Ford · Model Report
Showing safety data for the 2009 model year only.
Phenix Enterprises, Inc. (Phenix) is recalling certain model year 2009 and 2011 trucks manufactured from July 22, 2008, through December 16, 2011, equipped with a Sure Power battery separator, part number 16511893 (model 1314). Suspect vehicles, in their as-built configuration, had a Sure Power battery separator installed on the inboard side of the curb side rail. These battery separators may overheat.
FORD IS RECALLING CERTAIN MODEL YEAR 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH CATERPILLAR C7 ENGINE. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE A FUEL LEAK.
FORD IS RECALLING MODEL YEARS 2009 F-650 AND F-750 TRUCKS. THE CHASSIS WIRE HARNESS MAY HAVE BEEN ASSEMBLED WITHOUT A CONNECTOR SEAL IF THIS SEAL IS MISSING, THE CONNECTOR TERMINALS MAY CORRODE AFFECTING THE PROPER ILLUMINATION OF THE VEHICLE'S REAR BRAKE LAMPS, TAIL LAMPS, TURN SIGNAL LAMPS OR TRAILER LAMPS (IF EQUIPPED.) ALSO, THE FUNCTION OF THE ANTI-LOCK BRAKE SYSTEM MAY BE AFFECTED.
FORD IS RECALLING 2,811 MY 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH C7 OR C9 CATERPILLAR DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.
TL* THE CONTACT OWNS A 2009 FORD F-650 SD. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE BRAKES FAILED TO RESPOND. THE CONTACT HAD TO MAKE A SHARP LEFT TURN TO AVOID CRASHING INTO A VEHICLE. THE EMERGENCY BRAKE WAS ACTIVATED AND SHIFTED THE GEAR SHIFTER INTO SLOW RANGE TO BE ABLE TO CONTINUE DRIVING THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT A CONTROL UNIT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 17,000. UPDATED 05/19/17*LJ *CN
No injuries · No fire · No crash