Freightliner Sprinter Complaints (2006)

4 consumer complaints on file.

• #11121968August 23, 2018
  TIRES

  TL* THE CONTACT OWNS A 2006 FREIGHTLINER SPRINTER 2500 EQUIPPED WITH ANTARES COMFORT A5 TIRES, SIZE: LT225/75R16 118/16S 10PR, DOT NUMBERS: KBU5114 (PASSENGER SIDE) AND KBU51214 (DRIVER SIDE). WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SHOOK VIOLENTLY. THE CONTACT STOPPED THE VEHICLE AND DISCOVERED BULGES IN THE FRONT DRIVER AND PASSENGER SIDE TIRES. THE TIRES WERE CHANGED, BUT THE BULGES RETURNED IN BOTH TIRES. THE TIRES WERE NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE AND TIRE MANUFACTURERS WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 73,443. THE TIRE FAILURE MILEAGE AND VIN WERE NOT AVAILABLE.

  Crash:

  No

  Fire:

  No

  Injuries:

  0

  Deaths:

  0

• #10457354May 3, 2012
  ENGINE AND ENGINE COOLING, FUEL SYSTEM, GASOLINE

  THE TURBO RESONATOR ON THESE VEHICLES IS A KNOWN FAILURE ISSUE, THIS VEHICLE HAS EXPERIENCED TWO FAILURES WHILE STILL UNDER WARRANTY. THE 2ND FAILED AT 70,000, THE MANUFACTURER IS QUITE WILLING TO REPLACE UNDER WARRANTY BUT DESPITE NUMEROUS PRODUCT CHANGES THE (Q5 IS THE LATEST VARIANT) THE COMPONENT CONTINUES TO FAIL UNPREDICTABLY POTENTIAL RESULTING IN A SERIOUS TRAFFIC INCIDENT. THE TURBO RESONATOR IS UNDER FULL TURBO BOOST PRESSURE (APPROXIMATELY 35"MAP) THUS IS MOST LIKELY TO FAIL WHEN UNDER MAX LOAD I.E. CLIMBING HILLS, ETC. AND IN HOT CONDITIONS. WHEN FAILURE OCCURS THE VEHICLE WILL IMMEDIATELY GO INTO "LIMP HOME MODE", SPEED WILL IMMEDIATELY DROP TO DANGEROUSLY LOW MPH (18MPH IN MY LAST EXPERIENCE) AND THE VEHICLE BECOMES A MAJOR TRAFFIC IMPEDIMENT. THIS LONG STANDING PROBLEM HAS BEEN WIDELY IGNORED BY MERCEDES TO DATE AND NEEDS TO BE CORRECTED BEFORE SOMEONE IS SERIOUSLY INJURED OR KILLED. *TR

  Crash:

  No

  Fire:

  No

  Injuries:

  0

  Deaths:

  0

• #10428088September 30, 2011
  FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING

  TURBO RESONATOR PREVENTED ME FROM DRIVING OVER 45 MPH WHILE I WAS ON A 70 MPH FREEWAY! HAD TO HAVE RV TOWED! I WAS TERRIFIED. ADDITIONALLY, I JUST FOUND OUT THAT THE TURBO RESONATOR PART 5137154AC WAS THE SAME ONE USED TO REPLACE THE ONE THAT FAILED. I HAVE FOUND OUT THAT THIS PART IS MADE OUT OF PLASTIC, WHICH CRACKS AT HIGH HEAT AND CAUSES MY VEHICLE TO SLOW DOWN AND PREVENTS IT FROM GOING UPHILL. THE SECOND TIME THIS HAPPENED WAS TWO DAYS AGO ON SEPT. 28 WITH ONLY 28,160 MILES ON MY RV WHEN I WAS DRIVING IN MY RV WITH MY FAMILY ON A DARK DESERTED HIGHWAY 4 HOURS FROM MY HOME, AND IT JUST WOULDN'T GO OVER 45-50 MPH WITH MY FOOT ALL THE WAY DOWN ON THE ACCELERATOR. I WAS TERRIFIED AGAIN, AS I THOUGHT IT COULD NOT BE THE RESONATOR, AS I HAD IT REPLACED ONLY 18,000 MILES AGO AND IT SHOULD NOT BE FAILING. I COULD NOT FIND A CHRYSLER DEALER WHO WOULD WORK ON MY VEHICLE NEAR WHERE I WAS SO I DROVE IT SLOWLY 74 MILES (TERRFIED WHEN I CAME TO HILLS OR BRIDGES!!!!!!) TO CORPUS CHRISTI TO A MERCEDES DEALER, WHO APPARENTLY JUST REPLACED THE DEFECTIVE PART WITH ANOTHER ONE JUST LIKE IT! I AM NOW AFRAID TO DRIVE MY VEHICLE ANYWHERE, AS I AM A WOMAN WHO NEEDS TO KNOW THAT SHE IS SAFE WHEN SHE IS TRAVELING, ESPECIALLY WITH MY FAMILY! I KNOW THAT I AM NOT THE ONLY PERSON WHO HAS HAD REPEATED PROBLEMS WITH THIS TURBO RESONATOR AND WHO WOULD LIKE FOR THE MANUFACTURER TO RECALL THE PARTS AND REPLACE THEM WITH SOMETHING THAT DOES NOT FAIL AND IS SAFE. PLEASE ADVISE ME WHAT TO DO FROM HERE. *TR

  Crash:

  No

  Fire:

  No

  Injuries:

  0

  Deaths:

  0

• #10270013May 26, 2009
  ENGINE AND ENGINE COOLING

  I WAS DRIVING ON I-10 JUST WEST OF PALM SPRINGS CLIMBING A HILL WHEN MY VEHICLE SUDDENLY LOST POWER. THE TURBO RESONATOR HAD FAILED, CAUSING LACK OF ENGINE POWER. MY VAN SUDDENLY SLOWED FROM 70 MPH TO 35 MPH. TRAFFIC FROM BEHIND ME HAD TO REACT QUICKLY TO PASS ME. I WAS ABLE TO CONTINUE TO A DODGE DEALER, AND PURCHASED A REPLACEMENT TURBO RESONATOR. THE OLD ONE HAD A SPLIT IN IT, WHICH I FOUND WAS COMMON BASED ON A SEARCH ON THE INTERNET. THE COST OF THE PART WAS ABOUT $100 AND I WAS ABLE TO REPLACE IT -- AGAIN BASED ON INSTRUCTIONS FOUND ON THE INTERNET. I STILL HAVE THE OLD DEFECTIVE PART. *TR

  Crash:

  No

  Fire:

  No

  Injuries:

  0

  Deaths:

  0