Ford F-150 Complaints (2022)

911 consumer complaints on file.

#11575010March 2, 2024
ENGINE
My engine failed do to faulty valves at 42000 miles. A check engine light came on and I took it to nearest ford dealership for repairs. It was originally missed diagnosed with faulty ignition coil on number 5 cylinder back in November 2023. Since then it has been determined to have issue mentioned above. They say they will need to replace entire engine. Not happy with this but what can an owner do. I have seen this has been common in other similar vehicles. Has ford found and fixed the problem or will this again happen with the new engine they put in?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11574139February 27, 2024
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
Vehicle's engine will not start. When attempting to start, it will turn on all usual electrical components, but will immediately show an warning message to "Stop Safely Now" along with an engine light of a red outlined truck with exclamation mark. Followed by a message of accessory mode on, however the engine will not start with no access to power steering or shifting gears. Normal attempts to jump start or charge the battery will not work. All fuses and harness connections appear to be normal. After researching Ford community forums, this appears to be a common complaint in the Powerboost Hybrid 2021-2022 Ford F-150s. Extremely inconvenient as this situation has left us stranded several hours from home with no reasonable solution other than to tow to a dealership. We hope our message helps encourage Ford Motor to continue researching the issue and come with a reasonable solution for all effected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11574037February 26, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, he became aware that the vehicle was averaging 4 MPG, consistently miscalculating the current fuel range. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to diagnose a failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 19,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11573902February 25, 2024
POWER TRAIN
While leaving a parking garage the transmission violently jerked out of gears pulling te steering wheel and no longer driving the rear driveline so the vehicle could no longer accelerate up the ramp. Vehicle behind me almost rear ended me. The transmission was hunting erratically between gear as seen by the indicator gears, 1st to 2nd to 8th to 10th to 4th rapidly and began to smell significantly. The only way to pull forward off the ramp was to engage 4WD Hi. No warning lights. Dealer tried to state potentially low battery voltage but the vehicle continues to exhibit surging shifts both upshifts and down shifts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11572581February 18, 2024
SERVICE BRAKES
While driving to work a car crossed over two lanes and pulled in front of me, I had to slam on the brakes to avoid a collision. The truck applied the brakes and that was avoided but at that moment my dash lights came on, no ABS, brake light, engine lights, and traction control all lit up. I was near my exit and got off applied the brakes and the pedal went to the floor. Basically no brakes, I was pumping and could hear some type of noise like a hissing or air leak. Because i was going up an incline was able to stop otherwise i would have hit someone. When I stopped could see brake fluid leaking and the truck also made like a pumping noise i believe from the brake system and another hissing sound. Had the truck towed to Ford - They stated a leaking brake line from EBB to the right front caliper. There was no leak until I slammed on the brakes. The truck has 27, 901 miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11572429February 16, 2024
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, SERVICE BRAKES, POWER TRAIN
While coasting to an upcoming stop downhill, on slightly graded slope, speed within 15mph or less, with brake slightly applied; the Automatic Parking Brake engaged on its own, subsequently resulting in the transmission shifting of drive modes to park automatically. The vehicle came to an instant, unexpected stop, while still maintaining a speed around 5mph on its own. The vehicle locked up mid-line-of-traffic, leaving the potential of a rear-end collision by following vehicle. No known damage to transmission or powertrain resulted. Adverse weather/road conditions did not play a factor at the time of incident. Incident has occurred multiple times prior, during similar environment & circumstance.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11571891February 14, 2024
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
Campaign/NHTSA# 23S30/23V418 Issue Date 2023-06-09 Description On your vehicle, it may be possible that your reversing lamps may not function due to microscopic cracks that can develop in the vehicles rear lightbar. If a microscopic crack is present, condensation can potentially enter the reversing lamp lens through these cracks and cause electrical failure to the reverse lamps. Safety Risk This may result in inoperative reverse lamps which can reduce the awareness of other motorists or road users of the drivers intention to operate the vehicle in reverse gear, increasing the risk of injury or crash. Remedy Ford Motor Company has authorized your dealer to replace the rear lightbar free of charge parts and labor. Campaign/NHTSA# 23C38/23V801 Issue Date 2023-11-28 Description Affected vehicles may have software logic that does not reset the electronic stability control esc system to default operation at the initiation of each ignition cycle. Section 5.4.1 of fmvss no. 126 requires that the vehicles esc system return to the manufacturers original default esc mode at the initiation of each ignition cycle Safety Risk The vehicle operator may not notice that the vehicle operates differently after receiving the ota update 6.3.0 and now remains in off-road mode with a reduced esc state after cycling the ignition. If the vehicle operator does not notice the esc off telltale in the cluster, they may not know the vehicle is in a reduced esc state. For these vehicles, failing to revert back to a normal esc-on state after being in off-road mode makes the vehicles noncompliant to fmvss no. 126, increasing the risk of crash. Remedy The remedy for this program is a software update to accessory protocol interface module apim. Ford began Ford power-up over-the-air deployments to update the apim software for affected vehicles in November 2023. Alternatively, owners will have the option to take their vehicle to a Ford or Lincoln dealer to complete the software update. Campaign# 23B1
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11570776February 8, 2024
VEHICLE SPEED CONTROL, ENGINE
The contact owns a 2022 Ford F-150. The contact stated that while attempting to start the vehicle in a driveway, it failed to turn over and start. The contact depressed the brake pedal and the start-stop button again, but it failed to start. After another attempt, the vehicle restarted, inadvertently accelerated, and crashed into a wooden fence. There were no reported injuries. There was no air bag deployment, fire, or police report filed. The vehicle was towed to a collision center. The contact called the local dealer, who referred him to the manufacturer. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred to the NHTSA hotline. The failure mileage was approximately 12,000. The VIN was not available.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11570270February 6, 2024
VISIBILITY:SUN/MOON ROOF ASSEMBLY
The contact owns a 2022 Ford F-150. The contact stated that upon entering the vehicle, the passenger’s side seat was wet. Upon further inspection, the contact noticed that the entire front passenger’s side headliner was damp due to moisture. In addition, the contact stated that while observing the vehicle going through a car wash, water was pouring into the vehicle through the panoramic sunroof. The vehicle was taken to the dealer, and it was confirmed that the panoramic sunroof was leaking; however, the dealer was unable to repair the vehicle. The contact was referred to the manufacturer and a case was filed. The contact was then referred to the NHTSA Hotline for additional assistance. The vehicle was not repaired. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11570265February 6, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
The climate control system will malfunction and make the cab of the truck unbearably hot, even to the point of physical discomfort at the feet of the driver. The air is so hot blowing on the drivers feet that I have to remove my feet from the pedals to cool. This is a major distraction to the driver. The dealer says this is normal. No warnings or alarm messages.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11570030February 5, 2024
STEERING, ENGINE, UNKNOWN OR OTHER
2022 ford raptor. Oil leak passenger side vehicle, Exhaust rattle while idle. Parked vehicle in garage smell oil inside garage, upon inspection found large oil leak on garage floor, when underneath vehicle and found oil leak from cover plate and front axle, steering components. Made a service appointment with local Ford dealership Long Lewis ford Prattville, Al. Vehicle odometer reading on vehicle 17,388.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11569549February 2, 2024
SERVICE BRAKES, HYDRAULIC, POWER TRAIN
The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, the brake pedal depressed the floorboard but failed to bring the vehicle to a complete stop. As a result, the contact collided with the rear of two vehicles ahead. The air bags did not deploy. A police report was not filed, and no injuries were reported. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact also stated that sometime later, while his wife was driving at an undisclosed speed, a message displayed reading "Full Accessory Power Active," after which the vehicle inadvertently lost all motive power. The contact's wife was able to coast to the shoulder of the roadway, where the vehicle was able to restart. After restarting the vehicle, the vehicle returned to normal functionality. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 9,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11568430January 29, 2024
UNKNOWN OR OTHER
Recently completed the safety recall for my 2022 F150 axle bolt replacement. The dealer informed me that this is a "repair" and not a solution to why the axle bolt broke leading to replacement of both the left and right axle shafts. My dealer service manager told me Ford does not have a permanent "fix" to the axle bolt problem and will keep my recall service ticket open as this bolt may break again. I am concerned about my safety driving this truck now. Please assist with my issue and others who are experiencing this same problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11568000January 26, 2024
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, VEHICLE SPEED CONTROL
Runaway Throttle at least 8 times now: 1. Driving in adaptive cruise control when deactivated by manual braking (to turn into a parking lot, which is a more common scenario for a brake based shutoff) 2. Parked nose first and shut off the truck 3. Start truck and reverse out of parking space 4. Shift to drive, apply throttle gently and truck continues to accelerate when throttle released requiring a PANICKED brake application
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11567715January 25, 2024
VISIBILITY/WIPER
I received a recall for a windshield wiper motor and took my vehicle to a dealership to have it fixed. Before I went I checked several times to ensure they had the part to perform the recall and they informed me they did. I took it in 01/19/2024 for the recall, waited two and an half hours and they never performed the recall. When I asked the dealership why they did not have an answer and said they would call me back. They have not as of 01/25/2024. I have in the mean time contacted Ford who said the recall should have been performed to take it to another dealership to have it done because it is an active recall. I just don’t understand how the dealership decided what Ford said was a recall did not need to be done and they are a ford dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11567084January 22, 2024
ENGINE, POWER TRAIN, UNKNOWN OR OTHER
While driving down the highway, my 2022 Ford F-150 Tremor randomly caught on fire. I was driving down the highway and was flagged down by other drivers to let me know the bottom of the truck was on fire. I pulled over and luckily someone had a fire extinguisher and we were able to get the fire under control. The fire department was also called and they also helped put out the fire after their arrival. The truck has always been serviced at a Ford dealer and had gone in for an oil change less than 350 miles prior to the truck catching fire.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11566926January 22, 2024
UNKNOWN OR OTHER, EQUIPMENT:APPLIANCE:TV/RADIO/SPEAKERS
The radio will make a loud popping static noise that is louder than a gun shot. Damaging to my ears and children.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11566478January 19, 2024
UNKNOWN OR OTHER
Speakers (B&O) - I turned on the vehicle from a cold start and I began to hear what I thought was rats invading the rear interior of the vehicle, I heard a loud crunching noise. I turned the stereo down and it was not as pronounced. I began to drive and the sound continued loud cracking and soft at times coming from the front and rear speakers. It was annoying and very loud popping at times. It did not stop when I turned the radio down but it did stop when I got to my destination 10 minutes later. The issue has not reoccurred since but I feel like the rear speakers are not as loud as they once were. I did. It feel my safety was in jeopardy but the sounds was annoyingly loud. No warning lights came on and the Ford app stated there were no problems. I have not yet brought the vehicle I got the dealer. I will be scheduling in the coming days.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11565951January 17, 2024
ELECTRICAL SYSTEM, ENGINE
Vehicle will not start. Get "Stop safely now" message. It is 16 degrees outside. What if this had happened while I was out. This would be a life threatening problem. This appears to be a known issue, but Ford has not fixed it. There are hundreds of reports on various forums of the same problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11565978January 17, 2024
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, the check engine and transmission warning lights illuminated, and the Check 4x4 and Check Locking Differential messages were displayed. Additionally, while driving, there were popping sounds heard coming from underneath the vehicle. The vehicle also rolled about 4-6 inches while the transmission was in park (P). The vehicle was taken to the dealer; however, only the Check Locking Differential message was displayed. The dealer reset the Check Locking Differential message. The failure recurred with the Service Rear End message displayed and abnormal sounds coming from both the front and rear ends of the vehicle. The vehicle was taken back to the dealer; however, the dealer was unable to duplicate the failure. The vehicle was not repaired. Upon investigation, the contact related the failure to NHTSA Campaign Number: 23V896000 (Power Train) for which the VIN was included. The manufacturer was not made aware of the failure. The failure mileage was approximately 6,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150