Ford Ranger Complaints

278 consumer complaints on file.

#11632810December 28, 2024
STRUCTURE:BODY, SUSPENSION
I purchased a new 2024 Ford Ranger yesterday. As I was researching camper shells and truck racks I found that these common items cannot be installed without first installing a load bed reinforcement bracket kit to reinforce the truck bed to the bed side rails. Apparently, nothing can be attached to the side rail which weights more that 88 lbs or the truck bed could separate from the side rails. This is an design/engineering shortcoming from Ford as these are common after market add-ons for mid-sized trucks. Also, Ford is asking customers to pay for the reinforcement bracket and installation - which was quoted today at $1,600, and the Ford part is not currently available from the corporate US Ford website, and has not been available for several months.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631609December 19, 2024
POWER TRAIN
Increasingly the transmission, when cold, was experiencing difficulty shifting between 3-4-5 and not shifting into 9-10. When the weather started reaching zero degrees overnight, the vehicle was reluctant to move and, once it began moving, would not shift out of 1st. After allowing the vehicle to warm up, it would reluctantly shift from 3-4-5 and then, without any speed reduction, suddenly downshift with a shudder and bang. Vehicle is in the Ford dealer while they preform the TSB related to this universally known problem with the 10R80 transmission. Despite the TSB “approving” significant part replacements, including clutches, modules and converter, the dealer is required to proceed a few steps at a time and then test the vehicle to document the need to replace more components, before proceeding the the TSB. Ford is avoiding what should be a full recall involving providing the dealers with a rebuilt transmission and converter with the dealer’s responsibility only being the replacement of the transmission. Ford’s dealing with this very well know problematic transmission with a TSB is grossly unfair to the dealers and exceedingly unfair to the consumers who eventually bear the financial burden.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630642December 13, 2024
ELECTRICAL SYSTEM
Truck cut off at an intersection without warning and would not turn back over. After multiple attempts and AAA service members checking batter car would not start. Has power but will not turn over dealership is saying there is a module issue but is not sure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629933December 10, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I was in an area that had received snow and cold temperatures. I started my car to warm it up and began cleaning off the snow. The heat from the rear defroster caused my read window to shatter leaving glass mostly on the exterior of the truck bed but also in the back seat. This is a known problem with Ford model trucks and they refuse to repair the issue or replace my window.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628396December 2, 2024
POWER TRAIN
The contact owns a 2021 Ford Ranger. The contact stated that while driving at various speeds, the vehicle hesitated and jerked while depressing the accelerator pedal. The contact stated that at first there were no warning lights illuminated; however, after a while the "Power Train Malfunction - Reduced Power" message was displayed. The dealer and an independent mechanic were notified of the failure and acknowledge that the defect was a common failure. The contact was provided an estimate for a new transmission. The manufacturer was also notified of the failure and the contact was offered financial assistance if the vehicle was serviced by a Ford dealer. The vehicle was not repaired. The failure mileage was approximately 37,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627625November 26, 2024
SEATS
The rear seats in the 2024/2025 Ford Raptor Ranger are connected to the rear of the cab via a single latch. The single latch does not always latch. I noticed it had failed to properly latch the next day when I was installing my car seats. I figured it was user error, but than I re-tested it and struggled to properly latch it. The danger is the rear portion of the seat could suddenly fold forward during a hard break or accident, resulting in serious injury to rear passengers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625773November 17, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER, BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Wiring for back up camera failed and short circuited - will attempt to retain the components for inspection needs. Safety concern - when wire short circuited, it burned the wire at the control module in the dash board, causing the control module to also fail - according the the ford service advisor at my dealership. Issue was diagnosed and inspected by Titus Will Ford service center at 11503 Pacific Hwy SW, Lakewood, WA 98499 - phone # (253) 753-1253. No warning lamps/messages/symptoms.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622476October 29, 2024
STEERING
The contact owns a 2022 Ford Ranger equipped with Bridgestone Tires, Tire Line: Dueler HT685, Tire Size: 255/70/R16, DOT Number: 1VN0KDH2 3422. The contact stated that the driver’s side front inner tire was excessively worn. The contact noticed that the steel belts were showing through. The contact replaced the tire with a spare. There was no warning light illuminated. The vehicle was taken to an independent mechanic, who informed him that the alignment bolt s could not be adjusted. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The vehicle and tire failure mileage were approximately 38,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621817October 24, 2024
STEERING
Vehicle displays “Steering Assist fault-Service required”. Failure of power steering while driving could result in loss of control of the vehicle. The earliest available appointment for the dealer to check the problem is 11/20/24.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621341October 22, 2024
POWER TRAIN
Transmission issues that are known to the manufacturer. Backed out onto a road while there was no traffic, shifter into drive and the transmission made a banging noise and refused to shift. Cars started coming in behind me and I was blocking traffic. Was able to get it into neutral then into drive so I could pull away. This is a well known issue to Ford and they have only offered service bulletins that provide temporary fixes until vehicles are out of the factory warranty period and Ford no longer has to cover repair costs. Vehicle only has 50,000 miles and the transmission issues started around 30,000
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617130September 29, 2024
STRUCTURE:BODY
2024 Ford Ranger Trucks made in Michigan between January 4, 2024 to July 15, 2024 do not include the load box reinforcement bracket. Without this bracket installed, if the owner were to place more than 88lbs onto one or both bed side rails the bed could crack, warp, bend, or break. If operators of this vehicle are not aware and do load the bed side rails over 88lbs, this could pose a safety issue to the driver or other drivers on the road around the vehicle. Ford has not notified all owners of affected vehicles, and in my case I found out my vehicle was affected out of sheer curiosity and reading forums with posts of other owners whose vehicles are also affected. Ford is currently not willing to address the issue without additional cost burden on the vehicle owner.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617035September 28, 2024
UNKNOWN OR OTHER
I bought this ford ranger and got it last week and went to put a topper on it and you cant - the box rails only hold 80 pounds . You have to install new brackets Ford nose about this but makers buyer pay for it . please make ford do a recall on this before someone gets hurt . thank you
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11615090September 17, 2024
WHEELS
The contact owns a 2024 Ford Ranger. The contact stated while driving 50 MPH, the brake pedal was depressed and the front driver’s side wheel locked up, causing the vehicle to pull to the left. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that there was a part missing from the wheel. The contact was informed that the wheel needed to be replaced. The manufacturer was notified of the failure and a case was opened. The failure mileage was 6,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11611440August 28, 2024
ENGINE, FUEL/PROPULSION SYSTEM
Oil level 1/2 quart high, and smells like gasoline.? Actual mileage on truck is 8,544 last oil change @ dealership @ Wiscasset Ford on 5/6/24 in Wiscasset, Maine. 378 Bath Road 04578-9431 I was informed this is an issue. But what is the fix.?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11610413August 23, 2024
POWER TRAIN
We love Ford Rangers. This is my 4th. It has been wonderful, until [XXX]. We had to replace an A/C, but that's normal. We've also noticed a very few times that when the transmission shifted, there was a little jolt. But that was rare. But on [XXX], after stopping at a light at the intersection of [XXX] and [XXX] in Indianola, MS., we had a frightening experience. After crossing the busy highway I began to accelerate and suddenly the truck jolted forward and quickly accelerated to 70 mph. I hit the brakes, and after a couple of taps it slowed down. But when I gave it more gas, it only roared twice, and no power...with big trucks beside and behind me. That was frightening. Then it returned to normal, and I went on to Isola, MS. Upon leaving it didn't want to move forward, only roaring, but then quickly responded and was back to normal. I was scheduled for a 12:30 lunch meeting in Leland, MS and my wife and I proceeded. All normal. Upon leaving Leland, same thing. No power at first, then it moved forward, normally. We noticed it was a rough shift at 45 mph as we got out on freeway. I called the service department at Hallmark Ford, Batesville, and told mgr. my problem. Thought it might be fuel pump, filter, or transmission. Upon arrival at home, it wouldn't go in reverse. I sent it to dealer on wrecker. Got second opinion. Both say it needs a new transmission at $8900. My concern is will the new transmission have same problems...reading now on internet of other people who have had similar events. Money matters, but MY CONCERN is the danger this could have inflicted upon us. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11609840August 20, 2024
POWER TRAIN, VEHICLE SPEED CONTROL
2021 Ford Ranger - 10R80 Transmission Failure while driving. Hard shifting, lurching, slipping gears then abrupt failure. It is available. Currently at Diehl Ford in New Brighton, Pennsylvania. - It went from being 90% drivable to coming to complete stop with no transmission engagement at all. Break down occured while climbing a grade and the complete stop happened over a blind crest with guard rails on either side. Leaving myself vulnerable to being struck from behind and another driver having minimal time to see then avoid me or potentially have no where to go but through me. Can I add documents later as I get them?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607295August 8, 2024
SERVICE BRAKES, UNKNOWN OR OTHER
The two rear brake rotors were 75% rusted through, this truck only had 5,642 miles on it at the time. Brake pedal was soft, went to the floor to stop. Asked local ford dealer to look at and they wanted to charge me for two rear rotors and brake shoes. I informed them that I thought this would be a factory defect, they determined it wasn’t. This was unexceptable to me. So I took it to dealership where I purchased truck and they agreed that this was a factory defect and replaced. The only reason I’m writing you is due to all the complaints listed on your site for this truck, not one issue about rusted (badly) rotors. Unless this is an issue but just not being found.? I did read quite a few complaints about soft brake pedals though
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11607226August 8, 2024
POWER TRAIN
Five separate incidents where the truck suddenly accelerated to 4500 rpm while in drive. Usually at low speeds. Last incident occurred in driveway where the truck left skid marks on the pavers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606865August 6, 2024
FUEL/PROPULSION SYSTEM, ENGINE
Excessive fuel in the oil. Oil smells of gas and is diluted. Almost a quart high at 3000 mile mark. Dealer and Ford admit this may be an issue on some engines but it is supposed to be normal??? We installed a pcv catch can and it will fill up with fuel in about 800-1000 miles. That is almost 8 ozs. The included photo shows oil at about 4000 miles. The second hole you see in the dipstick is above the full mark.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11605717July 31, 2024
ENGINE, FUEL/PROPULSION SYSTEM
Water leaks into spark plug wells causing vehicle to lose power no cover is over the sparkplugs
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Ranger