Ford Focus Complaints (2016)

1,195 consumer complaints on file.

#11623448November 4, 2024
ENGINE, UNKNOWN OR OTHER, FUEL/PROPULSION SYSTEM
I am experiencing two significant issues with my 2016 Ford Focus, both of which closely match known recall problems documented for this model and year. However, my vehicle’s VIN does not currently show an active recall, and Ford has not covered the repairs. Canister Purge Valve (Error Code P1450): The canister purge valve in my vehicle is malfunctioning, leading to rough idling, poor fuel economy, and difficulties starting the engine. This issue also triggered the check engine light. My research shows that similar problems were included in a Ford recall for the 2016 Ford Focus, where a defective purge valve could cause stalling and inaccurate fuel readings. Despite these similarities, my VIN is not covered under this recall. Transmission Control Module (TCM) Issues: My vehicle also has transmission performance problems linked to the Transmission Control Module (TCM), causing hard shifting, irregular transmission behavior, and occasional failure to engage properly. The TCM issues are well-documented among 2016 Ford Focus vehicles, some of which were included in recalls and extended warranty programs, but my vehicle is excluded from this coverage. Given that these issues directly impact the vehicle's drivability and safety, I am requesting an investigation into why vehicles with similar symptoms are not covered by these recalls. These issues pose potential safety risks, including sudden stalling and compromised transmission performance. Thank you for your attention to this matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623061November 1, 2024
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate and shuddered while turning. No warning light was illuminated. The vehicle was taken to the dealer, where it was determined that the clutch needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 97,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623070November 1, 2024
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated that after coming to a complete stop, the vehicle began to jerk upon acceleration. The jerking persisted over time. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 18V845000 (Power Train). The vehicle was taken to the local dealer, where it was diagnosed and determined that the transmission clutch needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and confirmed that there was no warranty or recall coverage on the vehicle. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623094November 1, 2024
FUEL/PROPULSION SYSTEM
The malfunction light came on in my car I had a mechanic check the code that came up and he said it was the canister purge valve! Then I noticed whenever I put fuel in my car it was hard to start it would sputter and almost die !
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621877October 25, 2024
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated that while her daughter was driving at undisclosed speeds, the vehicle began jerking and stalled. The check engine warning light was illuminated. There was an unknown red symbol displayed. The vehicle was taken to an independent mechanic, who determined that the transmission had failed. The contact called the local dealer and was referred to the manufacturer for assistance. The vehicle was not diagnosed or repaired. The manufacturer was contacted and informed the contact that there was no recall coverage for the repair and opened a case and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620714October 18, 2024
POWER TRAIN
Failed tcm. Shaking and jerking car. Under 80k miles. Breaks stopped working in drive. Won't reverse. Same make,model,year and problem as recall warranty but for some reason my vin isn't included.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620536October 18, 2024
FUEL/PROPULSION SYSTEM
i know there is already a recall for other ford focuses with this same issue. my cpv is not working. the car breaks down every time i fuel and its a huge safety hazard as this happens far from my home usually and its very scary for me. i heard it can ruin my engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620685October 18, 2024
ENGINE AND ENGINE COOLING
The contact owns a 2016 Ford Focus. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while at a complete stop, the vehicle failed to accelerate upon depression of the accelerator pedal. Due to the failure, the vehicle was towed to an independent mechanic who informed the contact that the failure was related to the recall. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 93,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620094October 16, 2024
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
The contact owns a 2016 Ford Focus. The contact stated while parking the vehicle, the steering wheel did not function as intended. The contact stated that the steering wheel was very difficult to turn in either direction. In addition, the contact stated that the shift gear did not function as intended. The contact stated that the gear shifter did not shift into park, drive, or neutral. In addition, several unknown warning lights were illuminated. The contact stated that when she turned the vehicle off, the vehicle did not restart. The vehicle was towed to the contact's residence. The vehicle was towed to the dealer where it was diagnosed with a failed Transmission Control Module. The contact was informed that the Transmission Control Module needed to be replaced. The vehicle was not repaired. The contact had received recall notification NHTSA Campaign Number: 18V735000(Fuel System, Gasoline), however, the contact was advised that the failure was not associated with the recall repair. The vehicle was then towed to an independent mechanic where it was diagnosed with a failed Transmission Control Module. The contact was informed that the Transmission Control Module needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620137October 16, 2024
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2016 Ford Focus. The contact stated that while attempting to merge onto the highway at approximately 30 MPH, the vehicle independently switched from first to third gear, jerked, and shifted into the park gear to control the vehicle. The vehicle stopped in the middle of the roadway. The vehicle failed to move forward or in reverse. A bystander shifted the vehicle in neutral and pushed the vehicle to the shoulder of the roadway. The vehicle was towed to a local dealer where it was diagnosed that the clutch was fractured and transmission failed. The vehicle was not repaired due to costs. The contact was concerned as the vehicle was her primary source of travel since she was a traveling nurse and discovered that the clutch was previously replaced by the first vehicle owner. The manufacturer was notified of the failure. The approximate failure mileage was 74,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619218October 10, 2024
STEERING
Continuously get the message steering fault assist service required. It’s impossible to turn the steering wheel.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618707October 8, 2024
ENGINE AND ENGINE COOLING, POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated while accelerating from a stationary position, the vehicle experienced severe jerking, vibrations, and hesitation. The vehicle was taken to the local dealer who replaced the transmission clutch but later the failure reoccurred. Additionally, the engine overheated and the vehicle stalled. Upon inspection, it was discovered that there was no coolant inside the coolant reservoir. The contact stated that no visual evidence of a coolant leak could be found. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618811October 8, 2024
POWER TRAIN
The transmission system, specifically the clutch, malfunctioned. The clutch slipped, which caused the car to suddenly stop in busy traffic. The vehicle is available for inspection upon request. The sudden stop in heavy traffic put my safety and the safety of others at risk. It could have led to a rear-end collision or other accidents as the vehicle stopped without warning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618416October 7, 2024
ENGINE AND ENGINE COOLING
The contact owns a 2016 Ford Focus. The contact stated while driving 75 MPH, the engine seized. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that there was an oil pump and engine failure. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 83,790.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618090October 4, 2024
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated that the check engine and transmission warning lights were illuminated. The contact stated that the vehicle was previously repaired on 3 different occasions for transmission failure under warranty. The local dealer was contacted, but the vehicle was not diagnosed or repaired due to the warrant being expired. In addition, the contact stated that the reverse failed to engage when the gear shifter was shifted into reverse. The manufacturer was made aware of the failure. The failure mileage was approximately 93,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11616319September 25, 2024
STEERING, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
Electrical power steering goes in and out and the dash displays “steering assist fault” warning, and the power steering goes out entirely. You can still turn, but it takes a lot more physical effort to do so. Since it goes in and out, it can happen at any time and is very hard to get diagnosed through a diagnostic if the mechanic or dealer cannot replicate the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11616226September 24, 2024
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated while driving 35 MPH, the vehicle inadvertently lost motive power and decelerated, with the message "Transmission Fault" displayed. There was no warning light illuminated. The vehicle was towed to an independent mechanic, who diagnosed the vehicle and retrieved DTC code: P074 (Third gear failure, clutch failure). The mechanic confirmed that the vehicle jerked and popped out of gear and confirmed the whining noise from the transmission. The vehicle was not repaired. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 132,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11616266September 24, 2024
POWER TRAIN
The contact owns a 2016 Ford Focus. The contact stated while driving at an undisclosed speed, the vehicle shuddered and jerked abnormally. Additionally, the contact stated that the transmission independently downshifted and the RPM increased; however, the vehicle failed to respond as needed. The contact stated that the failure had occurred intermittently; however, recently the check engine warning light illuminated. The vehicle was scheduled for diagnostic testing at the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but did not assist. The contact was informed that the repair was not covered under recall or warranty. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11616064September 23, 2024
ENGINE AND ENGINE COOLING
The contact owns a 2016 Ford Focus. The contact stated that while his wife was driving at 55 MPH, the vehicle inadvertently lost motive power. The driver was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. The blank warning light was illuminated. The check engine warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact also stated that the engine was not original to the vehicle, because the original engine had previously been replaced. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 84,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614969September 16, 2024
POWER TRAIN
This car stalls in traffic. It has had recalls in the past. Not fixed. Unable to drive it with out fear of it stopping in traffic. Was told it was fixed and road worthy when purchased. guess i was lied to. this vehicle show be recalled due to transmission issues. Safety issue. Vehicle randomly slows down in traffic
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Focus