Ford F-150 Complaints (2003)

423 consumer complaints on file.

#11365770October 22, 2020
POWER TRAIN
TL* THE CONTACT OWNS A 2003 FORD F-150. THE CONTACT STATED THAT WHILE THE KEY WAS IN THE IGNITION SWITCH, THE VEHICLE FAILED TO SHIFT GEAR AS DESIGNED. THE CONTACT HAD TO SHIFT THE GEAR FROM PARK TO NEUTRAL AND BACK INTO PARK THEN NEUTRAL AGAIN FOR THE VEHICLE TO RESUME NORMAL OPERATION AND TURN ON. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 86,341.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11342285July 30, 2020
ENGINE
TL* THE CONTACT OWNS A 2003 FORD F-150. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE FROM DRIVING, THE VEHICLE BEGAN TO SMOKE FROM THE DRIVER'S SIDE OF THE VEHICLE. THE CONTACT STATED THAT SHORTLY AFTER THE VEHICLE CAUGHT ON FIRE UNDER THE HOOD ON THE DRIVER'S SIDE. THE FIRE DEPARTMENT CAME TO PUT OUT THE FIRE AND FILED A POLICE REPORT. THE VEHICLE WAS TOWED AND DEEMED TOTALED. THE CONTACT HAD CONTACTED THE DEALERSHIP (SAM PACK'S FIVE STAR FORD ADDRESS: 1635 S INTERSTATE 35E, CARROLLTON, TX 75006 PHONE: (972) 446-5027) WHO INFORMED THAT THERE WAS NO RECALL ON THEIR VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 240,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11327230June 4, 2020
ENGINE, FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 FORD F-150. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT HAD BEEN ILLUMINATED SINCE THE DAY OF PURCHASE. THE CONTACT ALSO STATED THAT WHILE THE VEHICLE WAS PARKED IN THE CAR PORT THE VEHICLE SUDDENLY CAUGHT ON FIRE. THE FIRE DEPARTMENT CAME AND PUT OUT THE FIRE. A FIRE DEPARTMENT REPORT WAS MADE. THE VEHICLE WAS DEEMED TOTALED AS WELL AS DAMAGED THE CONTACT'S RESIDENCE. THERE WERE NO INJURIES. THE CONTACT CONTACTED A CERTIFIED MECHANIC WHO INFORMED THEM OF A RECALL FOR THE YEAR/MAKE/MODEL, NHTSA CAMPAIGN NUMBER: 06E056000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THE VIN HAD NOT SHOWN TO BE INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 203,000. *BF *DL
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11318269March 16, 2020
ENGINE
TL* THE CONTACT OWNED A 2003 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL) AND A REPAIR APPOINTMENT WAS SCHEDULED WITH THE LOCAL DEALER. THE CONTACT STATED THAT HE WAS NOT INFORMED BY THE DEALER THAT THE DEFECTIVE PART COULD HAVE BEEN DISCONNECTED FROM THE VEHICLE TO AVOID A FIRE WHICH WAS STATED IN THE RECALL REMEDY. THE CONTACT STATED AFTER HIS GIRLFRIEND PARKED THE VEHICLE, ABOUT FOUR AND A HALF HOURS LATER THE VEHICLE UNEXPECTEDLY WAS ENGULFED IN FLAMES FROM THE ENGINE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FLAMES. A FIRE DEPARTMENT REPORT WAS FILED. THE CONTACT STATED THAT TWO OTHER VEHICLES WERE DAMAGED BY THE FIRE. THE DEALER WAS NOTIFIED OF THE INCIDENT AND CANCELED A SCHEDULED APPOINTMENT HOWEVER THE MANUFACTURER WAS NOT MADE AWARE OF THE INCIDENT. THE FIRE DEPARTMENT DEEMED THE VEHICLE A TOTAL LOSS. THE FAILURE MILEAGE WAS 196,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11308483February 11, 2020
AIR BAGS
TL* THE CONTACT OWNED A 2003 FORD F150. WHILE DRIVING 55 MPH THE VEHICLE SLID ON BLACK ICE CAUSING THE VEHICLE TO COLLIDE WITH THE GUARD RAIL SEVERAL TIMES. THE CONTACT STATED THAT NO WARNING LIGHTS WERE ILLUMINATED PRIOR TO THE COLLISION. THE AIRBAGS DID NOT DEPLOY IN THE VEHICLE. THE CONTACT STATED THAT HE SUFFERED WHIPLASH AND BRUISED MUSCLES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE CONTACT STATED HE WAS ABLE TO DRIVE THE VEHICLE TO HIS PLACE OF EMPLOYMENT HOWEVER, THE HE DRIVE SLOWLY AS THE VEHICLE WAS SHAKING. THE VEHICLE WAS TOWED 2 DAYS LATER BY THE INSURANCE COMPANY AND DEEMED A TOTAL LOSS. THE CONTACT WAS UNAWARE OF THE AIR BAGS FAILURE WAS DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS AVAILABLE. THE FAILURE MILEAGE WAS 116,807.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11282572November 26, 2019
SERVICE BRAKES
NOTHING HAS REALLY HAPPENED BUT BOTH ANTI LOCK BRAKE WIRES KEEP RUBBING ON THE RIMS AND WHERING THROUGH I HAVE REPLACED BOTH SIDES TWICE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11277644November 2, 2019
TIRES, TIRES:SIDEWALL
ONE GENERAL GRABBER STX, FROM WALMART, ON FRONT OF F150 BASE MODEL TRUCK SHREDDED ON HIGHWAY. FOLLOWING DAY THE OTHER FRONT TIRE OF SAME YEAR AND MODEL OF TIRE SHREDDED. THEY SHREDDED AT 49,189 MIES, 3YRS OF USE, STILL UNDER TIRE MANUFACTURERS WARRANTY. DOT: A30KHM580816 AND A30KHM581316. I SUSPECT THE MODEL OF TIRE CAN'T HANDLE THE LOAD OF THE FRONT OF THE TRUCK. WHEREAS THE EXACT SAME MODELS OF TIRES AND SAME DOT NUMBERS ON THE REAR ARE STILL RUNNING ON THE TRUCK WITH 2900 MILES MORE. THE SET OF THESE FOUR TIRES WERE ALL INSTALLED ON THE SAME DATE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11277645November 2, 2019
TIRES, TIRES:SIDEWALL
ONE GENERAL GRABBER STX, FROM WALMART, ON FRONT OF F150 BASE MODEL TRUCK SHREDDED ON HIGHWAY. FOLLOWING DAY THE OTHER FRONT TIRE OF SAME YEAR AND MODEL OF TIRE SHREDDED. THEY SHREDDED AT 49,189 MIES, 3YRS OF USE, STILL UNDER TIRE MANUFACTURERS WARRANTY. DOT: A30KHM580816 AND A30KHM581316. I SUSPECT THE MODEL OF TIRE CAN'T HANDLE THE LOAD OF THE FRONT OF THE TRUCK. WHEREAS THE EXACT SAME MODELS OF TIRES AND SAME DOT NUMBERS ON THE REAR ARE STILL RUNNING ON THE TRUCK WITH 2900 MILES MORE. THE SET OF THESE FOUR TIRES WERE ALL INSTALLED ON THE SAME DATE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11270871October 24, 2019
SERVICE BRAKES
BRAKE PEDAL BECAME SPONGY AT FIRST BUT THEN WENT CLEAR TO THE FLOOR WHEN ATTEMPTING TO STOP. THE VEHICLE STOPS BUT WITH VERY LONG REACTION TIME. THE MASTER CYLINDER WAS REPLACED WITH A NEW UNIT...BUT THE PROBLEM PERSISTED. ABS UNIT WAS THEN REPLACED WITH SALVAGE UNIT...PROBLEM STILL PERSISTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11270276October 22, 2019
UNKNOWN OR OTHER
LA GUAGUA ESTANDO ESTACIONADA EN LA MARQUESINA APAGADA. SE ENCENDI POR EL LADO DEL CHOFER EN MOTOR CERCA DE LOS FRENOS.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11269490October 18, 2019
UNKNOWN OR OTHER
GAS TANK STRAP BROKE WAS THIS A RECALL ON THIS VEHICLE?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11252023August 28, 2019
ENGINE
REQUESTNG FORD BE MADE TO ISSUE A RECALL FOR EXHAUST MANIFOLD HOLES AND CRACKING ISSUES. THIS ISSUE IS KNOWN AND THE ARE MULTIPLE FORUMS ONLINE WHERE PEOPLE ARE TALKING ABOUT HAVING THIS ISSUE. WHEN THE MANIFOLD LEAKS, THE RISK IS THERE THAT EXHAUST FUMES CAN GET INTO THE DRIVING COMPARTMENT AND ASPHYXIATE THE PEOPLE IN THE CAR. IT IS AN EXPENSIVE REPAIR FOR AN ISSUE FOR SHOULD HAVE RESOLVED LONG AGO.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11240653July 30, 2019
UNKNOWN OR OTHER
DRIVING A 2003 FORD F-150, LARIAT, SUPER CREW, GOING APPROXIMATELY 40 MPH AND ACCELERATING, ON THE ON-RAMP ENTRANCE TO CA STATE ROUTE 108, FROM STANDARD ROAD IN SONORA, CA, ON JULY-3-2019, THE WHEELS LOCKED AND THEIR WAS A LOSS OF STEERING. THE TIME WAS APPROXIMATELY 11 AM, ROAD WAS DRY, FAIR SKIES, NO DEBRIS OR OBSTACLES ON ROADWAY. THE ROAD WAS IN GOOD CONDITION. ONE WEEK EARLIER REPLACED ALL TIRES AT BIG O TIRES, SONORA, CA; THE WHEEL ALIGNMENT WAS CORRECTED AT THAT TIME. THE ON-RAMP WAS CURVING NORMALLY TO THE RIGHT, PROVIDING ACCESS TO THE WESTWARD BOUND TRAFFIC LANE. WHEN THE WHEELS LOCKED THE VEHICLE SPUN TO RIGHT, BUT TURNING THE STEERING WHEEL TO LEFT, INTO THE SPIN HAD NO EFFECT ON THE SPIN-OUT. THE PICK-UP TURNED 180 DEGREES, AND THEN ROLLED DOWN THE EMBANKMENT ON THE INSIDE OF THE ON-RAMP CURVE, THE NORTH-SIDE OF THE ON-RAMP. I WAS INJURED, EMS REQUIRED I BE FLOWN BY HELICOPTER TO THE MEMORIAL HOSPITAL IN MODESTO, CA. THE CA HIGHWAY PATROL INVESTIGATED THE ACCIDENT, AND PERSUMABLE TOOK A WITNESS STATEMENT FROM THE TRUCK DRIVER WHO WAS FOLLOWING ME AS WE ENTERED THE ON-RAMP. THE WITNESS, WHO HAD IMMEDIATELY RAN DOWN THE EMBANKMENT TO RENDER ASSISTANCE, SAID HE HAD NEVER SEEN ANYTHING LIKE IT BEFORE, THE WHEEL JUST COME OFF. BEING INCAPACITATED FROM THE ROLLOVER WRECK, I DID NOT GET THE NAME OF THE WITNESS, BUT THE INVESTIGATING OFFICE MUST HAVE. THE ACCIDENT REPORT IS NOT AVAILABLE AS OF THIS REPORT WRITING.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11235166July 26, 2019
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2003 FORD F-150. THE CONTACT'S SISTER SMELLED SMOKE COMING THEIR BEDROOM WINDOW. THE CONTACT WENT OUTSIDE AND NOTICED THAT THE VEHICLE CAUGHT ON FIRE. THE FIRE STARTED FROM THE DRIVER SIDE. THE CONTACT EXTINGUISHED THE FIRE WITH THEIR WATER HOSE. NO POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS NOT TOTALED HOWEVER THE FRONT HOOD AND PASSENGER SIDE WAS MELTED. THE VEHICLE WAS NOT DRIVABLE. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED TO TAKE THE VEHICLE TO HENSON FORD (581 1-45, MADISONVILLE, TX 77864). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 200,020.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11207740May 15, 2019
SERVICE BRAKES
TL* THE CONTACT OWNS A 2003 FORD F-150. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND IT TRAVELED TO THE FLOORBOARD. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED EVERY DAY FOR APPROXIMATELY A WEEK. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC. THE APPROXIMATE FAILURE MILEAGE WAS 178,157.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11193920April 4, 2019
TIRES, TIRES:SIDEWALL
I HAD A CATOSTROPHIC SIDEWALL FAILURE OF A GOODYEAR WRANGLER DURATRAC TIRE (MDW8 B11V 4110) THAT HAD ONLY 2140 MILES ON IT. THE TIRE FAILED AT 35 MPH BUT HAD TO BE DRIVEN ABOUT 100 FEET TO REMOVE IT SAFELY FROM THE ROADWAY. I HAVE A PICTURE OF THE RESULT IF NEEDED. HAD THIS HAPPENED ON THE INTERSTATE THE RESULT WOULD HAVE BEEN SIGNIFICANT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11191148March 23, 2019
ELECTRICAL SYSTEM, ENGINE, VISIBILITY/WIPER
AFTER A RAINSTORM AND WHILE DRIVING, MY WINDSHIELD WIPERS STOPPED WORKING, MY RADIO/CD PLAYER STARTED TURNING OFF AND ON, MY PANEL LIGHT DIMMED, AND I HEARD A CLICKING NOISE UNDER MY DRIVER SIDE DASH BOARD. THERE WAS ALSO A CLICKING NOISE COMING FROM THE ENGINE. WHILE STATIONARY AND KEY OUT OF THE IGNITION, I NOTICED WATER ON THE DRIVER SIDE FLOOR, AND WHEN I LOOKED UNDER I COULD SEE DROPS OF WATER SLIDING OFF I BELIEVE MY EMERGENCY BAKE AND BRAKE PEDAL, AND AN ONGOING CLICKING SOUND UNDER THE STEERING WHEEL. I LEFT MY TRUCK IN DRIVEWAY OVERNIGHT, AND THE NEXT MORNING MY BATTERY WAS DEAD. I HAD AAA TOW COME AND REPLACE BATTERY THAT AFTERNOON. THE NEXT MORNING THE BATTERY WAS DEAD AGAIN. AAA CAME AND CHECKED THE STARTER AND ALTERNATOR, ALL WERE FINE. AS THEY RECHARGED BATTERY THERE WAS A WEIRD NOISE HEARD IN THE ENGINE AREA. I DROVE IT TO A MECHANIC WITH FORD TRUCK EXPERIENCE. HE STATED THE GEM AND FUSE BOX WERE WET AND ATTRIBUTED IT TO WATER LEAKAGE COMING FROM THE WINDSHIELD WEATHER STRIPPING TRIM WHICH WAS COMMON IN FORDS VEHICLES. HE RECOMMENDED REPLACING GEM, FUSE BOX, AND WINDSHIELD TRIM. THIS WATER/ELECTRICAL PROBLEM HAPPENS EVERY YEAR AFTER A RAINSTORM. I NEVER THOUGHT A VEHICLE IN GOOD CONDITION COULD HAVE OUTSIDE WATER LEAKS GETTING INSIDE AND ONTO THE FUSE BOX AND GEM MODULE. THE MECHANIC TOLD ME IT CAN BECOME VERY DANGEROUS FOR THE GEM AND FUSE BOX TO FAIL BECAUSE IT CONTROLS EVERYTHING IN THE TRUCK. THE GEM AND FUSE BOX SHOULD BE PROTECTED FROM OUTSIDE ELEMENTS. WHEN WATER IS INTRODUCED TO THESE MODULES, IT MAKES THE WHOLE SYSTEM GO WACKY AND CAN CAUSE SERIOUS AND POSSIBLY DANGEROUS SITUATIONS. FORD NEEDS TO ACKNOWLEDGE THAT THIS IS A MANUFACTURE DEFECT AND FIX AND/OR REIMBURSE US CONSUMERS ON THE COST OF FIXING IT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11187422March 17, 2019
AIR BAGS
MY SON WAS DRIVING DOWN THE MAIN STREET IN OUR TOWN GOING THE SPEED LIMIT, CROSSED OVER THE RAILROAD CROSSING AND BOTH AIRBAGS DEPLOYED EVEN THOUGH THERE HAD BEEN NO COLLISION OR IMPACT OTHER THAN THE SMALL BUMP OF THE RAILROAD CROSSING. THANKFULLY, IT DID NOT CAUSE HIM TO LOSE CONTROL OF THE VEHICLE. THE IMPACT OF THE AIRBAG DID SLIGHTLY INJURE HIS WRIST, HE DID NOT SEEK MEDICAL TREATMENT. THE HORN BLEW CONTINUOUSLY UNTIL HE UNHOOKED IT. HOWEVER THE TRUCK WAS FULLY DRIVABLE IMMEDIATELY, SO HE CALLED US ASKING WHAT TO DO AND WE HAD HIM DRIVE IT HOME. THERE WAS NO WRECK OR ANY KIND OF IMPACT THAT SHOULD HAVE MADE THE AIRBAGS DEPLOY. THE TRUCK IS IN THE SAME WORKING ORDER THAT IT WAS PREVIOUSLY EXCEPT FOR BOTH FRONT AIRBAGS ARE DEPLOYED. THE AIRBAGS HAVE NEVER BEEN TAMPERED WITH THAT WE ARE AWARE OF. WE ARE NOT THE ORIGINAL OWNERS OF THE TRUCK, HOWEVER. THIS INCIDENT WAS REPORTED TO OUR INSURANCE COMPANY.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11180820February 18, 2019
VEHICLE SPEED CONTROL
GAS PEDAL IS STICKING. TRUCK SPEEDS UP, ONLY WAY TO STOP IS SHIFT TO NEUTRAL.HAPPENED ON HIGHWAY AND I SHIFTED TO NEUTRAL AND HIT PEDAL SEVERAL TIMES TO GET BACK TO IDLE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11127941September 6, 2018
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE DEALER (LYNCH FORD CHEVROLET INC, 410 US-30, MT VERNON, IA 52314, 319-895-8500) WAS CONTACTED AND CONFIRMED THAT PARTS FOR THE RECALL REMEDY WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150