Ford Ranger Complaints (2019)

271 consumer complaints on file.

#11704620December 11, 2025
POWER TRAIN
Transmission shifting issues. Will shift out of gear or delay shifting several seconds and sometimes limited power. The 1080r 10 speed transmission has a know design flaw that was finally fixed in 2023. My 2019 is now having the issue and is $8000 to fix for a bushing that moves out of place
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704234December 10, 2025
POWER TRAIN, VEHICLE SPEED CONTROL, ENGINE
Truck looses gear when pulling into traffic. It will shift out of gear and only allow coasting. At speeds of 40 MPH and higher it will down shift causing dramatic reduced speed with no brake warning to other drivers behind. It will also randomly loose power. It will have delayed shifts squealing tires upon shifting and excessive jerking that is uncontrollable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703457December 6, 2025
POWER TRAIN
I have had my 2019 Ford Ranger in for service to address issues with the transmission on 3 different occasions starting in Fall of 2023. Each time paying $106 for the deductible on the warranty to service a "Technical Service Bulletin" (TSB). Each time, being told of a different TSB that they would be addressing. Never addressing them all at the same time. In May of 2025, still experiencing the same/similar issues, I brought in in again only to be told that there was a TSB that they did not service, that my warranty had expired. Upon searching the internet, there are many people reporting similar issues with a similar response from Ford. I have spoken to multiple dealerships as well as reached out to Ford car with little to no response.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703201December 5, 2025
UNKNOWN OR OTHER
Repeated failure of HVAC system, even after repairs, leads to not only a very cold truck in January in Maine, but inability to defrost the windshield and keep it defrosted. Repairs have been made in January 2025, April 2025, and now has to be repaired again in December 2025. My independent service provider who subscribes to OEM Ford subscriptions, was not made aware of an "internal" service memo until now. Neither from the subscription services or from contacts at a Ford dealer where he resourced parts and repair info. SSM 51313 indicates a different repair than was made on the previous two attempts. These repairs require the disassembly and reassembly of the instrument panel and are very expensive - especially when not apprised of correct. Now the SSM indicates a complete housing replacement to correct the defective part. See attached forms.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703308December 5, 2025
SUSPENSION
On November 7th. 2025, I took my Ranger to my mechanic for it's yearly emissions and inspection, to have the tires rotated and brakes changed. He called me later that day and had sent me pictures of BOTH rear leaf springs broken off from the under carriage. He stated that he could not tell how long they were like this and asked if I had any issues driving. I did not notice any noise or driving issues. He stated that he is shocked that I did not wreak the truck by loosing control because it should have caused my rear to be bouncing all over. He contacted FORD and asked if there was a recall on them and was told "No". He then instructed me to file a complaint with you. He ordered the parts and replaced fixed the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702847December 3, 2025
ENGINE, ELECTRICAL SYSTEM, STRUCTURE:BODY
Hood/cowling along the windshield allows water to leak under the hood of the vehicle and wets the coils and plugs causing the engine to mis fire and shutter violently. This engine mis fire and sudden lack of power can cause the vehicle to obstruct the flow of traffic resulting in an accident. Problem was reproduced by the dealer and they replace coils, plugs, and installed an accessory engine cover to prevent the issue in the future. All at my cost. The problem remains that there are many Ford Rangers on the road unaware of this problem. This problem is documented in a Ford TSB but a more aggressive approaching is needed to resolve this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701697November 26, 2025
POWER TRAIN
I’ve been noticing a delay in shit out of 1st, 3rd, 6th, and 9th gear. Sometimes it slams but most of the time not. Anyways, this morning on my way to work I passed a slow driver on 2 lane road. After I merged back into the lane, I resumed cruise control and basically lost all power to the wheels. The vehicle I passed about slammed into the back of me. I canceled cruise control to give gas and the transmission was fighting me to stay in a gear. It finally caught and I drove it the rest of the way to work with the “normal” 1,3,6,and 9 being weird. My safety and the other vehicles safety was definitely at risk. The was no warning lights that came on. I haven’t had it checked out yet because this is same day
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701278November 24, 2025
EXTERIOR LIGHTING
My complaint isn't about my vehicle. My complaint pertains to pickup truck and SUV lighting. The lighting on these vehicles have become so bright that they blind oncoming drivers. In addition, I was recently blinded by the lights on a lifted pickup truck, that was following behind me. The lights on these vehicles have become so bright that they present a hazard to other drivers. This hazard is made worse when the vehicles are lifted (body or big wheels). Please consider taking action to address this problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699749November 17, 2025
SUSPENSION
The front eyes of both leaf springs were broke. Took truck to local shop to repair a tire leak and they called me to ask me how I drove the truck there as they never saw anything like it before. This is a major component that maintains the rear axle geometry and could have been a safety risk and should never be a concern on a 5 year old vehicle with under 100,000 miles. Vehicle has not been inspected by any other parties than the shop and myself. No symptoms were detected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698244November 7, 2025
SUSPENSION
Both rear leaf springs broke at the eye on the forward anchor bushing, leaving both leaf springs not anchored at one end. This was undetectable until the truck was lifted for an oil change. It was not detected and released back to me to drive. The rear axle was only anchored at 2 of the 3 anchor points. If one of the other anchor points was compromised the result could have been catastrophic depending on the driving conditions. I drove the vehicle locally until i figured out the clunking noise. Both leaf springs were replaced by a certified repair shop. There have been other reports of the same problem with no re-calls
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697140November 3, 2025
BACK OVER PREVENTION
The contact owns a 2019 Ford Ranger. The contact stated that while in reverse(R), the backup camera initially projected three lines at the bottom of the screen, distorting the driver’s vision. The contact stated that over time, the camera displayed a blank or distorted image, and the message "Camera Not Accessible" was displayed. The vehicle was taken to a dealer, and the backup camera was reset. The reset initially repaired the failure; however, the failure returned soon after the reset. The contact made two attempts to reach the manufacturer, but the call was disconnected each time. The vehicle was not repaired. The failure mileage was approximately 56,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693113October 13, 2025
POWER TRAIN, FUEL/PROPULSION SYSTEM
My 2019 Ford Ranger 4x4 was bought new in April of 2019 and has approxiamatly 73,400 miles. Over time a slight glitch in the transission got to be more frequent. When first starting out within the first mile of operation, the vehicle would hang between gears and act like it ran out of fuel for a few seconds at low speed, as in pulling out from a stop sign or accelerating from a dead stop. My guess is inbetween first and second or second and third gear. It just wouldn'd go. Fortunatley I was not involved in any accidents. I can see where this could easily cause a mjor accident. There are several TSB's for this transmission and I believe Ford and General Motors use this same transmission. I have had my truck at the dealer for almost a month after it got scary to drive it got scary to drive. They are repairing this and contributing to the cost. I feel ike they no there is a problem and probably should have done a recall before someone gets killed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689959September 26, 2025
LANE DEPARTURE: BLIND SPOT DETECTION, BACK OVER PREVENTION: WARNINGS
While backing up out of a parking space, my BLIS system did not give me a warning letting me know there was a pole to my left side...finally, it beeped just once as I backed into the pole...no other warning. Estimate of repair is $4900. My neighbor was with me and can confirm everything
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11687940September 17, 2025
BACK OVER PREVENTION
The contact owns a 2019 Ford Ranger. The contact received notification of NHTSA Campaign Number: 25V442000 (BACK OVER PREVENTION); however, the dealer refused to perform the recall repair. The contact stated that the rearview camera displayed a black screen while the vehicle was in reverse(R). The contact stated that the failure had obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 33,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684393September 2, 2025
POWER TRAIN
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission shuddered abnormally. In addition, while driving approximately 45 MPH, the vehicle drove without issues. No warning light was illuminated. The vehicle was taken to the dealer, and the failure was diagnosed as an internal transmission pump failure. The contact was informed that the transmission pump needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the manufacturer was aware of the failure; however, the repair was not covered under the recall. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 78,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11684152August 31, 2025
ELECTRICAL SYSTEM, POWER TRAIN, SEAT BELTS
Air bag malfunctions and not active passanger and driver side, hvac malfunction replaced twice, power train shifting out of gears, PCM malfunctions and triggering failures to sensors. Passanger seat belt not working. Collision sensor malfunction and not working.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678319August 4, 2025
POWER TRAIN
The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was an abnormal sound coming from the vehicle. The contact stated that the check engine and the service warning lights then became illuminated. The vehicle was driven to a nearby Ford dealer. The vehicle was diagnosed with internal failure of the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact referenced an unknown recall with a similar description of the failure; however, the VIN was not associated with the recall. The failure mileage was approximately 73,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675935July 24, 2025
ENGINE
The contact owns a 2019 Ford Ranger. The contact stated while driving approximately 60 MPH and hauling a trailer, the vehicle unintendedly decelerated and stalled. The vehicle was towed to the local dealer who diagnosed the vehicle and determined that there was rainwater inside the engine cylinders, causing two spark plugs to rust and malfunction. The spark plugs, spark plug boots, and spark plug coils were replaced and the vehicle was repaired. The contact stated that recently, while the vehicle was in for routine maintenance, the mechanic discovered rainwater inside the engine cylinders again. The vehicle was not yet repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The contact was informed that the VIN was not included in an Extended Warranty coverage related to the failure. The failure mileage was 44,825.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675449July 22, 2025
POWER TRAIN
My transmission failed on the highway. I was merging on the highway one day and all of a sudden I felt a sudden reduction in power which was dangerous for the people behind me, and heard an awful grinding/whining noise. I immediately limped it to the dealership and was told several days later the transmission (Ford 10R80) had a catastrophic failure and was lucky to get it to the dealership. This is unacceptable and I know I’m not the only one with issues with these transmissions. The dealership told me it happens all the time. This is a safety issue and unacceptable for the truck that is 5 years old.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673996July 16, 2025
WHEELS:LUGS/NUTS/BOLTS/STUDS
The contact owns a 2019 Ford Ranger. The contact stated that while the vehicle was at the dealer for a tire rotation, the contact was informed that the tires were unable to be rebalanced due to swollen lug nuts. The vehicle was then taken to Goodyear, who was also unable to rotate the tires. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Ranger