Kia Carnival Complaints

515 consumer complaints on file.

#11739601May 22, 2026
ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM, POWER TRAIN
The contact owns a . The contact stated that while parked when the brake was depressed, press start button, when put in reverse, it says gear is selected, the vehicle stayed in neutral. This happens intermittently. The stop button was pressed, all of the instrument panel warning indicators would not illuminate. When pressing p for parking to engage parking, it appeared as if it was in park; however the vehicle unexpectedly reversed. The vehicle was able to be stopped. The vehicle was taken to the dealer where the issue could not be duplicated. The manufacturer was not notified of the issue. The approximate mileage was 2,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739119May 20, 2026
SEATS
The contact owns a 2025 Kia Carnival. the driver seat automatically pushed on the rear passenger driver side seat that had a minor occupant in a child seat. The seat was able to move forward with the seat adjustment buttons. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The approximate failure mileage 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738682May 19, 2026
ELECTRICAL SYSTEM
Battery died at under 3,300 miles. After roadside came and jumped the batter, it died again after two days. Jumped again for the second time, when driving the car around it would randomly shut off even when the car is moving at higher speeds on freeway. The shut off would be for just one second and comes back on - everything starts resetting. And goes to user authoriztions notifications. Car shut off three times while driving around.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738446May 18, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM
My 2022 Kia Carnival, approximately 80,000 miles, had intermittent dashboard warning lights and grinding brake noise for a few weeks. I brought the vehicle to Tasca Kia White Plains first time on 4/14/26 then again on 5/8/26. The dealership initially could not reproduce the issue, then later suspected an ABS sensor issue and ordered the part. On 5/12/26, before the repair was completed, I was driving downhill with my children in the vehicle when the brakes failed to respond properly. I had to steer off the roadway and go over rocks/boulders to stop the vehicle. At that time, the brakes would not respond normally, and I could not immediately shift the vehicle into Park. Police and towing services were involved. The dealership later replaced an ABS sensor. However, when I reviewed the codes with the service manager, I was told the ABS sensor code did not appear on the date of the brake incident. I was also told that an ABS sensor failure itself would not typically cause hydraulic brake failure. I am concerned that the sensor replacement does not explain the brake failure and that this may involve a brake/ABS/electronic stability control safety issue.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11737829May 14, 2026
UNKNOWN OR OTHER
Our Carnival had the SC266 recall repair done on July 3rd, 2023, at 3074 miles. Then our [XXX] daughter was injured as a result of the safety function not working and the door closed without any chimes. [XXX] (my spouse) is a cardiac nurse at our local hospital, and I have combat medical training, so we took care of the minor injury. Her small hand was spared the devastation a larger one would suffer. The dealership is pretending it’s unreproducible (even though I supplied them with video evidence to the contrary), and Kia Corporate (case # XXX) doesn’t appear any more likely to help. I reported the injury when it occurred on January 13th, 2026, to the dealership. They said they were sorry and would look into it. Nothing happened. I call, and they say they can’t fix it. I call again after I see the XXX v. XXX, et al., case was allowed to proceed, and I produce videos confirming the safety issue with sticks. They bring it in and claim in their exact words in the paperwork, “Found Doors to chime when an “abstruction” was present in the doorway and vehicle doors to stop when detecting an object. Started T/L case for documentation purposes.” In private, they tell me, “We cannot stop the force of the closing or fix it” and do not allow me to reproduce the safety issue for them to witness. I file a complaint with Corporate, and they tell me the dealership is saying it’s fine. I send the videos, and they say they will look into it. No resolution. Today, I produced a second set of videos to show the devastation the safety issue causes and the lack of response from the sensor, chimes, or the reopening of the door from an obstruction using bananas after the dealership declared it not reproducible. My special needs [XXX] daughter was harmed as pictured. The van itself is unsafe for children, which is the only reason anyone (including me) would purchase it. My children could be harmed again, but we cannot afford the burden of another car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 55
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11737633May 13, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2025 Kia Carnival. The contact received the recall letter for NHTSA Campaign Number: 26V320000 ( NA) The local dealer was contacted but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737299May 12, 2026
UNKNOWN OR OTHER
Passenger sliding door failed to detect my son and closed completely on his arm. The doors will push the kids and don’t detect even adults at times. He now has a buckle fracture that they are concerned is a full fracture in both bone on his forearm. He is [XXX] old. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11737111May 11, 2026
ELECTRICAL SYSTEM
The contact owns a 2025 Kia Carnival. The contact’s daughter stated that while driving approximately 10 MPH, the vehicle unexpectedly lost motive power with no warning lights illuminated. The vehicle failed to restart and was towed to the dealer. The dealer informed the contact that the battery solenoid needed to be replaced; however, the vehicle was not diagnosed or repaired. The contact stated that the failure recurred on multiple occasions. The vehicle was taken to the dealer several times. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 4,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736945May 11, 2026
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The contact owns a 2024 Kia Carnival. The contact stated that while her husband was loading the child into the car seat. The rear button for the door was depressed by the child. The husband became stuck in between the sliding doors. No warning lights were illuminated. The contact sustained injuries to his previously injured rotary cuff, but medical attention was not provided. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 35,815.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11735023May 1, 2026
ENGINE
Despite being only 18 months old with under 26,000 miles, the vehicle suffered a catastrophic failure with no prior dashboard warnings. While driving at highway speeds, loud cracking noises occurred while the engine was running, though we were able to pull off safely. The incident resulted in a burning smell, fumes, and rapid battery drain; subsequent inspection revealed a sheared tensioner spring and a critical VDCU diagnostic code (P1A7795), indicating a "Check Generator Belt" error and a major hybrid power control system failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735144May 1, 2026
STRUCTURE
The contact owns a 2025 Kia Carnival. The contact stated that while driving in warm weather, heat from the exhaust pipe could be felt inside the cabin of the vehicle. As a result, the second row floor would become hot and cause discomfort to occupants seated in the second row. Upon investigation, the contact discovered TSB(Technical Service Bulletin) PI2501, which accurately described the failure the contact had experienced. The vehicle was taken to a dealer where they informed the contact that the TSB remedy was performed on the vehicle prior his ownership. The manufacturer was also notified of the failure and was given the same information as the dealer. The contact was then given a case number and was then referred to the NHTSA Hotline to file a complaint. The vehicle had not been repaired. The failure mileage was approximately 2,5000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734940April 30, 2026
LANE DEPARTURE: WARNING
I am submitting a safety complaint regarding the driver monitoring/driver assistance system in the 2025 Kia Carnival. The system repeatedly issues “take a break” or inattentive driver warnings during normal, attentive driving conditions. These alerts are overly sensitive, frequent, and intrusive. Rather than improving safety, the warnings are highly distracting. The visual and audible alerts demand attention at critical moments, pulling focus away from the road. This creates a counterproductive and potentially hazardous situation, especially in traffic or complex driving environments. There appears to be no reasonable way to adjust the sensitivity or disable these alerts without impacting other safety features. A driver assistance system should support the driver—not introduce additional distraction or frustration. I request that this issue be investigated, including the calibration, trigger thresholds, and user control options for the system. A redesign or update may be necessary to ensure the feature enhances safety instead of undermining it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734933April 30, 2026
Chest Clip, Buckle, Harness
The harness straps on the seat have begun to loosen while my child is riding in the seat. You do not need to use the harness adjuster button to loosen the straps. This is allowing a secure fit to become dangerously loose while the vehicle is in motion. I removed the car seat from the vehicle and was able to replicate the issue. A slight tug or movement makes the straps become loose and I can pull them completely out of the shell without using the harness adjuster. This is the same issue that started the Rava recall recently. The harness adjuster is clear of any debris and fully covered by fabric in this seat. There is no valid explanation to this other than a manufacturer defect. The seat is a few years old and has been used daily since receipt in Spring of 2023. It was purchased from the manufacturers website. One minor crash and the seat was not replaced because of the manufacturers stance on replacement (crash was May of 2024). This has been reported to the manufacturer as of 4/29/26.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734512April 29, 2026
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
-A "Check Hybrid system. Stop safely. " warning has come on 7 times now. The vehicle loses power and slows down abruptly before coming to a complete halt. This has happened on railroad tracks, the highway, and an intersection where my wife and children were almost hit by other motorists. The dealer has not been able to reproduce the code, but we have pictures and videos of said incidents. The vehicle has been inspected by Kia technicians and "fixed" multiple times, but this keeps happening and I will not risk my family's lives any longer. There has been zero warning every time this system failure has occurred. We are undergoing a buyback process with Kia corporate and are prepared to take legal action under Georgia state lemon laws. Thank you for your time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734511April 29, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
I am reporting a safety defect involving my 2023 Kia Carnival SX Prestige. On June 6, 2025, I brought the vehicle to Yonkers Kia Service Center because of a strong gasoline odor. The dealership told me the fuel tank was swollen and that the vehicle was unsafe to drive. The vehicle remained at the dealership from June 6, 2025 through October 17, 2025. Kia later indicated that the fuel tank, canister, and vent valve had been replaced. When the vehicle was returned to me on October 17, 2025, it still smelled like gas. Within 24–48 hours, the same or related safety issues returned, including strong fuel odor, loss of engine power, check engine light, abnormal fuel consumption, and later a visible fuel leak, which I documented on video. Because the vehicle did not feel safe, I stopped driving it on October 19, 2025. In March 2026, the vehicle was towed back to Kia for renewed diagnosis. Kia later reported that one fuel injector was leaking and performed additional repairs. My VIN now shows open unrepaired Recall SC368 / NHTSA Recall 26V232. That recall states that the high-pressure cross-over fuel pipe nuts may loosen over time, resulting in a fuel leak and fire risk. The recall warning signs include fuel smell and/or check engine light, which directly overlap with the exact symptoms I repeatedly experienced and reported. I am reporting that this vehicle had repeat fuel-related safety failures, a prior extended repair attempt that did not resolve the issue, and was previously returned to me in what I believe was an unsafe condition.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734666April 29, 2026
ENGINE
Carnival was working fine then, without warning, I was unable to accelerate. Had entered highway and reached a maximum speed around 30 mph in a 55 mph zone. Pedal fully depressed and zero acceleration, dashboard read "check hybrid system, stop safely". Tried changing driving modes to no effect. Lots of cars speeding past as I pulled to the side to restart the vehicle, then it worked again without issue. Happened one other time, similar circumstances and results.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734515April 29, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Kia Carnival. The contact received notification of NHTSA Campaign Number: 26V320000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734153April 27, 2026
ENGINE
Our 2024 Carnival has had a recurring engine oil leak that has required the vehicle to be left at the dealership 4 times for the same issue. Each time we get the van back the repair lasts about 1-3 weeks (depending on how often it's driven). Oil continues to leak from the engine area, creating risk of engine damage or a potential fire hazard if oil contacts hot components. The issue has not been resolved despite repeated repair attempts under warranty. The Carnival has 38,092 miles on it, and has been in the repair shop over 4 times. The 1st time it was put in the shop the van has 34,420 miles on it. Each time it has been left at the dealership for 9 - 17 days while the repairs were made. We have brought it to the same dealership each time and they have been very sympathetic and helpful. Not only does this issue cause the risks mentioned above, but it has ruined the concrete in my garage as well as added oil to the roadway which could cause an accident. I have all the repair orders from the first 3 repairs that I will attach. However I do not have thee current one because the vehicle is currently being repaired for the 4th time and I haven't received the finalized repair order documents. I can update this claim once the repairs are completed. I will be contacting Kia tomorrow and wanted to have a claim number started.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734099April 27, 2026
POWER TRAIN
I purchased this 2024 Kia Carnival on 2/7/2026 with less than 10K miles. The vehicle has died while I was driving 4 different times. Twice each day that it happened. The first time was on 4/7/26. My car died on the way home from getting my kids from school after fixing a flat tire. The check engine light came on after getting a jump and when I took it to Auto Zone the battery was fully charged and the codes were for the Power Train, which didn't make sense for a brand new car. Miracle Mart told me that Kia needed to be utilized for any issues because I purchased the vehicle as is. Their solution was to tighten the "loose cables". On 4/25/26 the car died again two more times. Something is terribly wrong with this car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733144April 22, 2026
ENGINE, UNKNOWN OR OTHER
On the motor, when off for more than a certain time prolonged, when is a cold start motor make a noise like it doesn’t have oil in it since new I let the dealer know but they say it’s normal and I don’t believe so. Also, the transmission have a problem since New it shifted weird sometimes, and the dealer says it’s normal
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Carnival