Ford Expedition Complaints (2021)

242 consumer complaints on file.

#11652842April 4, 2025
POWER TRAIN
The contact owns a 2021 Ford Expedition The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted. The transmission warning light was illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer, where it was diagnosed with transmission failure and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 79,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649660March 21, 2025
POWER TRAIN
The contact owns a 2021 Ford Expedition. The contact stated while driving 10 MPH, the vehicle became stuck in first gear. The driver was able to maneuver the transmission into fourth gear. The contact turned the vehicle on and off, and the transmission was reset. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 20V197000 (Power Train). The vehicle was taken to the local dealer, and was diagnosed with CDF drum failure, and that the transmission needed to be rebuilt or replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic, who determined that the transmission needed to be rebuilt. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 78,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649414March 20, 2025
POWER TRAIN
The transmission has started to delay engagement into drive and reverse which causes the ability for the vehicle to unexpectedly roll in either direction. The vehicle also shifts erratically and in a rough manner while driving causing the driver(s) to either hesitate acceleration and or cause a sense of urgency to stop. It was brought to my attention from repair/transmission shops that this is a common problem with this particular transmission and calls for a new replacement or rebuild. The issue is very noticeable when driving as stated by the driver(s) and auto repair mechanics/employees.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648043March 13, 2025
ENGINE
Coolant leak possibly coming from the thermostat housing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646953March 7, 2025
POWER TRAIN
Power Train went out on our family vehicle at 107k miles. This is a known problem by Ford for this model, and it is a major hazard. It created a dangerous driving situation for our family. The transmission would slip or quickly shift down to lower gears while driving at higher speeds causing the vehicle to malfunction in traffic and creating a very dangerous driving situation for our family. The vehicle is currently at a Ford dealership awaiting repair. Ford is aware there is a safety hazard concerning the transmissions in this model and they need to fix it ASAP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11644511February 24, 2025
VISIBILITY/WIPER
The contact owns a 2021 Ford Expedition. The contact stated while driving 30 MPH during the snow, the driver's side and passenger’s side windshield wipers ceased to work as intended. The vehicle was taken to an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643804February 19, 2025
STRUCTURE:BODY
Door latch mechanism freezes, unable to close/latch door. Ford has a known TSB for this issue, which was recently repaired. Door latch still freezing, so door will not close. Have to drive with bungee cord to hold shut. Totally unsafe for backseat passenger!!!!!’
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643198February 17, 2025
POWER TRAIN
DTC P07F7 - This is the code that the car is showing which is a CDF Drum failed in the transmission. The vehicle was almost hard braking when shifting gears and throwing us towards the dashboard specifically when switching between 9th and 10th gear. It was hard shifting between multiple gears. The vehicle is only 3 years old with 67,000 miles on it and the transmission has failed. There are also multiple reports and a service bulletin on this particular transmission from Ford.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643109February 17, 2025
VISIBILITY/WIPER
The wiper arms keep popping off the motor. We can pop them back on, but they are still popping off.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11642914February 15, 2025
POWER TRAIN
When driving and car down shifts to 4th speed and accelerator is pressed, the car does not accelerate, rpm’s only increase. The car then jars or jerks into gear with a loud sound. Safety risk is that you are driving at high speed and cannot keep car accelerating with other cars around - especially on freeway. 1st occurrence happened at 31000 miles. Now constant repeat at 43000 miles. No warning lights/lamps, etc. Car has only been serviced by Ford. Ford noted this as a software update needed. In researching this, seems to be a common problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11641002February 5, 2025
POWER TRAIN
I was merging on to the interstate and lost all throttle. Gear dropped to first. I had to hurry and pull off of the interstate to avoid having a wreck. I have also had issues with the car clunking into gear when putting car in drive. Car will also slip gears from 2-4 and 7-8th while driving
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11638861January 27, 2025
POWER TRAIN
The contact owns a 2021 Ford Expedition. The contact stated while driving at an undisclosed speed and depressing the accelerator pedal or the brake pedal, the vehicle failed to respond as needed. The power train system message was displayed. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed and the contact was informed that the clutch hub was damaged. The contact was informed that the transmission and the clutch hub needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11638262January 24, 2025
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The contact owns a 2021 Ford Expedition. The contact stated while driving 40 MPH, the driver's side door inadvertently opened. The contact stated that after inspecting the vehicle, the contact became aware that the driver’s side door was not closing properly. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11635283January 10, 2025
POWER TRAIN
The vehicle has a significant delay in changing from park to drive, drive to reverse, and reverse to drive. The vehicle has been brought to FORD on several occasions, each time the shop has informed me that the vehicle is indicating a low voltage for the adaptive learning module. They reset the adaptive learning module and it corrects the issue for a about 6 months and the issue returns worse each time. On the most recent occasion the delay moving from drive to reverse was more than 45 seconds; which resulted in a near crash with a high speed moving vehicle. Had there been a collision the malfunction would have been the primary cause of the crash and a superseding event. I have taken the vehicle back to FORD and there response is now that the vehicle is out of warranty and the only offer was to again reset the adaptive learning module at my cost. The cost is not the issue, the issue is that they are not investigation to determine the cause and only doing temporary corrections that will ultimately, if it has not already, led to serious crashes resulting in injury or death.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634455January 6, 2025
POWER TRAIN
The contact owns a 2021 Ford Expedition. The contact stated that while driving 60 MPH, the vehicle decelerated, hesitated, and shifted out of gear independently. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was referred to the NHTSA Hotline for assistance. The contact related the failure to Technical Service Bulletin: 22-2428 (Harsh/Delayed Engagement And/ Or Harsh/Delayed Shift). The failure mileage was 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633665January 2, 2025
POWER TRAIN
The contact owns a 2021 Ford Expedition. The contact stated that while driving at various speeds on several occasions, the vehicle down shifted inadvertently, and the vehicle lost power. The contact stated that there were no warning lights illuminated during the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633649January 2, 2025
POWER TRAIN
Transmission issues: Sudden loss of power while driving 2021 Expedition on interstate when transmission disengaged at approximately 75 MPH in passing lane. This occurred most recently AFTER transmission was re-built at Ford dealership. Transmission has been having these issues for years and they have gotten worse (more frequent) with time. Last time occurred on Thanksgiving day 2024. Large red wrench indicator warning light appeared on dash advising to consult owner's manual. Small wrench indicator light remained at bottom of screen after the larger one disappeared. Dealership has not been able to reproduce the event which occurred about an hour into the trip on the interstate when proceeding up a slight grade. Vehicle is not safe to drive. Work requires frequent travel on interstate day trips. Loyal to Ford. Love Expeditions. Have owned several. No confidence in this one. Value adversely affected since cannot in good faith sell vehicle without disclosure of transmission issues. No response from Ford to notice letter sent to them after most recent incident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632591December 27, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
The “handless” rear hatch opening activates when not intended. This has caused a concussion to a driver while loading a vehicle. While this is not a “driving” system, it causes injuries to occupants immediately prior to driving. It is entirely possible that a driver could suffer a head injury without knowledge, then begin driving. This causes a dangerous driving environment. In particular the system is supposed to operate when the key is in a persons pocket and the foot is waived in the air by the hitch receiver area. The issues exists because it activates even if an object moves under the vehicle when key is in the correct proximity. This can even pin a driver down with the door over thier back while loading. Again this causes injuries and issues that may not be discovered until driving. In this particular incident the driver was loading the cargo area, when the door activated to close unknown to driver. At the same time the driver was leaning back and standing back up hitting his head on the door while it was closing on him. Approximately 10 to 15 minutes later after finishing loading, the driver drove away (sole occupant). After another 10 to 15 minutes later driver was feeling dizzy and un able to focus. The driver stopped the vehicle and sought medical attention. The driver was diagnosed with a minor concussion. While this had a good result, it could have easily escalated or caused a serious accident. It is recommended that a safety advisory about the potential risks of automatic door opening/closing is released. In addition it is recommended that the manufacturer enable the ability to disable the automatic function in the vehicle system in a manner where it only comes back on after a user turns it on.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11632416December 26, 2024
STRUCTURE:BODY
The right tail lamp on my 2021 Ford Expedition was loose, and the tail lamp completely fell off while I was driving. My safety and the safety of other drivers was put at risk when the tail lamp fell off because my tail lamp was not visible to other drivers. The vehicle was not involved in any accident, and the tail lamp is in perfect condition. My car is at the dealership currently to get it fixed, and the technician stated that the tabs are broken on the backside of the tail lamp so it is not able to lock into place. The tail lamp has to be completely replaced. There were no warning lamps, messages, or any other type of indication that the tail lamp was loose. I believe this was caused by a manufacturer defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630431December 12, 2024
AIR BAGS, SERVICE BRAKES
I was in an accident on December 9 at 2 pm it was slightly wet out & 51 degrees i was making a left turn out of a business went into the middle lane and gave some gas to merge into the lane and the back end of the vehicle locked up and swung into a tail spin to the right as I applied the brakes it locked up worse and the vehicle spun around twice. Went into oncoming traffic and was hit. Had to exite the vehicle on the passenger side because i could not open the drivers door. When the police and tow truck came the both could not believe the airbags did not deploy . The car was found to be totaled by my insurance Co. AAA The fact that not one of the airbags didn’t deploy is very disturbing to me!!! This was my first Ford and dont think i will ever own anther.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition