Ford Expedition Complaints (1999)

946 consumer complaints on file.

#10147955January 17, 2006
VEHICLE SPEED CONTROL:CRUISE CONTROL, ELECTRICAL SYSTEM
DT*: THE CONSUMER STATED THERE WAS A RECALL 05V388000 CONCERNING THE CRUISE CONTROL. THE VEHICLE WAS TAKEN TO A LOCAL SERVICE DEALER FOR REPAIR UNDER THE RECALL. WHEN THE DEALER MADE THE REPAIRS THE 5 AMP FUSE IN ONE OF THE CIRCUITS WAS REPLACED WITH A 15 AMP FUSE WITHOUT THE CONSUMERS KNOWLEDGE OR CONSENT. THE MANUFACTURER WAS CONTACTED AND INDICATED THE DEALER SHOULD NOT HAVE REPLACED THE FUSE WITH A LARGE AMP WHEN COMPLETING THE RECALL WORK. AS RESULT OF A LARGER AMP FUSE BEING INSTALLED IN THE SMALLER CIRCUIT THE ELECTRICAL CIRCUITS WERE MELTED. THE FOUR WHEEL DRIVE WILL NO LONGER DISENGAGE, THE WINDSHIELD WIPERS AND THE FRONT DEFROSTER WILL NOT WORK. THE CONSUMER DISCOVERED THE LARGER FUSE WHEN INSPECTING THE FUSES BECAUSE OF THE OTHER ELECTRICAL PROBLEMS. *JB UPDATED 2/28/2006 - *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148646January 13, 2006
TIRES
1999 FORD EXPEDITION LEFT REAR TIRE BLEW OUT. *TS THE CONSUMER LOST CONTROL OF THE VEHICLE REAR ENDED A TRUCK AND THEN STRUCK A GUARD RAIL. *JB
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10147421January 11, 2006
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
DT*: THE CONTACT STATED THE ENGINE SHUT DOWN WHILE DRIVING AT 50 MPH. THE VEHICLE WAS TAKEN TO A LOCAL DEALERSHIP WHERE THE CAUSE WAS DETERMINED, BUT THE DEALER WAS UNABLE TO MAKE THE NECESSARY REPAIRS. AN INDEPENDENT REPAIR SHOP INSPECTED THE VEHICLE AND DETERMINED THE ENGINE SUFFERED ELECTROLYSIS PROBLEMS. THE ANTIFREEZE LEAKED ONTO THE ENGINE BECAUSE THE COMPARTMENT WAS MADE OF WEAK ALUMINUM. THEREFORE, THE COMPARTMENT COULD NOT SUSTAIN THE FLUID. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148621January 10, 2006
VISIBILITY:REARVIEW MIRRORS/DEVICES
CONSUMER HAD 1999 FORD EXPEDITION SIDE MIRRORS REPLACED DUE TO BUBBLES IN MIRROR. *TS AS A RESULT THE CONSUMER VISIBILITY WAS REDUCED, ESPECIALLY AT NIGHT. THE CONSUMER CONTACTED THE DEALER AND WAS TOLD THAT THE MIRROR WAS NOT COVERED UNDER WARRANTY. THE CONSUMER REPLACED IT AT HIS EXPENSE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147108January 6, 2006
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ENGINE SPARK PLUG BLOW OUT AT 80,000 MILES ON ENGINE. ENGINE HAD 40,000 ON IT FROM NEW AND WAS CONSUMING OIL DUE TO THE RIGHT HEAD LEAKING OIL. FORD REPLACED THE HEAD GASKET. THE GASKET DID NOT SOLVE THE PROBLEM SO A NEW MOTOR WAS INSTALLED. NOW AT 120,000 (80,000 ON THE MOTOR) AFTER THE SPARK PLUGS WERE CHANGED, A PLUG BLEW OUT OF THE HEAD. A HELICOIL WAS INSTALLED AFTER THE PLUG BLOW OUT BUT THAT ALSO FAILED. REBUILT HEAD IS BEING INSTALLED. FEEL THIS IS A FORD PROBLEM ON THIS SPARK PLUG BLOW OUT. THE 5.4L HEAD IS NOT MANUFACTURED TO WITHSTAND THE HORSEPOWER. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147001January 5, 2006
ENGINE AND ENGINE COOLING:ENGINE
DT*: THE CONTACT STATED WHILE DRIVING THERE WAS A LOUD BANG IN THE ENGINE. THE VEHICLE IMMEDIATELY LOST POWER AND WAS UNCONTROLLABLE. THE CONTACT PULLED THE VEHICLE TO THE SIDE OF THE ROAD. IT WAS TOWED TO AN INDEPENDENT REPAIR SHOP AND THE SPARK PLUGS WERE REPLACED. ONE MONTH LATER ANOTHER SPARK PLUG BLEW OUT OF THE ENGINE. THE VEHICLE WAS TAKEN AGAIN TO AN INDEPENDENT REPAIR SHOP WERE THE SPARK PLUGS WERE REPLACED. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147039January 5, 2006
ENGINE AND ENGINE COOLING:ENGINE
MY 99 FORD EXPEDITION'S SPARK PLUG EJECTED FROM THE HEAD. THIS HAS CAUSED EMOTIONAL DISTRESS, NOT BEING ABLE TO GET TO AND FROM WORK AND OTHER PLACES. I HAD IT REPAIRED FOR A PRICE OF $300 DOLLARS. THIS WAS RIDICULOUS, FORD SHOULD PAY ALL EXPENSES. THEN I WAS DRIVING TODAY AND ANOTHER PLUG BLEW. MY TRUCK IS SITTING ON THE SIDE OF THE ROAD RIGHT NOW. THIS IS TERRIBLE! *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146888January 4, 2006
VEHICLE SPEED CONTROL:CRUISE CONTROL
I RECEIVED A RECALL NOTICE (05S28) FROM FORD IN SEPTEMBER OF 2005 STATING THAT THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT CAUSING AN UNDERHOOD FIRE IN MY 1999 EXPEDITION. IT ALSO NOTED THAT THE NEAREST DEALER WILL TEMPORARILY DISCONNECT THE SWITCH UNTIL A PERMANENT REPAIR IS PERFORMED. THE DEALER REFUSES TO DISCONNECT THE SWITCH AND STILL HASN'T RECEIVED THE PARTS TO CORRECT THE PROBLEM. THE DEALERSHIP TOLD ME TO CALL BACK IN FEBRUARY 2006. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146239December 28, 2005
ENGINE AND ENGINE COOLING:ENGINE
1999 FORD EXPEDITION - BLOW SPARK PLUG OUT OF NUMBER 3 CYLINDER. RESULT IS LOSS OF POWER AND VERY POOR DRIVABILITY AT LOW SPEEDS. ALSO, GAS SMELL FROM LEADING INJECTOR IN NOW OPEN CYLINDER. FORTUNATELY I WAS NOT TOWING WHEN THE PLUG BLEW, OR THE LOSS OF POWER COULD HAVE RESULTED IN AN UNSAFE SITUATION. FORD DEALER RECOMMENDS REPLACING THE CYL. HEAD ($3,000), DOESN'T ACKNOWLEDGE ANY DEFECT THAT FORD HAS AUTHORIZED. SEVERAL OTHER MECHANICS INDICATE THIS IS A COMMON PROBLEM ON THIS ENGINE, DEALS WITH INSUFFICIENT NUMBER OF THREADS TO HOLD THE PLUG IN THE ALUMINUM HEAD. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146287December 28, 2005
ENGINE AND ENGINE COOLING:ENGINE
PULLING OUT FROM A STOP SIGN IN NEIGHBORHOOD WHEN SUDDENLY SMOKE SMELL AND LOUD RHYTHMIC BANGING FROM UNDER HOOD. I IMMEDIATELY PULLED OVER AND HAD THE VEHICLE TOWED TO SHOP. THEY DISCOVERED A SPARK PLUG HAD BLOWN THROUGH THE HEAD, REQUIRING A HEAD REPLACEMENT. SUBSEQUENTLY I DISCOVERED THIS IS A PROBLEM WITH FORD VEHICLES WITH THE TRITON ENGINE-DESIGN DEFECT IN THAT THEIR ARE ONLY 5-6 THREADS HOLDING SPARK PLUGS IN LEAVING THEM SUSCEPTIBLE TO THIS TYPE OF FAILURE DURING NORMAL OPERATION. FORD WOULD NOT ASSIST ME WITH REPAIRS STATING THERE WAS NO RECALL DEALING WITH THIS ISSUE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146295December 28, 2005
ELECTRICAL SYSTEM, VISIBILITY:REAR WINDOW WIPER/WASHER, SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM, SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
MAJOR ELECTRICAL PROBLEMS: AIR SUSPENSION STOP WORKING; INTERIOR AND EXTERIOR LAMPS CONTINUALLY CLICK ON AND OFF; REAR WINDSHIELD WIPERS STOP WORKING. ABS WARNING CLICKS ON AN OFF, WHEN OFF BRAKES TEND TO LOCK DURING BRAKING. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146094December 26, 2005
SUSPENSION:FRONT:STABILIZER BAR
I ALMOST FLIPPED MY WIFE'S 1999 FORD EXPEDITION ON CHRISTMAS EVENING (YESTERDAY) WHEN BOTH STABILIZER BAR LINKS SHEARED OFF. MY FAMILY, INCLUDING FOUR CHILDREN, WERE IN THE CAR. WE WERE PROCEEDING ON A RURAL ROAD AT THE POSTED SPEED LIMIT WHEN THE HANDLING WENT OUT AND THE VEHICLE STARTED DRIFTING ALL OVER THE ROAD. ANYTHING OVER 40 MPH BECAME UNSAFE AROUND TURNS. IT COST ME $84 TO REPLACE THE PARTS TODAY (SELF-INSTALLED). IT COULD HAVE KILLED MY FAMILY. I WANT FORD TO REIMBURSE ME FOR THE PARTS AND I WANT THEM TO INVESTIGATE WHETHER A RECALL WOULD BE PRUDENT. I OWNED TWO 1995 EXPLORERS AND BOTH WERE RECALLED FOR THIS DEFECT (WHICH IS THE ONLY REASON I KNEW TO LOOK FOR IT). I AM A LICENSED ATTORNEY. NOTICE OF A DEFECT GIVES RISE TO NEGLIGENCE. NOT ONLY DOES A QUALITY AND SAFETY ISSUE LIKE THIS ONE DAMAGE FORD'S REPUTATION, ECONOMICALLY IT LESS EXPENSIVE TO REPLACE THE PARTS THAN TO WAIT FOR THE FATALITIES TO MATERIALIZE AS THESE VEHICLES AGE. I WANT FORD TO REIMBURSE ME FOR THE PARTS AND INVESTIGATE THE ISSUE OR I WILL NEVER BUY ANOTHER FORD PRODUCT AGAIN. FORD, DO THE RIGHT THING HERE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144943December 12, 2005
ELECTRICAL SYSTEM
IT STARTED A YEAR AND A HALF AGO. THE WINDSHIELD WIPERS WOULD COME ON FOR NO REASON. IT DIDN'T HAPPEN VERY OFTEN AT THE TIME I TOOK IT IN TO EVALUATE THE PROBLEM. THE DEALER TOLD ME THEY COULD NOT FIX A PROBLEM THEY DIDN'T SEE. SLOWLY THE PROBLEM GOT WORST, ESPECIALLY IN WET WEATHER. ABOUT EIGHT MONTHS AGO, THE HEADLIGHTS WOULD GO OUT IF THE STEERING COLUMN WAS LOWERED. I CAN NO LONGER RAISE OR LOWER THE COLUMN ANYMORE FOR FEAR THE WIPERS, LOCKS AND HEADLAMPS WILL NOT WORK. AT TIMES, THE LOCKS TO THE BACK SEAT WOULD NOT RESPOND TO THE POWER LOCK BUTTONS. THE REAR WIPER DOES NOT WORK ANYMORE, YOU CAN HEAR THE MOTOR RUN AT TIMES, BUT NO MOVEMENT. THE ODOMETER BLINKS ON AND OFF AT TIMES. THERE HAVE BEEN TIMES IT DOESN'T COME ON AT ALL. THAT NORMALLY HAPPENS WHEN I'M ON THE ROAD FOR A LONG PERIOD OF TIME. WITH ALL OF THAT GOING ON, THE WORST THING IS TO DRIVE THE CAR IN THE RAIN AND SNOW AND NOT KNOW IF THE WIPERS WILL WORK AT ALL. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144623December 7, 2005
ELECTRICAL SYSTEM
MY 1999 FORD EXPEDITION HAS A RECURRING PROBLEM WITH A SUPPOSES SAFETY FEATURE. THE "DOOR AJAR" WARNING LIGHT COMES ON EVEN WHEN THERE IS NO DOOR OPEN. PART OF THIS SYSTEM TURNS ON THE DOME LIGHT AT SPEEDS BETWEEN 5 AND 18 MPH. THIS LIGHT MAKES IT DIFFICULT TO SEE OUT THE WINDOWS. IMAGINE YOURSELF BACKING OUT OF AN UNLIT DRIVEWAY AT NIGHT AND NOT BEING ABLE TO SEE IF THERE IS A CHILD APPROACHING THE REAR OF YOUR CAR. THERE IS NO WAY TO TURN OFF OR OVER-RIDE THE DOME LIGHT SHORT OF REMOVING THE BULBS. FORD TRIED TO FIX THE PROBLEM ONCE AND IT WORKED PROPERLY FOR A WHILE, BUT THE PROBLEM RETURNED. IT IS FRIGHTENING WHEN YOU HAVE YOUR SIGHT IMPAIRED. I WOULD RATHER HAVE THE DOME LIGHT WARNING SYSTEM DISABLED THAT HAVE IT MALFUNCTION. THE ODDS OF AN INCIDENT HAPPENING DUE TO IMPAIRED VISION ARE SURELY GREATER THAN OF AN OPEN DOOR NOT BEING NOTICED AND SUBSEQUENTLY CAUSING AN INCIDENT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144456December 5, 2005
STEERING:LINKAGES:TIE ROD ASSEMBLY
WHEN TURNING INTO PARKING LOT ENTRANCE AFTER COMPLETE STOP, THE STEERING SUDDENLY BECAME LOOSE AND I FELT A VIBRATION AND HEARD A SKIDDING NOISE FROM ONE TIRE. THE STEERING WAS LOOSE BUT RESPONSIVE WHILE I TURNED INTO A PARKING SPOT. AFTER THAT, THE RIGHT FRONT WHEEL WOULD NOT TURN WITH THE STEERING WHEEL. THE BALL JOINT ON THE PASSENGER SIDE TIE ROD HAD SEPARATED. I HAD THE CAR TOWED TO A LOCAL FORD DEALERSHIP WHERE THE TIE ROD WAS REPLACED. THE DEALER DISCARDED THE OLD PARTS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144223December 2, 2005
VEHICLE SPEED CONTROL:CRUISE CONTROL
DT: THE CONTACT STATES THERE I NHTSA S RECALL CAMPAIGN 05V388000 CONCERNING CRUISE CONTROL. THE PARTS NEEDED TO REPAIR THE VEHICLE ARE NOT AVAILABLE AT THE LOCAL DEALERSHIP. THE CONTACT SPOKE TO THE MANUFACTURER, WHO HAS CONFIRMED THAT THE PARTS WERE NOT AVAILABLE. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144341December 2, 2005
ENGINE AND ENGINE COOLING:ENGINE
DRIVING DOWN THE INTERSTATE HIGHWAY HEARD A LOUD POP, THEN A CONTINIOUS HUFFING SOUND FROM THE ENGINE COMPARTMENT ACCOMPANIED BY A SEVERE VIBRATION. PULLED VEHICLE INTO THE NEAREST REST STOP AND CHECKED ENGINE, FOUND THE SECOND SPARK PLUG ON THE RIGHT BANK (PASSENGER SIDE) HAD FORCEABILY EJECTED TAKING THE THREADS WITH IT. THE ENGINE IS A TRITON 5.4L. THE ENGINE WAS REPAIRED AT A DEALER (FORD COUNTRY IN HENDERSON NV) BY REPLACEMENT OF THE HEAD. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10143973November 29, 2005
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
SEVERAL TIMES THIS HAPPENED. AFTER RAIN OR SNOW THE ELECTRONICS IN MY 1999 EXPEDITION GOES CRAZY. SUCH AS VEHICLES FAN RUNS AFTER TRUCK IS TURNED OFF, WHEN IN DRIVE RADIO GOES OUT, BEEPING NOISES ETC ETC. THIS IS KNOWN TO BE CAUSED BY A LEAK IN THE VEHICLES WINDSHIELD WHICH IS UNDETECTABLE BY THE OWNER. WATER LEAKS BEHIND THE FUSE PANEL AND THE GEM MODULE AND CAUSES ELECTRICAL HAVOC. CAR WILL EVEN TRY STARTING ON ITS OWN W/O KEYS IN IT. FORD HAS KNOWN ABOUT THIS WINDSHIELD DEFECT AND WILL DO NOTHING TO RECTIFY IT. THIS STARTED THIS YEAR SEVERAL TIMES. THE DEALER IS REPLACING THE WINDSHIELD BECAUSE TO RESEAL IT HAS TO BE REMOVED AND IN THE PROCESS THEY CRACK. THE FUSE BOX AND GEM MODULE ALSO HAS TO BE REPLACED DUE TO CORROSION OVER TIME CAUSED BY THE UNKNOWN LEAK. THE WATER LEAKS DOWN THE FRONT PILLAR AND THEN BEHIND THE DASHBOARD. ALL THE WHILE THE OWNER IS UNAWARE OF THIS HAPPENING OVER TIME. FORD HAS KNOWN ABOUT THE DEFECTIVE SEAL ON THE WINDSHIELDS OF SEVERAL YEAR MODELS OF EXPEDITIONS. THIS IS ALSO A DEFINITE FIRE HAZARD AND A DEFINITE DANGER ESP. THOSE WHO PARK IN THERE ATTACHED GARAGES. REPAIRS COST THE OWNERS BETWEEN $600.00 TO WELL OVER $1000.00. THIS ISN'T FAIR WHEN A DEFECT LIKE THIS IS COMMON KNOWLEDGE TO ALL DEALERS AND OWNERS OF THESE VEHICLES. MY VEHICLE IS A TOP OF THE LINE EDDIE BAUER MODEL AND THE PRICE NEW WAS IN THE $40,000 RANGE. THE NHTSA SHOULD FULLY INVESTIGATE THIS AND DEMAND A RECALL AND REIMBURSEMENT TO THOSE WHO PAID DEARLY FOR THIS DEFECT THAT CAME STRAIGHT FROM THE ASSEMBLY LINE TO US. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10143773November 28, 2005
VEHICLE SPEED CONTROL, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
DT: THE CONTACT STATED WHILE DRIVING VEHICLE EXPERIENCED SUDDEN ACCELERATION. WHEN DEPRESSING THE BRAKES THE RMPS REVVED VERY HIGH. WHEN LIFTING FOOT OFF THE BRAKES THE VEHICLE ACCELERATED. HE EVENTUALLY DEPRESSED THE BRAKES HARD ENOUGH SO THAT THE VEHICLE STOPPED. THE CRUISE CONTROL WAS NOT IN USE. HE TOOK HIS VEHICLE TO THE DEALER. THEY TOLD HIM THAT THE PCV HAD A LEAK IN THE VACUUM SYSTEM. THE VEHICLE IS NOW BEING REPAIRED.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10143840November 28, 2005
PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE
EMERGENCY BRAKE CABLE SNAPPED. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition