Ford Ranger Complaints (2019)

271 consumer complaints on file.

#11518300April 21, 2023
POWER TRAIN, ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL, POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2019 Ford Ranger. The contact stated that the transmission was shifting roughly. While approaching a stop, there was an abnormal squealing sound detected from the tires, with the vehicle vibrating. The vehicle was randomly changing lanes while driving. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic who test drove the vehicle and confirmed that the vehicle had abruptly downshifted, and the tires were squealing. The contact called the local dealer, but the vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517351April 17, 2023
UNKNOWN OR OTHER, VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:AIR HANDLER/CHAMBER, DUCTS, AND VALVES
With high outside temperatures A/C unit was on, but only the heating system was working. Air Conditioning system was not functuning and heating system would not go off. With windows down, inside tempearture was over 100 degrees and passing out due to heat was happening. Ford Dealer inspected the problem and said it was a manufacture malfunction. After repairing, the same issue developed again five days later. Ford dealer said it was another malfunctioning manufacture part.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517352April 17, 2023
ELECTRICAL SYSTEM, VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:AIR HANDLER/CHAMBER, DUCTS, AND VALVES
In May of 2022 at approximatley 46,000 miles a family members 2019 Ford Ranger had the A/C unit on, but VERY hot air was blowing on drivers side. After inspection and Pin Point Test the Ford Dealership determined a manufactures Drivers Side Temp Blend Door was malfunctioning and was replaced at full charge of both parts and labor to the owner. A few days later after the manufactures malfunctioning part was replaced, the VERY same issue developed and caused a family member to pass out due to over 100 degress inside the vehicle. After OTHER inspection by the Ford Dealership it was determined the manufactures Blend Door Acuator, was malfunctioning and was replaced at full charge of both parts and labor to the owner. ON THE WEEK OF APRIL 10, 2023, THIS VIN'S FORD RANGER HAS EXPERIENCED THE EXACT SAME ISSUES AND HAS BEEN DETERMINED THE EXACT SAME MANUFACTURES PARTS ARE MALFUNCTIONING. THIS MUST BE DETERMINED AS A RECALL!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516884April 13, 2023
VISIBILITY
The contact owns a 2019 Ford Ranger. The contact stated while driving 45 MPH, hot air was entering through the vents. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the air distribution box to be replaced. The vehicle was not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 20V137000 (Visibility) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 42,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515754April 6, 2023
VISIBILITY/WIPER, VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
Climate control temperature system failed and would not adjust. A clicking/snapping noise was present under the dash when attempting to control climate and defrost. Ford verified the failure of the climate control system and stated that I the original owner, [XXX], must personally pay for labor and parts to replace the climate control housing assembly to resolve the failed climate control system and achieve functional defrost. The vehicle went in for inspection at Jim Click Ford (6244 E 22nd St; Tucson AZ 85711; +1-520-570-7301) on the March 29th, 2023 and the repair was completed on April 4th, 2023 (Ford Part Number 18478). The vehicle had 29,634 miles on it at the time of repair. The issue is identical to that described in “SSM 49264: 2019-2020 – Climate Control Temperature Will Not Adjust With Clicking/Snapping Noise From The Dash – Built On Or Before 30-Jul-2020”. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11511499March 13, 2023
SEATS, ELECTRICAL SYSTEM
The contact owns a 2019 Ford Ranger. The contact stated that while driving approximately 30-40 MPH, there was an abnormal burning odor detected. The contact stated that the front driver’s side heated seat had burned a two-inch hole into the seat, the upper back rest, and heating pad. The contact also noticed that the heated seat was inoperable. There were no warning lights illuminated. There were no blown fuses. The vehicle was taken to the dealer however, a service date was not available. The vehicle was not diagnosed or repaired. The contact repaired the seat himself. The manufacturer was notified of the failure and referred him to the local dealer for assistance. The failure mileage was approximately 54,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508404February 21, 2023
VEHICLE SPEED CONTROL:CRUISE CONTROL
The contact owns a 2019 Ford Ranger. The contact stated while driving 70 MPH with the cruise control activated, the vehicle made an abnormal sound. The contact stated that he decelerated to 30 MPH, and then re-activated the cruise control. While at a stop sign, the vehicle lost motive power. The vehicle was not diagnosed nor repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508407February 21, 2023
POWER TRAIN
The contact owns a 2019 Ford Ranger. The contact stated that while driving at 70 MPH with the cruise control activated, the vehicle made an abnormal sound. The contact stated, he reduced the speed to 30 MPH and restarted the cruise control. In addition, while at a stop sign, the vehicle lost motive power. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11507481February 15, 2023
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, he heard a clicking and popping sound when attempting to operate the air conditioning unit. The vehicle was taken to an independent mechanic where it was diagnosed that the blend door actuator and air conditioning flow box failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but, no assistance was provided. The failure mileage was 27,682.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11507027February 13, 2023
STEERING
The contact owns a 2019 Ford Ranger. The contact stated that upon starting the vehicle, the power steering assist failed with several unknown warning lights illuminated. The contact called the dealer and was informed that the VIN was not under recall. The contact was given an estimate for the repair. The contact called an independent mechanic and was also given an estimate for the repair. Due to the failure, the vehicle was towed to the independent mechanic and the contact was informed that the rack and pinion steering assembly needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 37,000. The contact stated that the vehicle was repaired.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505329February 3, 2023
SERVICE BRAKES
This trucks rear brake pads have been wearing unevenly since it was new. The inside rear brake pads are showing heavy wear and the outside pads are not showing even wear. This truck has been into the Kendall Ford of Wasilla Alaska for service in early 2022 and this was first noted and repaired. Now this issues has been found again by owner/operator. There seems to be and issue with the slid pins/bolts for caliper are not allowing the outside pads to slide when pedal is active. This is not an isolated issue according to blogs I have found on this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505375February 3, 2023
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
Very simple I believe this car fall into the recall discovered under Motor Company is issuing a safety recall for select 2019 Ford Ranger vehicles. Affected vehicles had the heating, ventilation and air conditioning, or HVAC, blower motor replaced from Oct. 9 to Nov. 22, 2019, per recall 19534. My car has only 27k miles and ac it’s blowing hot !!! Dealer would not repair it because vin did not “have” a recall but it’s the same exact issue above
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504622January 31, 2023
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:AIR HANDLER/CHAMBER, DUCTS, AND VALVES
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal cracking sound, and then the heating system became inoperable. The contact stated that he was freezing while driving in 20-degree weather. The contact was concerned that if he became stranded in traffic during a snowstorm, he would freeze. The vehicle was taken to the dealer, where it was diagnosed that the heating duct was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and agreed to cover a portion of the cost of the repair. The failure mileage was approximately 46,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504716January 31, 2023
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:AIR HANDLER/CHAMBER, DUCTS, AND VALVES
The contact owns a 2019 Ford Ranger. The contact stated while driving 40 MPH with the heating system activated, the contact heard an abnormal sound coming from the vents. The contact stated that both cold air and heat was coming through the vents. The vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that the vehicle was out of warranty. The failure mileage was 39,081.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504058January 27, 2023
POWER TRAIN
Purchased this vehicle (2019 Ford Ranger XLT), in 2019. Over the last month or so, started developing a shimmy when starting out, bad shimmy when slowing down. Had the brakes checked, no issue. Continued it get worse, developing harder shimmy when starting and braking, began feeling a delay in shifting gears. Dropped it off where I purchased it, Priority Ford Norfolk, was told that the transmission needed to be replaced. 3 year old truck, transmission went bad. After during research, these particular transmissions (10 speed) was installed in Rangers, F150s, Explorers etc. This transmission issue poses a risk to safety when driving. When slowing down, it had major difficulty down shifting and coming to a smooth stop, it would feel like it was locking up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504085January 27, 2023
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:AIR HANDLER/CHAMBER, DUCTS, AND VALVES
The actuator motor is not working. This is a common complaint of the 2019 Ford Ranger and is noted in Ford's SSM 49264. Certainly a service bulletin identifying a need to replace the entire climate control housing assembly is worthy of a recall. This truck has 23, 000 miles on it and is just out of warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502863January 20, 2023
VISIBILITY/WIPER
It looks like on some 2019 Ford Rangers (mine included), there is a faulty blend door in the heater box assembly. Note this issue is not present in other model years due to Ford correcting the defective part. This defective part causes the switch between hot and cold air to fail. My truck got stuck on hot and the dealer replaced it under warranty. The replacement has now failed 6 months (3000) miles later. This issue can prevent the heat from functioning properly in cold weather, which means the defrost is ineffective - requiring the driver to manually clear the windshield. The issue is that Ford A) knows there is a defect that can impact the safe operation of the vehicle B) These vehicles would likely be covered under the manufacturer warranty due to low miles from 2020 (COVID) but has not made efforts to notify owners of the defect C) will gladly charge $3,000-$4,000 for this repair once the warranty expires (which has happened for many 2019 vehicles by this point). Profiteering on a known factory defect is unacceptable!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11502106January 17, 2023
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Back up camera is blurry unable to identify objects. I know there’s been a recall on many of the back up cameras but none on my vehicle since I have a back up camera that is blurry and unable to identify objects. Clearly, how do I go about getting it fixed?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11501121January 10, 2023
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
My vehicle's heater stopped working mid-drive. I heard a loud POP sound and then the air that came out of the vent was room temperature. I pulled over and stopped the vehicle. Waited a minute and restarted it. The temperature did not change. I was driving on Highway 80 over Donner pass in the Sierra mountains. The temperature was very cold and my window began fogging up. I then had to continue my drive by wiping my windshield from the inside with a rag every 15 seconds or so to maintain visibility enough to drive. As the snow was coming down and it was getting dark, I needed to keep going as it would have been too cold to stay in the vehicle and wait out the storm. Now, driving the vehicle is hazardous because I do not have proper defrosting capability. I took it to a dealership and they estimated roughly $4000 in repairs to fix the issue. The car is barely 3 years old.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11500810January 9, 2023
STEERING, SERVICE BRAKES
The contact owns a 2019 Ford Ranger. The contact stated that they had received a notification on the main control computer screen and the vehicle's notifications app indicated that there was an electrical failure occurring with the steering. The contact then stated at the same time the vehicle began to self-direct causing an excessive amount of force required to steer the vehicle. The brakes became difficult to depress causing an excessive amount of pressure to be applied on the brake pedal in order to get the vehicle to come to a stop. The vehicle was taken to the dealer who was unable to diagnose the cause of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 16,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Ranger