Ford · Model Report
Showing safety data for the 1994 model year only.
Cummings Mobility Conversion & Supply, Inc. (Cummings) is recalling various model year 1994-2011 Ford and Chevrolet vans equipped with Braun NCL-2, and NVL-2 wheel chair lifts manufactured November 20, 2006, through September 10, 2010. Over time, and with frequent use, the roll stop latches on the outer barrier of the lifts in these vans may become bent or misaligned.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
THESE VEHICLES DO NOT COMPLY WITH FMVSS 105, "HYDRAULIC BRAKE SYSTEMS." THE PARKING BRAKE APPLICATION FORCE FOR A FOOT OPERATED CONTROL SYSTEM SHOULD NOT EXCEED 125 POUNDS TO HOLD THE VEHICLE ON A 30% GRADE. INTERFERENCE BETWEEN THE PARKING BRAKE PEDAL AND A WIRE HARNESS MAY INCREASE THE NEEDED PEDAL FORCE TO GREATER THAN 125 POUNDS TO SET THE PARKING BRAKE TO HOLD THE VEHICLE ON THE 30% GRADE.
DRIVING ON INTERSTATE AT 70 MPH WITH SPEED CONTROL ENGAGED. TRUCK AHEAD OF ME APPLIED BRAKES. I APPLIED MY BRAKES. SPEED CONTROL DID NOT DISENGAGE. BRAKE FROZE IN 'HIGH' ('OFF') POSITION WITHOUT ANY BRAKE APPLICATION. PASSING GEAR WAS ENGAGED AND VEHICLE SHOT FORWARD. FOOT CONTACT WITH BRAKE OR ACCELERATOR DID NOT AFFECT ACCELERATION OR SHUT OFF SPEED CONTROL. I MANUALLY TURNED OFF THE SPEED CONTROL NARROWLY AVOIDING A COLLISION. TESTED THE SYSTEM ON AN OPEN STRETCH OF INTERSTATE LATER IN THE DAY AND THE SITUATION DUPLICATED ITSELF 4 TIMES. VEHICLE IS AT DEALERS NOW FOR INSPECTION: OLATHE FORD, OLATHE KS
No injuries · No fire · No crash
SUDDEN BRAKE HOSE FAILURE. 1994 FORD DIESEL E350 W/4-WHEEL ABS. BRAKE HOSE FAILURE DUE TO RUSTED PORTION OF THE HOSE ASSEMBLY . THE AREA THAT RUSTED AWAY IS THE CRIMPED CONNECTION WHICH JOINS THE RUBBER HOSE TO THE STEEL FITTING AT THE CALIPER END OF THE HOSE ASSEMBLY. THIS RUST IS NOT VISIBLE WHILE DOING A ROUTINE INSPECTION OF THE BRAKE SYSTEM BECAUSE IT IS COVERED BY A RUBBER SLEEVE. APPARENTLY WATER/MOISTURE IS COLLECTING UNDER THIS RUBBER SLEEVE AND CORRODING THE STEEL CRIMPED AREA OF THE FITTING UNTIL THERE IS NO MORE OF A SECURE CONNECTION OF THE RUBBER HOSE TO THE STEEL , THEN WHEN THE BRAKES ARE APPLIED AND THE FLUID IS PRESSURIZED IN THE BRAKE SYSTEM THE RUBBER HOSE WILL BLOW AWAY FROM THE STEEL FITTING. (IDENTICAL FAILURE IN NHTSA DATABASE MAY 06, 2002 - TOMS RIVER, NJ). *TR
No injuries · No fire · No crash
WHEN I AM DRIVING MY 1994 E350 DIESEL TRUCK, THERE WILL BE A SUDDEN LOSS OF POWER STEERING AND BRAKES RESULTING IN A LOSS OF ABILITY TO STOP THE TRUCK. FORTUNATELY, I WAS TRAVELING AT A SLOW SPEED WITH PLENTY OF CLEARANCE AHEAD OF ME AND WAS ABLE TO PULL THE TRUCK OFF THE ROAD AND HAVE IT TOWED IN TO A MECHANIC SHOP. SO FAR THE SERPENTINE BELT HAS BEEN REPLACED, A NEW TENSIONER INSTALLED, AND A NEW IDLER PUT IN. UNFORTUNATELY, THE PROBLEM PERSISTS AND IS VERY DANGEROUS. I SEE THAT A RECALL WAS ISSUED # 9610030000 BY NHTSA FOR 1994 FORD ECONOLINE E350 TRUCKS WITH SERPENTINE BELT PROBLEMS AND THAT THE FORD DEALERS HAVE AGREED TO REMEDY THE PROBLEM. WHEN I CALL FORD, THEY SAY THAT MY VIN# IS NOT AMONG THOSE THAT WERE RECALLED. THIS IS THE 3RD TIME I HAVE LOST POWER STEERING AND BRAKES DUE TO A SERPENTINE BELT MALFUNCTION. I BELIEVE THAT MORE VEHICLES MANUFACTURED THAT YEAR SHOULD BE INCLUDED IN THE RECALL. *TR
No injuries · No fire · No crash
WAS DRIVING DOWN HIGHWAY WHEN SUDDENLY THERE WAS A LOUD AND NOTICEABLE VIBRATION IN VAN. TOOK VAN TO SEARS SERVICE CENTER IN LAS CRUCES. MECHANIC ADVISED THAT ONE OF THE TIRES WAS COMING APART FROM INSIDE OUT. TIRE HAD A VERY NOTICEABLE WEAVE PATTERN. WAS ABLE TO DRIVE. *TR
No injuries · No fire · No crash
1994 E350 CAUGHT ON FIRE. *TS A MECHANIC TOLD THE CONSUMER THE TRUCK HAD A BAD WATER PUMP AND THAT WAS THE CAUSE OF THE FIRE. *JB