Ford F-150 Complaints (2008)

369 consumer complaints on file.

#10478234October 1, 2012
SERVICE BRAKES
FRONT ROTORS NEEDED REPLACED AT 20000 MILES THEN AT 44000 MILES....IN ALL THE VEHICLES I OWN HAVE NEVER HAD TO REPLACE????WARPED ROTORS COSTING OVER 600 TO REPLACE EVERY 20 TH MILES....DEFECTIVE!!!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10477246September 27, 2012
STEERING
TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING 40 MPH THE STEERING WHEEL SEIZED WHILE MAKING A TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC CONFIRMED THAT THE STEERING SHAFT AND UNIVERSAL JOINT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 42,100 AND THE CURRENT MILEAGE WAS 42,220... UPDATED11/01/12 *BF THE CONSUMER STATED THE STEERING WHEEL WOULD NOT SELF CORRECT AFTER MAKING A TURN. 11/02/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461614June 19, 2012
VEHICLE SPEED CONTROL
2008 FORD F-150. CONSUMER STATES ACCELERATION ISSUES WITH VEHICLE *TGW THE CONSUMER STATED HE BEGAN EXPERIENCING SUDDEN ACCELERATION PROBLEMS IN EARLY APRIL 2012. THE FIRST TIME IT OCCURRED, HE WAS BACKING DOWN A BOAT RAMP, WHEN ALL OF A SUDDEN, THE VEHICLE ACCELERATED. THE CONSUMER HAD THE BRAKE PEDAL ALL THE WAY TO THE FLOOR. FINALLY, HE USED THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR A AN INSPECTION. HOWEVER, THE DEALER WAS UNABLE T DUPLICATE, THE CONSUMERS CONCERN. AFTER LEAVING THE DEALERSHIP, DRIVING AT A VERY SLOW SPEED, HE APPLIED THE BRAKE, BUT THE VEHICLE SUDDENLY ACCELERATED OUT OF CONTROL AND ONTO THE INTERSTATE. THE CONSUMER STATED HE HAD THE BRAKE PEDAL TO THE FLOOR, THE ENGINE WAS RACING AT HIGH RPM'S AND AT THAT POINT, HE SLAMMED THE TRANSMISSION INTO PARK. THE CONSUMER STATED HE HAS EXPERIENCED SUDDEN ACCELERATION ON SEVERAL OCCASIONS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461318June 12, 2012
STEERING, SERVICE BRAKES
BOUGHT A 2008 FORD F150 FROM A SO CALLED REPUTIBLE DEALER. HAD ISSUES AFTER THE FIRST COUPLE OF MONTHS WITH A VIBRATION TOOK VEHICLE BACK TO DEALER RAN A DIAGNOSTICS CHECK ON IT, THEY SAID NOTHING IS WRONG. TWO YEARS LATER PROBLEM HAS ESCALATED WHERE TRUCK VIBRATES SO BAD THAT IT SPILLS A CAN OF SODA. FORD NOW SAYS NO WARRANTY LEFT ON VEHICLE AND WE HAVE TO PAY FOR FIXING. IT WAS UNDER WARRANTY TWO YEARS AGO WHEN PROBLEM ARISED. I AM VERY UNHAPPY WITH THE DEALERSHIP AND FORD ITSELF. I AM THINKING ABOUT FILING A LAW SUIT AGAINST FORD IF THE PROBLEM IS NOT RECTIFIED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460672June 5, 2012
STEERING, SUSPENSION
IT FELT AS IF STEERING WAS BINDING WHEN MAKING A TURN. IT WOULD SUDDENLY BREAK FREE AND OVERSTEER WAS A PROBLEM. WHEN COMING OUT OF A TURN THE WHEEL WOULD NOT CENTER ON ITS OWN, BUT HAD TO BE TURNED BACK TO THE STRAIGHT AHEAD POSITION. SPOKE WITH A FORD DEALER AND THEY WANTED AN EXORBITANT CHARGE TO JUST LOOK AT THE VEHICLE AND PROFESSED THEY HAD NOT HEARD OF THE PROBLEM BEFORE. I WENT ON THE INTERNET AND FOUND AT LEAST TWO HUNDRED (200) REFERENCES TO THE EXACT ISSUE. IT WAS THE LOWER STEERING SHAFT UNIVERSAL JOINTS THAT HAD SEVERELY CORRODED. I LUBED THE JOINTS AND THINGS WENT BACK TO NORMAL FOR A FEW DAYS AND THE BINDING RETURNED. I INSTALLED A NEW LOWER SHAFT - FORD PART8L3ZB767B- AND THE TRUCK STEERS LIKE NEW. THE ORIGINAL PART ENDED IN A AND THE B REPRESENTS AN UPDATED VERSION. OBVIOUSLY FORD IS AWARE OF THE PROBLEM AND HAS ENGINEERED A FIX - AND NEVER NOTIFYING THE CONSUMER. A TRUE CONCERN IS THE FOLLOWING. OVER THE PAST FEW MONTHS WHEN DRIVING STRAIGHT THE WHEEL SHOWED ABOUT 15 DEGREES OF RIGHT INPUT WHILE TRACKING STRAIGHT, HANDS OFF. I HAD THE ALIGNMENT CHECKED AND ALL OK. IT WAS NOT PULLING, JUST A DISPLACED FROM CENTER WHEEL POSITION. THIS HAS ALL DISAPPEARED WITH THE NEW SHAFT. ON THE SAME ROADS, SAME CONDITIONS THE WHEEL IS PERFECTLY CENTERED. THIS TELLS ME THE OLD SHAFT HAS SUFFERED SOME TYPE OF DEFORMATION, MOST LIKELY ASSOCIATED WITH THE UNIVERSAL JOINTS ON SAID SHAFT. THIS IS A DEFINITE SAFETY ISSUE AND SHOULD BE ADDRESSED BY FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459728May 26, 2012
FUEL/PROPULSION SYSTEM
TRUCK WOULD CRANK BUT WOULD NOT START. TOWED TO FORD DEALER AND PROBLEM TRACED TO CORRODED FUEL PUMP DRIVER MODULE. DIAGNOSE & REPAIR $235.80. THIS PART IS LOCATED IN AN AREA THAT IS SUBJECTED TO ROAD SALT & OTHER CONTAMINATES WHICH CASE CORROSION & FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10458653May 16, 2012
SERVICE BRAKES
TL* THE CONTACT OWNS A 2008 FORD F-150 FX2. THE CONTACT WAS DRIVING 35 MPH WHEN THE BRAKES WERE DEPRESSED AND THE STEERING WHEEL STARTED TO SHAKE. THE VEHICLE ALSO FAILED TO STOP PROPERLY. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THE MECHANIC STATED THAT BOTH ROTORS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 59,322 AND THE CURRENT MILEAGE WAS 59,383.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10458501May 14, 2012
ENGINE
HAD A P/M CHECK DONE ON MY VEHICLE BY MY MECHANIC. DURING THE CHECK, HE INFORMED ME THAT THE IGNITION COIL FOR CYLINDER 5 WAS GOING OUT. HE ADVISED THAT THIS WAS COMMON. HE ALSO ADV THAT HE NEEDED TO REPLACE THE SPARK PLUG BUT HE DID NOT WANT TO UNTIL I CHECK INFO ON THE 9/16 PLUG ON-LINE. THIS PLUG HAS HISTORY OF BREAKING (DESIGN FLAW- CARBON FUSING/REPLACEMENT MC PLUGS HAVE BEEN REDESIGNED) BASED ON INFO IN VARIOUS FORUMS. THE PLUG DID BREAK DURING EXTRACTION REQUIRING ADDITIONAL WORK/EXPENSE. CALLED A LOCAL FORD DEALER SERVICE MGR WHO ADVISED HE WAS UNAWARE OF THAT HAPPENING BEFORE 80K MLS. AN EMAIL TO FORD REVEALED THAT THEY ARE UNAWARE OF ANY PROBLEMS/RECALLS OR TSB (WHICH DO EXIST). IN OTHER WORDS, THEY WILL NOT DO ANYTHING. I AM NOW WORRIED ABOUT PLUGS BREAKING DURING SCHEDULED TUNE RESULTING IN ADDITIONAL EXPENSE EVEN AT FORD DEALER .(AS PER COMMENTS ON LINE FORUM) THIS IS CLEARLY A DESIGN FLAW W/ MOTORCRAFT PLUGS AND THEY KNOW IT (TSB'S) CAN YOU HELP? *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10456576April 26, 2012
SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 2008 FORD F150. THE CONTACT STATED THAT THE ACCELERATOR AND BRAKE PEDALS WERE POSITIONED TO CLOSE TO ONE ANOTHER. WHENEVER THE CONTACT DEPRESSED THE BRAKE PEDAL, HE ALSO UNINTENTIONALLY DEPRESSED THE ACCELERATOR PEDAL. THE DEALER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS ADDRESSING THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 59,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10452120March 18, 2012
ELECTRICAL SYSTEM
CABIN TEMPERATURE CANNOT BE REGULATED IN HEATING OR COOLING MODES. A CONSTANT TEMPERATURE CANNOT BE MAINTAINED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10450427March 6, 2012
VEHICLE SPEED CONTROL
WHILE BACKING UP TRUCK ACCELERATED ON ITS OWN,ALSO DID THE SAME WHEN STOPPED AT A LIGHT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10450448March 6, 2012
POWER TRAIN
SAFETY CONCERN. SOLENOID THAT ACTIVATES 4 WHEEL DRIVE FAILURE, CAUSES PARTIAL ENGAGEMENT OF 4 WHEEL DRIVE AT ANT TIME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10450165March 3, 2012
ENGINE AND ENGINE COOLING
I WAS DRIVING DOWN THE FREEWAY AT 60 MPH WHEN I HEARD A LOUD POP AND THE ENGINE DIED. I COASTED OFF THE FREEWAY WHICH WAS DIFFICULT BECAUSE OF THE TRAFFIC AND WAS ABLE TO GET IT ON THE OFF RAMP. I THEN STARTED THE TRUCK AND GOT IT IN THE DRIVEWAY OF A HOSPITAL. IT DIED AGAIN AND I STARTED THE TRUCK AND MOVED IT OUT OF THE ROAD WHEN I NOTICED SMOKE COMING FROM THE ENGINE. I LIFTED THE HOOD AND FOUND THE ENGINE ON FIRE. I WAS ABLE TO SMOTHER IT BY THROWING A JACKET ON IT. IT MELTED THE WIRING AND THE COMPUTER MODULES. I HAD THE VEHICLE TOWED TO MY MECHNICS SHOP AND FOUND IT HAD BLOWN A SPARK PLUG. I WENT HOME AND FOUND FORD WANTS TO REPLACE THE CYLINDER FOR A COST OF $3000. I HAD MY MECHANIC PUT IN A SLEEVE AND REPLACE ALL 8 SPARK PLUGS. BUT THEN I CALLED MY INSURANCE COMPANY FOR THE FIRE DAMAGE AND THEY HAD IT TOWED TO THE FORD DEALER WHO IS REPLACING THE MODULAR. THIS COULD HAVE BEEN MUCH MORE SERIOUS. FORD DENYS THEY HAVE ANY PROBLEMS WITH THEIR SPARK PLUGS. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10447705February 12, 2012
POWER TRAIN, ELECTRICAL SYSTEM
WHILE BACKING UP THE FOUR WHEEL DRIVE WENT OUT, AND WOULD ONLY OPERATE IN TWO WHEEL DRIVE. THIS HAPPENED WHEN IT WAS VERY SNOWY AND ICY ROAD CONDITIONS. CAUSE WAS FROM ELECTRIC ACTUATOR THAT ENGAGES 4X4 SYSTEM. VEHICLE HAD LESS THAN 19,000 MILES ON IT. FORD WOULD NOT REPAIR UNDER POWER TRAIN WARRANTY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10447344February 10, 2012
POWER TRAIN, VEHICLE SPEED CONTROL
WHILE DRIVING ON THE INTERSTATE AT 70 MPH, THE VEHICLE LOST ACCELERATION. THE RPM'S SHOT UP, AND TRUCK WOULD NOT ACCELERATE. IT WAS AS IF IT HAD SLIPPED INTO NEUTRAL. HAD TO PULL OVER ON SIDE OF HIGHWAY, AND TURN THE TRUCK OFF. THIS SEEMED TO RESET THE ISSUE FOR THE TIME BEING. HAS HAPPENED SEVERAL MORE TIMES. TOOK IT TO TWO DIFFERENT DEALERSHIPS. THE FIRST ONE CLEANED THE MAF SENSOR. THE SECOND DEALERSHIP FLUSHED THE TRANNY AND REPROGRAMMED THE TRUCK. NONE OF THESE SOLUTIONS HAVE WORKED. IT HAPPENED AGAIN THIS WEEK WITH MY TWO YOUNG CHILDREN IN THE CAR. WAS ABLE TO MAKE IT ONTO SHOULDER BEFORE AN ACCIDENT OCCURRED. HAVE ANOTHER APPOINTMENT AT DEALERSHIP TOMORROW MORNING. THIS IS DANGEROUS! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10445728January 29, 2012
VEHICLE SPEED CONTROL
IT WAS ABOUT 6:00AM WHEN I STARTED MY TRUCK UP AND DROVE TO MY MAIL BOX WHICH WAS ABOUT 300FT FROM MY CARPORT. I HAD BACKED MY TRUCK UNDER THE CARPORT TO REMOVE GROCERYS THE DAY BEFORE, SO I DROVE FORWARD TO THE MAIL BOX AND DROVE BACKWARDS TO PARK MY TRUCK BACK UNDER THE CARPORT,. I CAME TO A COMPLETE STOP AND TOOK MY FOOT OFF THE GAS PEDAL AND PRESSED THE BRAKE WHEN THE TRUCK STARTED SPINNING THE TIRES AS THOUGH THE ENGINE WENT TO FULL TROTTLE. I TOOK OF IN REVERSE RAN THRU A TWO FOOT DITCH, OVER MY OUTSIDE AIRCONDITIONER UNIT AND SLAMMED INTO MY BRICK HOME. I HAD APPLIED THE BRAKE AS HARD AS I COULD WITH NO EFFECT. UPON THE IMPACT WITH THE HOUSE I TURNED THE IGNITION SWITCH OFF TO STOP THE WHEELS FROM SPINNING . I COULD FINALLY PUT IT IN PARK . *TT
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10442774January 7, 2012
ENGINE AND ENGINE COOLING
150000 MILES THE ENGINE JUST STARTED TO MISS FIRE WE WERE TOLD THE ENGINE HAD TO BE DISMANTLED I WAS TOLD THE ENGINE JUST WORE OUT IT STILL RAN FINE UNTIL THERE WAS THE RIGHT THROTTLE POSITION THIS ENGINE WAS WELL MAINTAINED AND I MEAN WELL EVERY SERVICE RECORD SHOWED IT WAS BETTER THAN FORD RECOMMENDED CAN YOU BELIEVE IT JUST WORE OUT HOW CAN THIS HAPPEN WITH NOTHING BROKE OR DAMAGED JUST IT'S TIME 3 YEARS 150'000 MILES AND IT'S OVER FOR A ENGINE WHO EVER SAID THAT IF YOU MAINTAIN THE SERVICE AND ITS UP TO DATE THIS WONT HAPPEN AS FAR AS I CAN SEE FORD YOU CANT BUILD A ENGINE THAT CANT GO OVER 150,000 MI STOP BUILDING CHEAP INTERNAL PARTS RIP KING RANCH YOU WERE THE MOST GORGEOUS TRUCK ON THE ROAD. I HOPE YOU SEE THIS FORD I THINK IT HAS SOMETHING TO DO WITH THE BAD PLUG DESIGN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10436938November 24, 2011
POWER TRAIN, ENGINE AND ENGINE COOLING
THERE HAS BEEN SEVERAL TIMES WHILE I'M DRIVING AT A SLOW RATE OF SPEED AT 20 TO 30 MPH, MY RPM GAUGE WILL REV HIGH TO 4 TO 5 AND STAY THERE FOR SEVERAL MINUTES AND WILL GO BACK TO NORMAL RPM AFTER MY TRANSMISSION SHIFTS GEARS. I DON'T SEE WHY MY TRUCK NEEDS TO REV THAT HIGH AT A SLOW SPEED TO SHIFT GEARS. TO ME THAT SHOWS THAT MY TRANSMISSION IS SLIPPING GEARS OR THE GEAR RATIO WAS NEVER PROPERLY TUNED WHEN I BOUGHT THE TRUCK. MY TRUCK REVVING THAT HIGH WHILE I'M SLOWING DRIVING IS AN UNSAFE ACT AND COULD POTENTIALLY CAUSE MORE UNSAFE SITUATIONS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10434093November 3, 2011
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WOULD SMOKE WHEN THE IGNITION WAS STARTED. THE DEALER DIAGNOSED THAT THERE WAS A COMPUTER DEFECT, WHICH CAUSED THE VEHICLE TO BLOW BLACK SMOKE OUT OF THE EXHAUST PIPE. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 26,000 AND THE CURRENT MILEAGE WAS 28,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10430727October 18, 2011
SERVICE BRAKES, HYDRAULIC
ABS TONE RING BREAKAGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150