Hyundai Veloster Complaints (2013)

427 consumer complaints on file.

#11774168October 28, 2026
UNKNOWN OR OTHER, FUEL/PROPULSION SYSTEM
1. COMPONENT FAILED / INSPECTION AVAILABLE: The EVAP canister system failed to retain fuel vapors due to a leak at a structural bracket bolt hole drilled by a technician. The vent valve wiring harness malfunctioned after being physically severed by the shop. All photos, video proof, and OBD2 logs are preserved and available for inspection upon request. 2. SAFETY RISK: Safety was compromised by fuel vapor emissions. The dealer falsified Special Parts Order (SPO) recall records, releasing the vehicle into public operation with an active fuel vapor leak, creating an immediate fire hazard and exposure to toxic fumes. Severing the vent valve wiring rendered emission diagnostics completely non-operational. 3. CONFIRMED BY DEALER/INDEPENDENT: The original canister failure was confirmed by a manufacturer warranty authorization. The failure of the dealer's bracket remedy was confirmed via a home smoke test with clear video evidence of the leak. Physical damage to the electrical harness was visually confirmed via before/after photos taken immediately upon picking up the vehicle. 4. INSPECTION BY OTHERS: Inspected by manufacturer representatives at Twin City Hyundai (Alcoa, TN) under open safety campaigns. The service department falsified safety recall metrics to hide non-compliance, misdiagnosed leaks to solicit $1,100+ in fraudulent repairs, and issued a lifetime service ban to cover up their actions when confronted with proof. 5. WARNING LAMPS & SYMPTOMS: Check Engine Light displayed permanent trouble code P0442 (EVAP small leak). Following the dealer's canister installation and damage to the wiring, a new electrical circuit code triggered immediately. Following my manual repair of the dealer-inflicted harness damage, the permanent P0442 code completely cleared on its own, proving the dealership's diagnosis was fraudulent.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11771275October 15, 2026
STEERING
Clunking sound in steering wheel caused by disintegration of EPS rubber coupler. This is due to a design flaw in the OEM part where the rubber turns gummy.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11769195October 5, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, ENGINE
My 2013 Hyundai Veloster caught fire spontaneously while it was turned off and parked in my garage. The fire originated in the engine compartment, specifically around the ABS module area. The vehicle has an open and incomplete safety recall for this exact issue (Recall 251 / NHTSA Campaign 23V-651000). The Mission Fire Department responded to the scene to extinguish the fire
Crash:
No
Fire:
Yes
Injuries:
1
Deaths:
0
#11768151September 30, 2026
AIR BAGS
The contact owns a 2013 Hyundai Veloster. The contact stated that while starting the vehicle, the check engine and air bag warning lights intermittently illuminated. Additionally, the vehicle was driven over deep potholes on the highway, which damaged the steering column and caused the steering wheel to become loose. The contact filed a Police report after the issue, and the vehicle was towed to an independent mechanic, and it was determined that the driver's side air bag was inoperable and needed to be replaced. The vehicle was being repaired by the insurance company. The failure mileage was approximately 194,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765616September 20, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM
My 2013 Hyundai Veloster experienced a catastrophic failure of the ABS module covered under Recall 23V-651 (Campaign 251). The brakes went completely to the floor while operating, and the ABS module is shorting out every replacement fuse, creating an imminent engine fire hazard. Hyundai Corporate has explicitly refused to remedy the underlying defective component causing this fire hazard, only offering to replace the blown fuse. This is a direct failure by the manufacturer to safely remedy a federally recalled defect."
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760874August 31, 2026
ENGINE
The contact owns a 2013 Hyundai Veloster. The contact stated that while driving at various speeds on several occasions, abnormal sounds emanated from the engine compartment, and the check oil light illuminated while making left turns. The vehicle was taken to a dealer, where it was diagnosed that an engine cleaning was needed; however, the service was not performed. The vehicle was later returned to the same dealer, where the same diagnosis was provided. The service was performed, but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759846August 26, 2026
UNKNOWN OR OTHER
Complaint: Manufacture has not remedied the issue in a timely manner. No incident YET but we limit driving the vehicle because of: Manufacturer Recall Number251 NHTSA Recall Number23V651000 Recall Status Recall Incomplete This recall is from September 22, 2023. It's been nearly 3 years. Our vehicle also has an issue with the headlight constantly going out and the battery being drained. I'm not sure if this is related to this particular recall or just a totally new issue to deal with.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754371August 3, 2026
SERVICE BRAKES, HYDRAULIC
The contact's daughter owns a 2013 Hyundai Veloster. The contact stated that while the vehicle was parked, it caught on fire. The vehicle became engulfed in flames, and the authorities were called to the scene. The Fire Department extinguished the fire. The vehicle was later towed to an impound lot where it was deemed a total loss. No injuries were reported. A police report was filed. A nearby roadside electrical box was damaged due to the heat from the fire. Prior to the fire, the vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 23V132000 (Electrical System). The contact was informed by the dealer that the vehicle did not have a parking sensor, and the recall repair would not apply to the vehicle. Upon investigation, the contact later discovered that the vehicle was included in NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic); however, the owner was not made aware of the recall. The manufacturer was not notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11745380June 20, 2026
ELECTRICAL SYSTEM
Ac selector switch burnt up
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733080April 22, 2026
ENGINE
The car goes into limp mode in the middle of driving on the interstate or usually at higher speeds and loses speed quickly. This has put me at high risk for accidents when traveling between cities and has left me stranded on dangerous parts of the interstate at times. I have taken it to my Hyundai dealer I bought the car from and they said there is a knock in the engine and the whole engine would need replaced and I cannot afford that ($12k) but the car only has 125k miles on it and I want to keep it for as long as possible because it’s my baby. I do not think it has been inspected by anyone but my dealer yet but I am willing to let anyone look at it in order to get it fixed without paying an arm and a leg. The car did have some issues prior to this issue that were recalled and fixed, but this happened out of nowhere and when it does happen the engine light flashes and it goes into limp mode. The light currently stays on because of the O2 Sensor though, but that is not a big issue. I have to use a OBD2 Scanner to clear the engine knock code every time it goes into limp mode in order to drive it properly and even then it will go back into limp mode eventually. My car started having issues probably a year or two ago. I also want to note I know a girl who used to have the exact same year, make and model of car as me and had the exact same issues of going into limp mode and such so it is not just a random issue of mine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725147March 18, 2026
ENGINE
As my [XXX] son was driving, his car, out of nowhere, stopped working and the steering wheel became incredibly hard to turn. It put him and other vehicles around him at risk as he was doing 50mph and his car suddenly stalled. No warning. No dash lights. It was hard for him to pull over to safety. We replaced the battery and tried to restart the car, then the engine started smoking. We immediately called for a tow. Our local shop said his engine seized. We then towed it to Hyundai and they confirmed the same thing, "it definitely locked right up." The car has been well taken care of, no warning signs prior to engine failure, no warning lights, etc. His car is also under 100k miles. There is literally no reason for an engine failure. In 2019 there was a NHTSA Recall 19V204, Hyundai Recall #182 ECU Software update; this was supposed to fix the issue but here we are... the engine STILL BLEW. Hyundai is refusing to help. They won't do anything. There's known issues with Hyundai's 1.6 GDI turbo engine. They should be held responsible. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720871February 27, 2026
ELECTRICAL SYSTEM
I am writing regarding a serious safety issue with my 2013 Hyundai Veloster, purchased new. Over the life of the vehicle, I have replaced the manual AC/heat control head three times due to repeated failure. During the most recent installation, I left the trim panel off to monitor the wiring harness and found it becomes extremely hot while operating. A local repair technician examined it and immediately advised me not to use the heating system due to potential fire risk. Research specific to my vehicle shows documented issues including blower control overheating, burning smell/smoke, burned internal contacts, wiring harness heat damage, and repeat control failure. These match exactly what is occurring with my car. I previously spoke with my dealership’s parts department and was told there may be known concerns involving the wiring harness and blower resistor. I also contacted Hyundai Motor America Consumer Affairs but did not receive assistance. After inspection, the dealership informed me the wiring harness and resistor must be replaced at a cost of approximately $2,450. Given the repeated failures and overheating electrical components, I do not believe I should be responsible for this expense, especially considering the potential safety hazard. The vehicle has been carefully maintained, stored properly, and rarely driven in winter. I had planned to use it for travel after retirement but now feel unsafe operating it. I respectfully request a formal safety review and goodwill repair assistance, as this appears to be a defect rather than normal wear. I am also filing a complaint with the National Highway Traffic Safety Administration due to the documented fire risk. I appreciate your prompt attention to this matter. I am respectfully requesting: A formal safety review of this issue. Goodwill repair assistance or full coverage of the repair costs. Clarification as to whether this issue has been evaluated for recall consideration. [XXX] , [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720265February 24, 2026
ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
"CATASTROPHIC ENGINE FAILURE & INEFFECTIVE RECALL REMEDY (NHTSA 19V-204): While traveling at highway speeds, with my two children and boyfriend, the vehicle went completely black. Car loss complete power, going into a limp mode( 'Loss of Motive Power') The Check Engine Light began flashing before going solid. When I was able to pull to the shoulder, I tried to start the car and noticed the radio screen was black and stayed black(before this time, the screen would some times go blank or completely black and then turn back on). Car would start and shake really hard with noise coming from engine, and then car would die. Since then I have been going back and forth with Hyundai Motors and Hyundai dealer, telling them that this is not a warranty issue, but a safety issue and they both have ignored and didn't enology this at all. This happened October 4th, 2025 Recall of 182 was completed but it failed. The vehicle is at the Dalton Hyundai dealer in Nation City. Dealer confirmed zero compression in engine and want $5000 to tare engine to see if it would be under warranty but I keep telling them this is a safety issue that is still accruing and under the 573 Recall/19v-204 I tried to get help throw the BBB and got denied because of age and being the second owner and they told me to contact NHTSA I am a single mother of two young kids, I bought car on 01/26/25 and still owe money on car. Since 10/4/25 I have had to pay out of pocket for a car rental just get to work. My car is up for repo due to me not able to pay for a rental and my monthly car payment. I am lost and don't know what else I can do to get this matter seen. When buying this car the sale person said it is a good car, it will save money on gas, and it has been a nightmare.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719258February 19, 2026
ENGINE
2013 Hyundai Veloster 2013 turbo had 69000 miles when the engine stalled on the highway and promptly slowed to 40 mph. Midas stated engine blew due to a recall so I had it towed to the closest dealership in Oct 2022. They denied the repair and sent it to corporate for authorization and it was denied. Dealership attempted to charge 150 for checking the recall. They then told me to talk to Corporate hyundai. I have went back and forth with them trying to get an explanation for the denial to fix the recall. They wouldn't send the explanation. I refiled the claim again sending them recall laws as well. Recently I received a call from the dealership stating they had the car towed and destroyed. Help
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714229January 29, 2026
ELECTRICAL SYSTEM
Electrical wiring harness and connector melting and blower transistor overheating with know Hyundai internal documentation, all causing a smoke smell and fire hazard. I'm on my 3rd manual Heater / HVAC Control Unit. Fire risk acknowledged by Hyundai dealership and customer affairs. Forced to pay diagnostics fees despite know safety issues, Cost for repairs out the door around 2,450 out the door. Car sitting at the Hyundai dealership waiting for me to repair or not. I cant be driving a fire hazard vehical.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708201January 1, 2026
ENGINE
Purchased car from Premier Auto in Kansas City, KS in January of 2023. The car had 70,000 miles on it. In July of 2023 I was driving on a 4 lane HWY with a speedlimit of 65. The car suddenly jerked to and slowed to 35 MPH. The car behind me nearly hit me. I had it towed to Midas to have it checked out. They informed me the engine had failed and it was because of a manufacturer recall. I then had it towed to a Hyundai dealership in October 2023. They stated to me that it was engine failure due to a recall but they would not fix it. They stated not under recall. The dealership then sent me a notice saying that I owed them 150 dollars and they would keep the car. I filed a claim with Hyundai corporate and they denied repairs stating not under warranty. I appealed that which was a denied response with the reason as not under warranty. I then filed a claim with BBB warranty department and their response was "we only assist with new car warranty issues. I then filed another claim with Hyundai corporate and the dealership and both denied it because of the warrant expiration. While that was happening I lost my spouse of 23 years. The car has been at the dealership for 2.5 years now and I continue to submit requests that are continuously denied.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707608December 29, 2025
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
The contact owns a 2013 Hyundai Veloster. The contact stated that the highest dial setting of the A/C unit had failed to operate as needed. Upon repairing the dial setting on his own, the contact discovered that the dial had burned out. The contact stated that after the repair, the failure recurred nearly a week later. The contact discovered that the dial had burned out again. The dealer was notified of the failure, and the contact was given an estimate for a diagnostic test. The contact stated that failure had caused the defrost system to function poorly, which reduced the road's visibility while driving. The vehicle was not repaired. The manufacturer had yet to be notified of the failure. The failure mileage was approximately 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690624September 30, 2025
ENGINE
The contact owns a 2013 Hyundai Veloster. The contact stated that while driving at 70 MPH, the vehicle stopped and failed to accelerate. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The dealer informed the contact that there was no special warranty coverage on the vehicle for the repair. The manufacturer was not contacted. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684545September 2, 2025
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
On or about May 1, 2025, I was operating my 2013 Hyundai Veloster when flames were observed emanating from under the hood. I immediately pulled into the median and, upon opening the hood, observed an active fire beneath the plastic engine cover. I contacted 911. Before the fire department arrived, a passerby extinguished the flames with a fire extinguisher. Firefighters from a nearby station arrived shortly thereafter and fully doused the engine compartment. The vehicle was subsequently towed to a Hyundai dealership. At that time, I was aware of an active recall related to potential brake line issues that could result in an engine compartment fire. After the vehicle remained at the dealership for an extended period, I was informed that Hyundai Motor America (“HMA”) would send an inspector. Approximately 30 days later, I was contacted by HMA’s corporate office and asked to provide documentation, including a copy of the title and insurance information. During this call, I was advised that while repair or replacement of the vehicle was unlikely, HMA would “make me whole.” Shortly thereafter, I received written correspondence from HMA stating that, following its review of the inspection results, documents, and other information, no product defect was identified as the cause of the incident. The letter concluded that HMA would not accept responsibility and denied my request for assistance or compensation.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11681071August 16, 2025
ELECTRICAL SYSTEM
Smoke, burning smell came from ac control unit. Ac wiring unit, knob completely burned/melted. Reported to Hyundai local and corporate office no resolution other then I just have to replace the unit. Please note this happened in 2022 (40,000 miles today vehicle had 58,000miles) and I paid in full for the replacement the 1st time.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0

← Back to Hyundai Veloster