may experience the audio is not synchronized with the video display when using the vehicle speakers. To correct this condition, contact the VOXX Customer Service Department at 1-866-869-7888. For claiming, refer to the Warranty and Policy manual for Ford Licensed Accessories.
Associated Products (27)2022 Ford Edge2022 Ford Expedition2022 Ford Explorer2022 Lincoln Aviator2022 Lincoln Nautilus2022 Lincoln Navigator2021 Ford Edge2021 Ford Expedition2021 Ford Explorer2021 Lincoln Aviator2021 Lincoln Nautilus2021 Lincoln Navigator2020 Ford Edge2020 Ford Expedition2020 Ford Explorer2020 Lincoln Aviator2020 Lincoln MKX2020 Lincoln Nautilus2020 Lincoln Navigator2019 Ford Edge+ 7 moreAssociated Documents - July 8, 2022•Document ID: 10216057Service Bulletin/Repair InstructionsSUSPENSION
- Mfr Comm. #:
- SSM 50930
- Date Added:
- July 20, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2021 Aviator vehicles equipped with air suspension may exhibit a Drive Malfunction and/or Suspension Fault message in the instrument panel cluster (IPC) with diagnostic trouble codes (DTCs) B1041 and U2100 stored in the SUMA. This may be due to the SUMA entering into a diagnostic service mode after an on-demand self-test or module replacement. If no other DTCs are present, use the latest software version of the Ford Diagnosis and Repair System (FDRS) scan tool to update and configure the SUMA. If other DTCs are present, refer to Workshop Manual (WSM), Section 204-05 for normal diagnostics. For claiming use causal part 5319 and applicable labor times found in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (2)Associated Documents - July 1, 2022•Document ID: 10215589Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- TSB 22-2262
- Date Added:
- July 8, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Explorer/Aviator vehicles may exhibit a lack of audio and/or a water leak in the rear liftgate area and/or water in the spare tire area. The customer may indicate that this concern is more noticeable after a car wash or rainfall. To correct the condition, follow the Service Procedure to identify the leak path.
Associated Products (6)Associated Documents - June 29, 2022•Document ID: 10215368Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 50900
- Date Added:
- July 6, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Explorer/Aviator/Police Interceptor Utility vehicles may exhibit a rear differential that is venting rear axle fluid. This may result in a noise, smell, or leak noticed by the customer. Inspect the rear of the vehicle for signs of rear differential fluid venting in the right rear wheel well (oil staining in the wheel well liner and/or oil residue on the wheel end assembly below) or leaking from the rear differential. If signs of fluid leaks are found from any seals, repair as necessary. Refer to Workshop Manual (WSM), Section 205-02. If no seal leaks are found but fluid is venting, drain the rear differential and re-fill with fresh rear differential fluid. Remove the vent tube and use compressed air to verify that the fluid vent tube is clear. Reinstall the vent tube. Engineering is investigating, monitor OASIS for updates.
Associated Products (6)Associated Documents - June 29, 2022•Document ID: 10214878Service Bulletin/Repair InstructionsBACK OVER PREVENTION:SOFTWARE
- Mfr Comm. #:
- TSB 22-2254
- Date Added:
- July 1, 2022
- Manufacturer:
- FORD
SummarySome 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator, 2021 Bronco Sport and 2020-2022 Explorer/Aviator vehicles with SYNC 3 may experience various SYNC performance related concerns. This may be due to the SYNC Software. To correct the condition, follow the Service Procedure to update the accessory protocol interface module (APIM) software.
Associated Products (48)2022 Ford Explorer2022 Lincoln Aviator2021 Ford Bronco Sport2021 Ford Ecosport2021 Ford Escape2021 Ford Expedition2021 Ford Explorer2021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford Mustang2021 Ford Ranger2021 Ford Transit Connect2021 Lincoln Aviator2021 Lincoln Corsair2021 Lincoln Navigator2020 Ford Ecosport2020 Ford Edge2020 Ford Escape+ 28 moreAssociated Documents - June 28, 2022•Document ID: 10214870Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 22-2145
- Date Added:
- July 1, 2022
- Manufacturer:
- FORD
SummarySome 2018-2021 Expedition/Navigator and 2020-2021 Explorer/Aviator vehicles equipped with a 10R80/10R80 MHT or 10R60 may exhibit a momentary transmission neutral-out condition while in drive. Vehicle may also have diagnostic trouble code (DTC) P07E6 and/or P07E4 stored in the powertrain control module (PCM) or transmission control module (TCM) and/or a possible audible noise. This may be due to a leak in the park valve circuit. To correct the condition, follow the Service Procedure to inspect the park system hardware for wear or damage and replace the valve body separator plate with an improved valve body separator plate.
Associated Products (12)Associated Documents - June 24, 2022•Document ID: 10214841Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- SSM 50885
- Date Added:
- June 30, 2022
- Manufacturer:
- FORD
Summary2020-2022 Explorer/Aviator and 2021-2022 F-150 hybrid vehicles equipped with a 10R80 MHT require the Transmission Strategy Download application in the Ford Diagnosis and Repair System (FDRS) to be run after certain transmission or module repairs. The Transmission Strategy Download routine is failing in FDRS levels 32.5.3 and 32.5.4. The FDRS development team is working to resolve this in a future release of FDRS. In the meantime, uninstall FDRS from the computer using the select all function to remove all data and recordings. Reinstall the older FDRS version 31.6.5 using this url - http://www.fordservicecontent.com/Ford_Content/IDS/FDRS/FDRS_31.6.5.exe Once 31.6.5 is installed, download and run the Transmission Strategy Download application.
Associated Products (8)Associated Documents - June 23, 2022•Document ID: 10214839Service Bulletin/Repair InstructionsEQUIPMENT:APPLIANCE:TV/RADIO/SPEAKERS
- Mfr Comm. #:
- SSM 50882
- Date Added:
- June 30, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Explorer/Aviator vehicles may exhibit a concern of inoperative, rattling, crackling and/or distorted sound from one or more speakers. In order to correct the condition, make sure to completely follow the diagnostics in Workshop Manual (WSM), Section 415-00, Pinpoint Test D for vehicles without SYNC 3, and WSM, Section 415-00B, Pinpoint Test E for vehicles equipped with SYNC 3. If the diagnostics point towards speaker replacement, remove and re-center the speaker, making sure to tighten to the specified torque and retest. Refer to WSM, Section 415-00.
Associated Products (6)Associated Documents - June 22, 2022•Document ID: 10214825Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 50745
- Date Added:
- June 30, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Explorer/Aviator/Police Interceptor Utility vehicles may exhibit erratic transfer case operation and/or noise. This may be due to water intrusion between the transmission and the transfer case. The transfer case installation procedure has been updated in Workshop Manual (WSM), Section 307-07B to prevent this concern from reoccurring. Follow the updated WSM procedure to make sure the top of the transfer case is sealed upon installation.
Associated Products (6)Associated Documents - June 21, 2022•Document ID: 10214829Service Bulletin/Repair InstructionsINTERIOR LIGHTING
- Mfr Comm. #:
- SSM 50872
- Date Added:
- June 30, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Aviator vehicles may exhibit an issue transitioning to night mode in low ambient light conditions. This may be due to accessory protocol interface module (APIM) software. Inform customers that engineering is currently working on a solution for this condition and will be released via an over the air (OTA) software update expected in July 2023. Software will update automatically if the vehicle is connected to LincolnWay. Monitor OASIS for additional information. Schedule a service appointment for customers that are not connected to LincolnWay once the repair becomes available.
Associated Products (3)Associated Documents - June 21, 2022•Document ID: 10214832Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 50873
- Date Added:
- June 30, 2022
- Manufacturer:
- FORD
SummarySome 2017-2022 Ford and Lincoln vehicle owners may experience a condition of missing authorization, command and control, battery charging details or phone-as-a-key setup buttons/selections in their FordPass or LincolnWay App. This condition is due to an error within the FordPass or LincolnWay App and not due to a concern on the vehicle. Verify that the customers FordPass or LincolnWay App is at the latest version. Replacement or reprogramming of the telematics control unit (TCU)/gateway module (GWM)/remote function actuator (RFA) will not resolve this condition. If the condition persists, utilize the FordPass Guides or Lincoln Way Concierge teams.
Associated Products (86)2022 Ford Bronco Sport2022 Ford Edge2022 Ford Escape2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford Mustang2022 Ford Mustang Mach-E2022 Ford Ranger2022 Ford Transit Connect2022 Lincoln Aviator2022 Lincoln Corsair2022 Lincoln Navigator2021 Ford Bronco Sport2021 Ford Edge2021 Ford Escape+ 66 moreAssociated Documents - June 21, 2022•Document ID: 10214753Service Bulletin/Repair InstructionsFUEL SYSTEM, GASOLINE
- Mfr Comm. #:
- TSB 22-2176
- Date Added:
- June 27, 2022
- Manufacturer:
- FORD
SummarySome 2020-2022 Escape/Corsair vehicles built on or before 3-Jan-2022, 2020-2022 Explorer vehicles built on or before 14-Feb-2022, 2020-2022 Aviator vehicles built on or before 07-Feb-2022 and 2021-2022 Bronco Sport vehicles built on or before 3-Dec-2021 may exhibit a slow fuel fill and/or spit back condition during refueling. This may be due to the design of the fuel tank filler pipe. To correct the condition, follow the Service Procedure to replace the fuel tank filler pipe.
Associated Products (14)Associated Documents - June 20, 2022•Document ID: 10214496Service Bulletin/Repair InstructionsSEATS
- Mfr Comm. #:
- SSM 50868
- Date Added:
- June 29, 2022
- Manufacturer:
- FORD
SummarySome 2020-2022 Explorer/Aviator vehicles may exhibit a second row folding seat that is inoperative or requires excessive effort to fold. This may be due to tension built up within the seat and seat track that leads to more force required to manually fold the seat. To correct the condition, the second row seat frame will need to be unbolted from the floor and tightened in the correct sequence. Additionally, the sliding tracks of the seat should be inspected for proper alignment when tightening the bolts. It is important to note that the bolts should be started by hand before tightening to the correct torque. This sequence is outlined in Workshop Manual (WSM), Section 501-10. The WSM has been updated to reflect the updated bolt installation procedure.
Associated Products (6)Associated Documents - June 8, 2022•Document ID: 10214161Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 50845
- Date Added:
- June 17, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Corsair/Nautilus/Navigator/Aviator, 2021-2022 Mustang Mach-E vehicles equipped with Phone-as-a-Key may exhibit Phone-as-a-Key concerns and have diagnostic trouble code(s) (DTC) U200D:15, U200E:15, U200F:15, B15**:31, B15**:49 and/or B15A5:56 stored in the remote function actuator (RFA) module. If the vehicle is exhibiting other symptoms outside of Phone-as-a-key concerns, address those first. If any of these DTCs are detected during diagnostics, clear the DTCs, reflash RFA to the latest software level and start a new Ford Diagnosis and Repair System (FDRS) session. Verify that DTCs are no longer present. If only the B15**:31, B15**:57 and/or B15A5:56 DTC(s) returns in the RFA after a self test, follow normal Workshop Manual (WSM) diagnostics, Section 419-01C.
Associated Products (16)2022 Ford Mustang Mach-E2022 Lincoln Aviator2022 Lincoln Corsair2022 Lincoln Nautilus2022 Lincoln Navigator2021 Ford Mustang Mach-E2021 Lincoln Aviator2021 Lincoln Corsair2021 Lincoln Nautilus2021 Lincoln Navigator2020 Lincoln Aviator2020 Lincoln Corsair2020 Lincoln MKX2020 Lincoln Nautilus2020 Lincoln Navigator2007 Lincoln MKXAssociated Documents