Ford E-150 Complaints (2004)

33 consumer complaints on file.

#11675913July 24, 2025
POWER TRAIN
The contact owns a 2004 Ford F-150. The contact stated that while parked when the vehicle suddenly rolled backwards downhill the contact's son attempted to get into the vehicle to make it stop. The trailer's jackknife stopped the vehicle from going onto the road. The contact manually moved the vehicle back into their garage. The contact stated their son did receive injuries to their head, left or right leg (the contact was unsure of the exact leg), and their left or right arm (the contact was unsure of the exact arm). Medical attention was needed. The dealer was not contacted. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was 74,000.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10863242May 4, 2016
POWER TRAIN
VIBERATION IN REAR AND CLUNKING NOISR IN REAR WHEN STOPPING AT LIGHT THEN TAKING OF WHILE MAKING A RIGHT TURN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10749051August 17, 2015
ENGINE
2004 FORD 4.6L ENGINE: #2 SPARK PLUG EJECTED FROM CYLINDER HEAD. ~$700 TO REPAIR!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10724084June 8, 2015
EXTERIOR LIGHTING
THERE ARE TONS OF DRIVERS ON PUBLIC ROADS USING OFF ROAD LED LIGHT BARS AND USING AMPLIFIED HID HEADLIGHTS. THEY ARE SO BRIGHT I HAVE TO BLOCK THE LIGHT WITH MY HANDS WHEN THEY DRIVE BY. I KNOW THIS IS ILLEGAL. IT IS TERRIBLY UNSAFE. WHY ARE THERE NOT LAWS BEING ENFORCED TO PREVENT THEIR USE ON THE STREET?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10712952April 26, 2015
POWER TRAIN
AT THE POINT I REACH 40 MPH TRUCK SHIFTS TO NEUTRAL, HAVE TO PULL OVER SAFELY AND TAKE TRUCK OUT OF OVERDRIVE TO GET HOME. VERY DANGEROUS WHEN TRAVELING AT THAT RATE OF SPEED. DID SOME OF MY OWN INVESTIGATING AND FOUND MANY WEBSITE HAVE ANGRY PEOPLE WHO ALSO OWN SAME VEHICLES WITH VERY LOW MILEAGE. I SAW THE RANGE OF MILES BETWEEN 44,000 MILES TO 150,000 MILES. PLEASE REFER TO WWW.CARCOMPLAINTS.COM JUST TO START WITH, THERE ARE MANY OTHER WEBSITES FOR THIS MODEL YOU CAN SEE. PLEASE HELP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10579555April 14, 2014
SUSPENSION
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE LOWER BALL JOINTS WERE CAUSING PREMATURE WEARING OF THE TIRES. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT END SPRINGS WERE COMPLETELY FRACTURED. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE MANUFACTURER STATED THAT THERE WERE NO ACTIVE RECALLS REGARDING THE FAILURE AND DECLINED TO PROVIDE A REMEDY TO RESOLVE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 93,000. UPDATED 05/05/14*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10567423March 5, 2014
VISIBILITY/WIPER
TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THE FRONT PASSENGER'S SIDE WINDOW INDEPENDENTLY OPENED. THE FAILURE RECURRED SEVERAL MONTHS LATER ON THE REAR PASSENGER WINDOW. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT BOTH WINDOW REGULATOR ASSEMBLIES WOULD NEED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10542912September 10, 2013
ENGINE
TL* THE CONTACT OWNS A 2004 FORD E-150. THE CONTACT STATED THAT A PRIVATE MECHANIC ATTEMPTED TO REMOVE THE SPARK PLUGS BUT THEY WERE FUSED TO THE ENGINE. THE VEHICLE WAS EVENTUALLY REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 118,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10526410July 23, 2013
POWER TRAIN
TODAY WAS DRIVING NORMALLY ON THE SIDE ROAD NOT TOWING & IN OVERDRIVE WHEN AROUND 40MPH THE OVERDRIVE DISENGAGED & STARTS REVVING LIKE IT'S IN NEUTRAL. I PULL OVER & PUT IT INTO PARK & THEN BACK INTO OVERDRIVE & START DRIVING ONCE AGAIN & SAME THING HAPPENED THREE TIMES. LUCKILY THERE WAS A SERVICE SHOP CLOSE. I TOOK THE TRUCK IN & THEY SAID TAKE IT TO A TRANSMISSION SHOP. HE ALSO SAID IT WAS FINE TO TAKE IT OUT OF OVERDRIVE & THAT WOULDN'T CAUSE IT TO DO THAT. SO, I TOOK IT OUT OF OVERDRIVE & IT DIDN'T MISS A BEAT. AFTER READING THE REVIEWS IT SEEMS TO BE AN ISSUE WITH THE OVERDRIVE SERVO RETAINING CLIP BREAKING. THIS IS BY FAR A MAJOR PROBLEM FORD NEEDS TO LOOK INTO THAT COULD POTENTIALLY PUT LIVES AT RISK. IF IT'S A BAD PART WHY NOT FIX THE PROBLEM IF THERE ARE HUNDREDS OF REPORTS ON THIS SAME EXACT ISSUE? I'VE BEEN A FORD OWNER ALL MY LIFE & AM TRULY SADDENED THAT THIS COULD POSSIBLY BE MY LAST FORD I EVER BUY AGAIN. I'M HOLDING FORD ACCOUNTABLE ON THIS & EVERYONE ELSE THAT HAS THE SAME ISSUE SHOULD DO THE SAME. IT'S A $2.50 PART, THAT'S ALL. & WHEN YOU BRING IT INTO FORD OR ANY OTHER TRANSMISSION SHOP THEY WANT TO DO A WHOLE REBUILD WHICH WILL COST THOUSANDS. WE GO BY THE SAYING BUILT IN AMERICA FOR A REASON & THAT'S NOT USING CRAP PARTS. BUILD IT RIGHT THE FIRST TIME & HAVE NO PROBLEMS. IF YOU START THROWING PARTS & BUBBLE GUMMING IT TO DEATH, THIS IS WHAT HAPPENS. FIX IT FORD! THERE ARE ENOUGH COMPLAINTS ON THIS ALREADY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10390009March 13, 2011
SERVICE BRAKES, HYDRAULIC
DURING THE WINTER MONTHS OUR 2004, FORD, E150, VAN HAS HAD OCCASIONAL YET COMPLETE BRAKE FAILURE SEVERAL TIMES. TYPICALLY, IT HAS HAPPENED WHEN IT WAS VERY COLD -10F AND TYPICALLY SLOWER SPEEDS 10-15MPH BUT TODAY IT WAS 30 F AND SPEEDS WERE 45-50 MPH AS WE WERE COMING DOWN A MOUNTAIN PASS IN COLORADO. WE ALMOST REAR ENDED A SEMI AND ALMOST TOOK ANOTHER CAR HEAD ON BUT THEY HAD MOVED INTO THE FAR LANE. BEFORE REACHING THE BRAKE FAILURE RUN OFF WE WERE ABLE TO DOWN SHIFT AND EVENTUALLY THE BRAKES CAME BACK TO COMPLETE WORKING ORDER. THE VAN HAS BEEN BROUGHT IN SEVERAL TIMES TO FORD DEALERSHIP AND EACH TIME SAME ANSWER, WE CAN'T REPRODUCE THE PROBLEM SO THEY HAVEN'T DONE ANYTHING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10342014July 8, 2010
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
TL*THE CONTACT OWNS A 2004 FORD E-150. WHILE DRIVING 20 MPH THE CONTACT NOTICED THAT THE REAR PASSENGER DOOR HAD SUDDENLY OPENED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE DOOR HINGES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 130000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10327234April 23, 2010
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
MY 2004 F-150 HAS A WINDOW REGULATOR GO OUT FOR THE SECOND TIME THIS IS A REAL ISSUE IT IS A HAZARD TO MY CHILDREN AND A REAL BIG COST TO ME BEING 300 DOLLAR BOTH TIMES I HAD TO REPLACE IT NEED TO BE RECALLED WHAT A BIG DISAPPOINTMENT CAN YOU HELP ME IN THIS MATTER THANK YOU. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10292850November 18, 2009
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
DRIVING DOWN INTERSTATE IN 2004 FORD F150 XLT WITH APPROX. 70K MILES AND INADVERTENTLY LOWERED REAR WINDOW. WHEN I WENT TO CLOSE THE WINDOW, I HEARD A LOUD CRACK AND REALIZED THAT THE WINDOW WAS NOT GOING BACK UP. AFTER PULLING OFF ONTO THE SHOULDER TO INSPECT WHAT HAD OCCURRED, I SAW THAT MY REAR WINDOW HAD DROPPED INTO THE DOOR. LUCKILY IT WAS NOT RAINING THAT DAY OR I WOULD HAVE HAD A BACK SEAT FULL OF WATER. I TOOK IT TO A LOCAL MECHANIC WHO SAID THAT FORD'S POWER WINDOW BRACKET REGULATOR, WHICH WAS CRACKED, IS ONE PIECE AND REQUIRED REPLACEMENT BY TAKING APART THE DOOR. $275 WAS SPENT TO FIX THE REAR WINDOW. I HAVE SEEN NUMEROUS COMPLAINTS REGARDING FORD'S WINDOWS. RIGHT NOW I CONSIDER MYSELF LUCKY THAT IT HAS ONLY HAPPEN TO ONE WINDOW, BUT I WON'T BE SURPRISED IF IT HAPPENS AGAIN SOON TO ANOTHER WINDOW SINCE IT APPEARS OTHERS HAVE HAD TWO OR THREE WINDOWS WITH THIS PROBLEM. IT APPEARS TO BE A MAJOR DEFECT THAT SHOULD BE RECALLED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10252853December 26, 2008
SERVICE BRAKES, HYDRAULIC
REPEATED VEHICLE BRAKE FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10228203May 19, 2008
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2004 FORD E150. THE VEHICLE SPEED CONTROL SWITCH WAS DISCONNECTED APPROXIMATELY 6-8 MONTHS AGO. THE CONTACT SPOKE WITH FORD A COUPLE OF WEEKS AGO AND WAS INFORMED THAT THE PART FOR THE REPAIR WOULD NOT BE AVAILABLE FOR ANOTHER FOUR MONTHS. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 106,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10214091January 7, 2008
SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2004 FORD E150. THE CONTACT STATED THAT THE BRAKES WERE INOPERABLE . THE DEALER WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE AND AS OF SPRADLEY BARR FORD JANUARY 7, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE CURRENT MILEAGE WAS 57,650 AND FAILURE MILEAGE WAS 18,000. UPDATED 02-14-08 *BF THE CONSUMER STATED ONCE THE VEHICLE IS DRIVEN FOR 15 MINS. AND THEN PARKED. THE CONSUMER STATED ONCE DRIVING AGAIN BRAKES BECOME NON EXISTENCE. UPDATED 02/14/08 *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10213172December 29, 2007
SEAT BELTS:FRONT:WARNING LIGHT/DEVICES, SEAT BELTS
FOR THE LAST 3 MONTHS, MY SEAT BELT WARNING BEEP HAS BEEN ON WHETHER I HAVE MY SEAT BELT ON OR OFF. THE DEALER SHIP WHERE I BOUGHT THIS VAN, WHICH IS BILL COLLINS FORD, HAS NOT BEEN ABLE TO HELP WITH THIS PROBLEM. ALSO MY DVD PLAYER STOPPED WORKING AND THE 3 ROW SEAT BELT STRAP HAS BROKE OFF. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10212965December 27, 2007
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2004 FORD ECONOLINE E150. HE RECEIVED A SAFETY RECALL NOTIFICATION LETTER IN AUGUST 2007 ON THE FORD VEHICLE SPEED CONTROL. THE INFORMATION PROVIDED IN THE LETTER IS FRAUDULENT AND MISLEADING AND THE DEALER LEAD HIM TO BELIEVE THAT A REPAIR WAS GOING TO BE MADE DURING HIS APPOINTMENT. THE CONTACT WAS LATER INFORMED AFTER THE SWITCH WAS DISCONNECTED THAT THE PART WAS NOT AVAILABLE. HE HAS CALLED FORD EVERY MONTH SINCE RECEIVING THE NOTIFICATION IN AUGUST AND EVERY MONTH HE HAS BEEN TOLD THAT THE PARTS WOULD BE AVAILABLE THE FOLLOWING MONTH. HE HAS ALSO TRIED MORE THAN ONE FORD DEALERSHIP AND HE RECEIVED THE SAME RESPONSE. IF HE CANNOT HAVE HIS CAR REPAIRED THAT HE WOULD LIKE TO NEGOTIATE A REFUND. THERE ARE NO FAILURES AT THIS TIME. THE CURRENT MILEAGE WAS 48,000. UPDATED 01/17/08 *BF UPDATED 01/17/08 *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10189892May 5, 2007
SERVICE BRAKES, HYDRAULIC
BOLTS FALLING OFF OF BRAKES THAT HOLD CALIPER ON. I HAVE A TOTAL OF 12 2004 FORD E-150 AND 1 2004 FORD EXPEDITION. 3 OF MY E-250'S AND THE EXPEDITION HAS ALL HAD THIS HAPPEN TO THEM. WHAT HAPPENS IS THAT IT SOUNDS LIKE THE BRAKE PADS ARE WORN DOWN TO METAL ON METAL, WHEN BRAKES WERE CHECKED FOR THE PROBLEM, THE BOLT HAD COME LOOSE AND WAS CAUSING THE CALIPER TO RUB AGAINST THE RIM. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10183001February 20, 2007
WHEELS:LUGS/NUTS/BOLTS/STUDS
I WAS DRIVING DOWN INTERSTATE 91 IN MASS. DOING 65 MILES PER HOUR AND EVERYTHING WAS FINE UNTIL I FELT A SLIGHT VIBRATION AND WITH NO WARNING MY REAR RIGHT WHEEL JUST SNAPPED OFF. I WAS LUCKY TO BE ABLE TO STOP THE VEHICLE AND KEEP IT FROM ROLLING OVER OR CREATING A PILE UP OF TRAFFIC. WHEN I HAD GOTTEN OUT TO LOOK I FOUND THAT ALL 5 LUGS WERE SNAPPED OFF AND BROKEN. THERE HAS TO BE SOME SORT OF DEFECT WITH THESE BOLTS. MY FEAR IS THAT SOMEONE ELSE MAY GET KILLED. NOW I AM IN A PROCESS OF TRYING TO HAVE IT REPAIRED AND EVERYONE INCLUDING FORD IS PASSING THE BLAME ON SOMEONE ELSE. PLEASE HELP ME. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford E-150