Ford Expedition Complaints (2020)

428 consumer complaints on file.

#11679083August 7, 2025
POWER TRAIN, VEHICLE SPEED CONTROL
The contact owns a 2020 Ford Expedition. The contact stated that while depressing the accelerator pedal, the vehicle failed to respond as intended and the vehicle lost power. A dealer was contacted. The vehicle was taken to a dealer to be diagnosed; however, the diagnostic result was not provided. The vehicle was not repaired. The manufacturer was not notified on the failure. The approximate failure mileage was 106,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678777August 6, 2025
VEHICLE SPEED CONTROL
The contact owns a 2020 Ford Expedition. The contact stated while driving 40 MPH and attempting to accelerate, the vehicle went into LIMP Mode and the vehicle lost motive power. The contact was able to pull over to the shoulder of the roadway and turned off the vehicle. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11677421July 31, 2025
POWER TRAIN
Driving and transmission gear bumping hard when shifting gears. Have pulled out twice to pass and transmission made hard bump and I could not go anywhere. The last time this happened was 7/29/25 and it made a lot of clanking noise and the faulty light came on. I let off the gas and it went back in gear and I made it home and have not drove it since. Ford dealership said there was no recall on transmission but I have read alot of complaints from other 2020 Expedition owners about this problem I have 70,000. plus miles and have taken extreme care of this vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676902July 29, 2025
POWER TRAIN
Failure of transmission, leading to unsafe operation on roadway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675756July 23, 2025
POWER TRAIN
Info sent to Ford in working with cust service w/o action: Our 2020 Expedition had 4 separate instances of slipping out of gear during a road trip (2 instances on 7/11 and 2 on 7/19). During each incident, the vehicle slipped gear at highway speed, RPMs maxed out on the dial, lost all acceleration and significant speed, and the vehicle remained unresponsive for several (3-5) seconds until finally accelerating after the unresponsive period. It goes without saying that completely losing gear at highway speed while navigating traffic is a serious life and safety issue. Having that occur four times on a single round trip presents unreasonable risk. We documented the mileage and engine conditions by taking a picture of the dash after recovering from each occurrence. Those details were shared with the Krieger Ford service center on 7/22. That Ford service team was not able to recover fault codes from this information. Without being able to identify a root cause based on lack of fault codes, Ford Service performed a transmission relearn on 7/22. The service team confirmed this step is an initial measure due to lack of codes and not being able to see inside the sealed transmission. Abandoning further assessment in favor of a potential but unlikely quick-fix may be appropriate with an inconvenience issue, but not acceptable on one with such serious consequences. I recognize that further assessment will require additional cost. The assessment cost relative to the risk associated with not properly addressing the root cause of this dangerous issue is clearly justified. I’ve previously communicated this same situation to Ford when it occurred on a road trip in July of 2024. We contacted the dealership (Germain Ford of Dublin) and were deferred multiple months due to Ford's transmission tech backlog. The codes were not available by the time a service appointment was open. Without error codes and a single occurrence at that time, Ford service was unable to investigate further.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675280July 22, 2025
ELECTRICAL SYSTEM
Just about every time we get in the vehicle the center screen won’t light up and requires a power and fast forward button to reset. Sometimes this needs to be done twice in one drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674473July 18, 2025
POWER TRAIN
The contact owns a 2020 Ford Expedition. The contact stated that while driving at various speeds, the vehicle failed to accelerate properly while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to a dealer; however, the dealer failed to duplicate the failure. The contact stated that after several visits to the dealer, the dealer acknowledged the failure, and a valve body replacement was performed. The contact stated that the failure returned, and the failure became more frequent. The vehicle was taken to a dealer, and the ignition coils and spark plugs were replaced. The vehicle was valeted back to the residence, and the valet informed the contact that the failure was still present. The valet brought the vehicle back to the dealer, where it remained. The vehicle was diagnosed with a defective transmission, and the contact was informed that the vehicle was no longer covered under warranty. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674561July 18, 2025
POWER TRAIN
Hard downshift, loss of power.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673872July 16, 2025
POWER TRAIN:AUTOMATIC TRANSMISSION, POWER TRAIN
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674028July 16, 2025
POWER TRAIN
The contact owns a 2020 Ford Expedition The contact stated while depressing the accelerator pedal, the vehicle failed to respond as intended. The contact stated that the gear shifter operated independently. A dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was notified on the failure and transferred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 127,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673694July 15, 2025
ENGINE, POWER TRAIN, FUEL/PROPULSION SYSTEM
On several occasions the engine has slipped/stalled. Vehicle has only 27k miles on it, single owner. When moving from a stoplight the engine "slipped", all lights came on "service alert" or something similar. Vehicle recovered but I am very uneasy as I am a [XXX] female usually [XXX] and often on a very busy section of [XXX]. (This has occurred multiple times) When increasing speed, as to pass a vehicle or otherwise, vehicle is unresponsive or lags. To be clear this happens at speeds of 40-50 mph. It is unpredictable when this will occur nor why. I will likely sell this vehicle due to this safety issue. I spoke with a service rep at the local ford dealership who was able to look into the vehicle computer remotely but there was no record of the "Alert" or otherwise. I took the vehicle to my local mechanic who drove it and was able to replicate the danger/slipping. I was advised to do "zip code" driving only. I believe this "engine slipping" is related to the Recall just issued except the 2020 Ford Expedition is not included in this recall. Others have noted this issue as well with NHTSA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673391July 14, 2025
POWER TRAIN, UNKNOWN OR OTHER, FUEL/PROPULSION SYSTEM
What component or system failed or malfunctioned, and is it available for inspection upon request? The Powertrain Control Module (PCM), which manages engine-transmission communication and regulates cooling system performance, malfunctioned, resulting in a cascade of related failures: Transmission system: Delayed shifting, hesitation, and eventually a “transmission stuck in park” code. Cooling system: Repeated overheating that led to a ruptured radiator. These issues stem from the faulty PCM referenced in Ford Recall 24E13, issued on April 25, 2025. Yes, the failed components remain in the possession of Harbin Motor Company in Scottsboro, AL, where the vehicle is still located. The vehicle has not been repaired and is available for inspection upon request. How was your safety or the safety of others put at risk? This vehicle was operated while exhibiting documented powertrain and overheating symptoms—including while transporting children. Harbin Ford repeatedly instructed continued use despite: Diagnostic scans on April 10, 2025 confirming PCM-related failures including “transmission stuck in park” and overheating. A coolant leak that occurred without warning lamps, leading to the radiator bursting. These failures put occupants at serious risk of breakdown or fire, especially in high-traffic or high-temperature driving conditions. Operating a vehicle with a malfunctioning PCM increases the likelihood of gear slippage, sudden deceleration, or complete transmission failure. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The issue has been repeatedly confirmed by Harbin Motor Company, an authorized Ford dealer: On April 10, 2025, a scan identified “transmission stuck in park,” overheating, and a third unidentified code. On May 15, 2025, the service manager Craig Davis confirmed the transmission had an internal issue requiring a full rebuild and located a coolant leak. These confirmations were documented via servi
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11671859July 8, 2025
POWER TRAIN
I’ve owned my 2020 Ford Expedition for just over a year. Initially, the transmission performed flawlessly. However, over time I’ve noticed a few concerning issues: At low speeds, the transmission shifts very hard. While accelerating at interstate speeds, it feels like the transmission is slipping. When I shift the vehicle into gear, it makes a loud clicking or knocking sound.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668582June 23, 2025
POWER TRAIN
I was driving pulling off an exit incoming to a highway that needed me to speed up to catch a 65 MPH traffic while I was going 35MPH the car while on D for drive somehow engine REV went up to 5500 RPM no power to drive vehicle slow down to 30MPH and all of the sudden a Violent engine and all the body clunk as if another gear or Park all of the sudden! Tires stop spinning as you can hear tires screeching and this lasted a second and then transmission caught up again and started to accelerate again normally. We were almost hit from a moving truck behind us with 3 small kids in the car! This already happened 3 separate times while we are out traveling out of our hometown. 98 degrees outside dry conditions flat surface in Florida Got it all on Dash Camera on VIDEO and Audio Hope to get this fixed before someone gets KILLED!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666925June 14, 2025
ENGINE, POWER TRAIN
The transmission is consistently hesitating to switch gears, very jerky gear shift, and will sometimes completely fall out of gear. You could so easily lose control if this happened on the highway. Thank goodness we weren’t on a busy street. This isn’t the first reporting according to a simple search online and there should be a recall for safety reasons. This could be life or death for someone driving on the highway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666940June 14, 2025
POWER TRAIN
Transmission hesitated when entering traffic almost causing accident. This is not the first time this has happened. After the first incident I addressed the issue with the service manager. He said it’s common that this model transmission shifts rough, and has some hick ups but, nothing to worry about. It also randomly shifts into neutral randomly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665813June 9, 2025
POWER TRAIN
The contact owns a 2020 Ford Expedition. The contact stated while driving 40 MPH and attempting to overtake a semi-truck, the vehicle shuddered, lost motive power, and made an abnormal clunking and winding sound. The contact stated that the failure had occurred several times while driving and depressing the accelerator pedal and while driving from a complete stop. The check engine warning light was illuminated. The vehicle was taken to the dealer; however, failure could not be duplicated. The contact stated that the failure reoccurred. The vehicle was taken to Krapohl Ford (1415 E Pickard St, Mt Pleasant, MI 48858), where the transmission shifter cables were reset through a computer update; however, the failure persisted. The vehicle was taken back to the dealer, where the cause of the failure could not be determined; however, the dealer recommended the transmission be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664020May 30, 2025
POWER TRAIN
The contact owns a 2020 Ford Expedition. The contact stated while driving at an undisclosed speed, the transmission shifted hard between gears. The contact stated an unknown warning light was illuminated and then went off. In addition, the contact stated that the transmission hesitated while shifting between gear and then unexpectedly downshifted. The contact stated that the transmission seemed not to identify the intended gear. The contact stated that the failure had become persistent. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The vehicle was scheduled for a diagnostic test. The contact stated that when the failure started, the vehicle was taken to the dealer several times, however the failure was not duplicated. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 35,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663196May 27, 2025
POWER TRAIN
i bought a 2020 ford expedition with the 10r80 transmission last july. They have used this transmission since 2017 and continue to put it in vehicles depite having many issues with them. When i was sold this vehicle i was told it had a new transmission just put in it (by another dealership than who i was buying it from) and the carfax (that i still have) shows that the transmission had been replaced. In the last month or so ive been having a hard shift at 4th and 8th gear. i figured it would be covered under warranty so i take it back to the dealership that did the work. They said it didnt have a new transmission only the cdf clutch was replaced. now when i look at the carfax it only shows the tranmission was rebuilt. Thats Fraud. a dealership shouldnt be able to change a entry. i was only 2231 miles over the powertrain warranty and ford will not help. the part that was fixed only had a year warranty and it just a month past a year since it was repaired. Ford knows this tranmission has problems and should be held accountable. i look forward to hearing from someone.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663255May 27, 2025
POWER TRAIN
The contact owns a 2020 Ford Expedition. While the contact's wife was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission unexpectedly downshifted from tenth gear to first gear. The contact's wife drove the vehicle to the shoulder of the road. The contact's wife was almost rear-ended by a tractor trailer. The vehicle was driven to the residence with the hazard lights activated. The contact test drove the vehicle and the failure reoccurred. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. In addition, the contact stated that in 2024, two transmission software updates were performed by the dealer. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition