Ford F-250 Complaints (1999)

830 consumer complaints on file.

#10425046September 12, 2011
FUEL SYSTEM, GASOLINE
TL*THE CONTACT OWNS A 1999 FORD F250. WHILE DRIVING 5 MPH, BOTH STRAPS FOR THE FUEL TANK FRACTURED, CAUSING THE FUEL TANK TO DETACH FROM THE VEHICLE. IN DOING SO, THE BRAKE LINES WERE FRACTURED. BOTH THE FUEL TANK AND THE BRAKE LINES BEGAN LEAKING FLUIDS. THE VEHICLE WAS TOWED TO A LOCAL SERVICE STATION WHERE THE FUEL STRAPS, REAR MAIN BRAKE LINE AND THE FUEL SENDING UNIT WERE REPLACED. THE DEALER AND THE MANUFACTURER WERE CONTACTED AND STATED THERE WERE NO RECALLS FOR THE FAILURE AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 113,665.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10424172September 7, 2011
TIRES, TIRES:TREAD/BELT
THE REAR TIRES ON MY PICK UP TRUCK FAILED - THE TREAD SEPARATED - WHILE I WAS OPERATING ON A ROUTE 81 IN VA. THE TIRES FAILED WITHIN 100 MILES OF EACH OTHER AND THEY BOTH FAILED THE SAME WAY. I WAS TOWING A TRAILER, BUT ALL LOADS WERE WELL BELOW THE MAXIMUM CAPACITY RATINGS. THE FIRST TIRE ALSO RUPTURED/DEFLATED. THE OTHER TIRE DID NOT DEFLATE - ONLY LOST THE TREAD. THE TREAD WOUND AROUND THE AXLE DAMAGING THE PARKING BRAKE CABLE. BOTH WHEEL WELLS AND REAR FENDERS WERE DAMAGED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10422374August 29, 2011
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING APPROXIMATELY 55 MPH THE FUEL TANK DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED BOTH FUEL TANK STRAPS HAD CORRODED AND ONE OF THE STRAPS WAS FRACTURED. AFTER THE FUEL STRAPS WERE REPLACED, THE CONTACT NOTICED THE FUEL GAUGE READING DECREASED. THE VEHICLE BEGAN LEAKING APPROXIMATELY 15 GALLONS OF FUEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THE FUEL LINE HAD TO BE REPLACED. NHTSA RECALL CAMPAIGN NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) MAY BE RELATED TO THE FAILURE. THE TECHNICIAN STATED THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 216,776. THE ONE OTHER THING THAT WASN'T MADE CLEAR IN THE FIRST REPORT WAS THE TECHNICIAN DID NOT MAKE CLEAR THAT THE FUEL LINE CRACKED BECAUSE OF THE GAS TANK FALLING. UPDATED 10/26/2011 *LN *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10421298August 24, 2011
FUEL SYSTEM, GASOLINE
1999 FORD F250 SUPERDUTY PICKUP GAS TANK STRAPS RUST AND FAIL FORD HAS RECALLED OVER 1 MILLION TRUCKS BUT NOT MINE EVEN HERE IN VT WHERE MY DEALER SAYS THE TRUCK IS UNSAFE FORD WILL NOT FIX IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10417782August 6, 2011
SUSPENSION:FRONT
FRONT PASSENGER SIDE LOWER TRACK BAR BRACKETS WILL SHEAR OFF AND BREAK LEAVING TRACK BAR FLOATING IN FRONT END. THIS CAN OCCUR ON LOW MILEAGE VEHICLES AND IS REPORTED MANY TIMES ON THE INTERNET BUT NO ONE SEEMS TO DO ANYTHING ABOUT IT. THIS IS VERY DANGEROUS AND CAN LEAD TO A ROLLOVER OF THE VEHICLE. IT HAS HAPPEND SO MANY TIMES THAT AFTERMARKET COMPANIES ARE MAKING AFTERMARKET KITS TO REPAIR THE BROKEN BRACKETS NOW. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10417177August 5, 2011
TIRES, TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 1999 FORD F-250 EQUIPPED WITH COPPER DISCOVER A/T TIRES, 285/75/16. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, A NOISE WAS HEARD COMING FROM OUTSIDE OF THE VEHICLE. AFTER REACHING A SAFE LOCATION, THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT PASSENGER TIRE EXHIBITED A SUBSTANTIAL AMOUNT OF TREAD SEPARATION. THE TIRE WAS REPLACED WITH A SPARE TIRE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000. THE DOT NUMBER WAS UPYUC722503. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10417029August 4, 2011
FUEL SYSTEM, GASOLINE
1999 FORD 250 SUPER DUTY (NO INCLUDED IN CURRENT RECALL) FRONT FUEL TANK STRAP FAILED (BROKE), REAR STRAP VERY CLOSE TO BREAKING, PLASTIC FUEL TANK DROPPED APPROXIMATELY 6" WHEN FRONT STRAP FAILED. HAD REAR FAILED AS WELL, TANK WOULD HAVE DROPPED TO THE GROUND, WITH LIKELY ACCIDENT/FIRE. I HAVE REPLACED BOTH FUEL TANK STRAPS, REAR BROKE ON REMOVAL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10416889August 3, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED THAT WHEN EXITING HIS VEHICLE HE NOTICED THAT ONE OF THE FUEL TANK STRAPS HAD DETACHED FROM THE VEHICLE AND WAS COVERED WITH RUST. THERE WAS NO FUEL SPILLING FROM THE TANK. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR HAD IT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THEY WOULD LOOK INTO IT. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 91,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10414640July 22, 2011
WHEELS
TL* THE CONTACT OWNS A 1999 FORD 250. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED THAT THE VEHICLE BEGAN TO WOBBLE ABNORMALLY. THE CONTACT ALSO NOTICED THAT ONE OF THE DRIVER SIDE TIRES WAS DETACHED FROM THE VEHICLE THROUGH THE DRIVERS SIDE MIRROR. THE CONTACT WAS ABLE TO STOP THE VEHICLE AT THE SHOULDER OF THE ROAD BEFORE THE VEHICLE DROPPED TO THE GROUND. THE VEHICLE WAS TOWED TO AN AUTO REPAIR SHOP FOR INSPECTION BY THE INSURANCE COMPANY AND A MECHANIC. THE MECHANIC STATED THAT THE REAR DRIVER SIDE RIM WAS FATIGUED OR DISINTEGRATED AND CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS DECLARED AS DESTROYED AS A RESULT OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10408485June 22, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED WHILE DRIVING 35 MPH THE VEHICLE STARTED OVERHEATING. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THE RADIATOR NEEDED TO BE REPLACED. THE DEALER REPLACED THE RADIATOR AND IMMEDIATELY AFTER THE VEHICLE WAS REPAIRED THE VEHICLE STARTED TO OVERHEAT AGAIN. THE CONTACT TOOK THE VEHICLE TO A DIFFERENT DEALER WHO INFORMED THE CONTACT THAT THE HEAD GASKET WAS CRACKED. THE CONTACT CALLED THE MANUFACTURER REGARDING THE CRACKED HEAD GASKET AND THEY STATED THERE WAS NO RECALL; THEREFORE, THERE WERE UNABLE TO OFFER ANY ASSISTANCE. THE CONTACT STATED THIS WAS A COMMON FAILURE WITH HIS YEAR, MAKE, AND MODEL. THE FAILURE MILEAGE WAS 167,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10400796May 13, 2011
FUEL SYSTEM, GASOLINE
FUEL (GASOLINE) TANK STRAP FAILED DUE TO RUST. FUEL TANK DROPPED IN REAR CAUSING THE DRIVER TO NOTE THE TANK HANGING DOWN UNDER THE VEHICLE. TANK HAD TO BE TEMPORALILY SUPPORTED TO MOVE VEHICLE TO REPAIR FACILITY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10400623May 12, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT STATED THAT THE VEHICLE STALLED AS THE FUEL TANK STRAPS FRACTURED. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE STRAPS WERE RUSTED AND CORRODED. THE VEHICLE WAS NOT INSPECTED OR REPAIRED BY A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 240,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10397912April 26, 2011
UNKNOWN OR OTHER
WHILE DRIVING DOWN THE HIGHWAY THE ENGINE HESITATED THEN SEIZED UP. THE DRIVER PULLED OVER AND TURNED OFF THE ENGINE AT WHICH POINT THE VEHICLE WAS IN FLAMES. THE VEHICLE WAS A TOTAL LOSS. IT IS NOT KNOWN IF THIS VEHICLE HAD A RECALLED CRUISE CONTROL SWITCH AND AVAILABLE INFORMATION VARIES AS TO IF THIS MAKE/MODEL WAS INCLUDED. ALSO THE DEALER WHO SOLD US THIS VEHICLE APPROXIMATELY 14 MONTHS PRIOR TO THE FIRE DID NOT CHECK FOR RECALLS PRIOR TO RESELLING THE VEHICLE.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10394291April 5, 2011
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 1999 FORD F250 SD. THE CONTACT STATED THAT THE SPEED CONTROL DEACTIVATION SWITCH WAS LEAKING BRAKE FLUID AND AS A RESULT, THE CRUISE CONTROL FAILED. THE VEHICLE WAS TO THE DEALER WHO REFUSED TO DO ANY REPAIRS SINCE THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 06V286000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS CONTACTED WHO STATED IT WAS UP TO THE DEALER WHETHER THEY WOULD REPAIR IT FREE OF CHARGE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 219,838 AND THE CURRENT MILEAGE WAS 241,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10393641March 29, 2011
ENGINE AND ENGINE COOLING:ENGINE
FORD F250 V-10 ENGINE BLOWNING OUT SPARK PLUGS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10393515March 28, 2011
ENGINE AND ENGINE COOLING:ENGINE
TL* THE CONTACT OWNS A 1999 FORD F250 SD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR MAINTENANCE WHERE THEY DETECTED THAT THE ENGINE HEAD GASKET FAILED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 45,000. UPDATED 05/04/11 *BF THE HEAD GASKET WAS LEAKING OIL. UPDATED 12/19/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10392258March 20, 2011
ENGINE AND ENGINE COOLING:ENGINE
BLOWN SPARK PLUGS FROM FORD F250 V10 ENGINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10392260March 20, 2011
ENGINE AND ENGINE COOLING:ENGINE
FORD 5.4 LITRE TRITON V8 SPARK PLUG EJECTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10392266March 20, 2011
ENGINE AND ENGINE COOLING:ENGINE
FORD 1999 F250 5.4L TRITON V-8 BLEW SPARK PLUG. LOST POWER, CREATED ROAD HAZARD AND SCARED THE CRAP OUTTA ME WHEN IT BLEW. MADE IT TO SIDE OF ROAD SAFELY AND GOT TOWED. WENT ONLINE TO FIND OUT THIS IS A HUGE PROBLEM WITH THIS ENGINE AS WELL AS OTHER TRITONS. SPARK PLUG THREADS ARE VERY SHORT LENGTH. NOT JUST POORLY ENGINEERED BUT ENGINEERED TO FAIL. HAVE READ POSTS SAYING FIRES WERE CAUSED BY THIS PROBLEM WHEN FUEL MIXTURE EJECTED FROM HOLE CAUGHT FIRE FROM ARCING BLOWN PLUG. OTHERS CLAIM THE PLUG BLEW A DENT INTO HOOD. CANNOT IMAGINE THE DAMAGE TO AN EYE OR OTHER IF MECHANIC OR OTHER PERSON IS LOOKING DOWN INTO ENGINE LOOKING FOR REASON FOR TICKING NOISE, WHEN BAM, THE PLUG BLOWS OUT. FORD WILL FIGHT THIS TOOTH AND NAIL BECAUSE IT IS AN EXPENSIVE FIX. THEY MAKE TONS OF MONEY BY HAVING THEIR SHOPS PULL THE ENGINE AND REPLACE THE HEAD. PLEASE HELP US. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10383102February 17, 2011
ENGINE AND ENGINE COOLING
1999 F-250 SPARK PLUG DEFECT V8 5.4L HAD 2 SPARK PLUGS COME LOOSE. $700 TO REPLACE. MECHANIC LAUGHED AND SAID THEY HAVE A KIT FOR THIS DEFECT BECAUSE IT IS SO COMMON. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250