Ford Bronco Sport Service Bulletins (2022)
150 manufacturer communications on file.
- April 4, 2023•Document ID: 10235153Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- SSM 51536
- Date Added:
- May 4, 2023
- Manufacturer:
- FORD
SummaryFor 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
Associated Products (47)2023 Ford Bronco2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Maverick2023 Ford Mustang2023 Ford Ranger2023 Ford Transit Connect2023 Lincoln Aviator2023 Lincoln Corsair2023 Lincoln Navigator2022 Ford Bronco2022 Ford Bronco Sport2022 Ford Edge2022 Ford Escape2022 Ford Expedition2022 Ford Explorer+ 27 moreAssociated Documents - April 4, 2023•Document ID: 10234133Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
- Mfr Comm. #:
- SSM 51537
- Date Added:
- May 4, 2023
- Manufacturer:
- FORD
SummarySome 2021-2023 Bronco Sport vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P025A, P025B, P00C6, P008A, P0627 and/or U0109 stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness, connector pin push-outs or loose/corroded grounds to the fuel pump control module (FPCM) connector, PCM connector and/or battery junction box connector. Inspect the following connectors for 1.5L and 2.0L engines: C1551B, C1035A, C110, C401, C4033, C4330. Verify the connections are fully seated, without damage and/or pushed out pins/terminals prior to performing Workshop Manual (WSM) diagnostics or replacing any components. Inspect G404 and verify it's clean and secure. If any connector damage is found, repair as necessary. Refer to Wiring Diagram, Cell 005.
Associated Products (3)Associated Documents - March 17, 2023•Document ID: 10233742Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 51459
- Date Added:
- April 5, 2023
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Escape/Corsair, 2021-2022 Bronco Sport, and 2022 Maverick vehicles built on or before 23-Mar-2022 may exhibit a hard, stiff, and/or difficult to turn condition due to a lack of power steering assist during engine start-up with U3000 diagnostic trouble codes (DTCs) stored in the PSCM. Using the latest version of Ford Diagnosis and Repair System (FDRS) tool, select and run the PSCM - Reset the Power Steering Control Module (PSCM) application. After PSCM reset, perform an ignition cycle. Update the PSCM to the latest software level using FDRS tool. If the U3000 DTC returns, continue with diagnostics and repair direction using Workshop Manual (WSM), Section 211-02 > Power Steering > Diagnosis and Testing. For claiming, use causal part 3C529 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (7)Associated Documents - March 14, 2023•Document ID: 10233848Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 22N18
- Date Added:
- April 6, 2023
- Manufacturer:
- FORD
SummaryCertain 2021-2023 Model Year Bronco Sport and 2020-2022 Model Year Escape Vehicles with a 3-cylinder 1.5L Engine Replacement of High-Pressure Fuel Injectors
Associated Products (5)Associated Documents - March 14, 2023•Document ID: 10233713Service Bulletin/Repair InstructionsVEHICLE SPEED CONTROL:CRUISE CONTROL; FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
- Mfr Comm. #:
- SSM 51437
- Date Added:
- April 5, 2023
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Escape/Corsair, 2021-2022 Bronco Sport, 2022 Maverick vehicles built on or before 23-Mar-2022 may exhibit driver assistance warning messages displayed in the instrument panel cluster (IPC): Pre-collision Assist Not Available, Cruise Control Not Available, Collision Warning Malfunction and/or Adaptive Cruise Control Malfunction. Diagnostic trouble code (DTC) U0415:00 may also be stored in the power steering control module (PSCM), DTC C0051:67 stored in the anti-lock brake system (ABS) module and DTC U0418:86 stored in the image processing module A (IPMA). This may be due to the software in the PSCM. Using the latest version of Ford Diagnosis and Repair System (FDRS) scan tool, update the PSCM to the latest software level. For claiming, use causal part 3C529 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (7)Associated Documents - March 10, 2023•Document ID: 10233845Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL; EQUIPMENT:OTHER:LABELS
- Mfr Comm. #:
- 22L05
- Date Added:
- April 6, 2023
- Manufacturer:
- FORD
Summary2020-2022 Model Year Escape and Corsair, 2021-2022 Bronco Sport and 2022 Maverick Vehicles Equipped With a 2.0L EcoBoost Engine Vehicle Emissions Control Information Label Update Owner Letters
Associated Products (7)Associated Documents - February 8, 2023•Document ID: 10232491Service Bulletin/Repair InstructionsSERVICE BRAKES; POWER TRAIN
- Mfr Comm. #:
- TSB 23-2041
- Date Added:
- March 4, 2023
- Manufacturer:
- FORD
SummarySome 2020-2022 Escape vehicles built on 1-Nov-2020 and through 29-Aug-2022 and 2021-2022 Bronco Sport vehicles built on or before 23-Sep-2022 may exhibit a moan noise when the vehicle is driven in reverse (R) in cold weather and/or high humidity. This may be due to the suspension sensitivity of the vehicle and interaction of the caliper housing with the pad backplate. To correct this condition, follow the Service Procedure to replace the rear caliper bushings.
Associated Products (4)Associated Documents - February 7, 2023•Document ID: 10232572Service Bulletin/Repair InstructionsEQUIPMENT; EQUIPMENT:OTHER:LABELS
- Mfr Comm. #:
- 22L05
- Date Added:
- March 6, 2023
- Manufacturer:
- FORD
SummaryCertain 2020-2022 Model Year Escape and Corsair, 2021-2022 Bronco Sport and 2022 Maverick Vehicles Equipped With a 2.0L EcoBoost Engine Vehicle Emissions Control Information Label Update
Associated Products (7)Associated Documents - January 17, 2023•Document ID: 10231021Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 22B38
- Date Added:
- February 3, 2023
- Manufacturer:
- FORD
SummaryCertain 2022 Model Year Multiple Vehicle Lines Equipped with 8F35 Transmissions Transmission Replacement In all of the affected vehicles, the snap ring that is used to hold the 8F35 transmission clutch compression spring engaged was not fully seated in the assembly process. When the snap ring is not fully seated, the transmission will function as if the C clutch is partially engaged. The customer may experience rough shifts until the transmission can adapt to the clutch performance. There is a potential long term durability concern associated with the compromised function of the clutch.
Associated Products (6)Associated Documents - January 6, 2023•Document ID: 10230783Service Bulletin/Repair InstructionsVISIBILITY:SUN/MOON ROOF ASSEMBLY
- Mfr Comm. #:
- SSM 51286
- Date Added:
- January 31, 2023
- Manufacturer:
- FORD
SummarySome 2021-2022 Bronco Sport vehicles built on or before 07-Nov-2022 may exhibit a squeak/rattle/creak noise from the roof opening panel when the glass is closed or in vent position while driving on uneven highways. This may be due to roof opening panel bolts not being properly secured. To correct this condition, confirm that the bolts on each side of the moon roof are properly tightened. If the bolts are not properly tightened, tighten the bolts. Refer to the Workshop Manual Section (WSM), Section 501-17 Roof Opening Panel Glass > Removal and Installation.
Associated Products (2)Associated Documents - January 6, 2023•Document ID: 10230782Service Bulletin/Repair InstructionsVEHICLE SPEED CONTROL:CRUISE CONTROL; FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
- Mfr Comm. #:
- SSM 51285
- Date Added:
- January 31, 2023
- Manufacturer:
- FORD
SummarySome 2020-2022 Escape/Corsair, 2021-2022 Bronco Sport, 2022 Maverick vehicles may exhibit any of the following driver assistance warning messages displayed in the instrument panel cluster (IPC): Pre-collision Assist Not Available, Cruise Control Not Available, Collision Warning Malfunction and/or Adaptive Cruise Control Malfunction. Diagnostic trouble code (DTC) U0415:00 may also be stored in the power steering control module (PSCM), DTC C0051:67 stored in the anti-lock brake system (ABS) module and DTC U0418:86 stored in the image processing module A (IPMA). This may be due to the software in the power steering control module (PSCM). To correct this condition, using the latest version of Ford Diagnosis and Repair System (FDRS) scan tool. Update the PSCM to the latest software level.
Associated Products (7)Associated Documents - December 16, 2022•Document ID: 10228876Service Bulletin/Repair InstructionsSERVICE BRAKES
- Mfr Comm. #:
- SSM 51261
- Date Added:
- January 6, 2023
- Manufacturer:
- FORD
SummarySome Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotors should only be machined if directed by the WSM because one or more of the following conditions are present on the braking surface: scoring, excessive corrosion/rust or pitting, bluing/discoloration and/or heat spots. For additional information, refer to WSM section 206-00.
Associated Products (41)2023 Ford Bronco2023 Ford Bronco Sport2023 Ford E-3502023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Maverick2023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Bronco2022 Ford Bronco Sport2022 Ford E-3502022 Ford Edge2022 Ford Escape2022 Ford Expedition2022 Ford Explorer2022 Ford F-150+ 21 moreAssociated Documents - December 16, 2022•Document ID: 10228761Service Bulletin/Repair InstructionsFUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
- Mfr Comm. #:
- TSB 22-2433
- Date Added:
- January 5, 2023
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 22-2176 to increase the labor operation allowance and update the part list. Some 2020-2022 Escape/Corsair vehicles built on or before 3-Jan-2022, 2020-2022 Explorer vehicles built on or before 14-Feb-2022, 2020-2022 Aviator vehicles built on or before 07-Feb-2022 and 2021-2022 Bronco Sport vehicles built on or before 3-Dec-2021 may exhibit a slow fuel fill and/or spit back condition during refueling. This may be due to the design of the fuel tank filler pipe. To correct the condition, follow the Service Procedure to replace the fuel tank filler pipe.
Associated Products (10)Associated Documents - December 14, 2022•Document ID: 10228872Service Bulletin/Repair InstructionsPOWER TRAIN; STEERING:STEERING CONTROL MODULE
- Mfr Comm. #:
- SSM 51255
- Date Added:
- January 5, 2023
- Manufacturer:
- FORD
SummarySome 2020-2022 Escape/Corsair, 2021-2022 Bronco Sport, and 2022 Maverick vehicles may exhibit a hard, stiff, and/or difficult to turn condition due to a lack of power steering assist during engine start-up with various U3000 diagnostic trouble codes (DTCs) and/or U3000:66. To correct this condition, using the latest version of Ford Diagnosis and Repair System (FDRS) tool, select and run the PSCM - Reset the Power Steering Control Module (PSCM) application. After PSCM reset, perform an ignition cycle. Update the PSCM to the latest software level using (FDRS) tool. If DTCs U3000 returns, continue with diagnostics and repair direction using Workshop Manual (WSM), Section 211-02 > Power Steering > Diagnosis and Testing. For claiming, use causal part 3C529 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (7)Associated Documents - December 14, 2022•Document ID: 10228871Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR; BACK OVER PREVENTION:SOFTWARE
- Mfr Comm. #:
- SSM 51254
- Date Added:
- January 5, 2023
- Manufacturer:
- FORD
SummarySome 2020-2022 Escape/Corsair/F-53 Motorhome/F-59 Commercial Stripped Chassis, 2021-2023 F-650/F-750/E-Series, and 2021-2022 Bronco Sport vehicles may exhibit an intermittent no crank/no start condition and/or an intermittent blank instrument panel cluster (IPC)/SYNC touchscreen. This may be due to the software in the gateway module (GWM). To correct the condition, reprogram the GWM using the latest software level of the appropriate Ford diagnostic scan tool. For claiming use causal part 14F642 and the applicable labor operations of Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (9)Associated Documents - December 13, 2022•Document ID: 10228800Service Bulletin/Repair InstructionsEQUIPMENT; EQUIPMENT:ELECTRICAL:WIRELESS CHARGER/CRADLE
- Mfr Comm. #:
- TSB 22-2485
- Date Added:
- January 5, 2023
- Manufacturer:
- FORD
SummarySome 2020-2021 Expedition/Navigator, 2020-2022 F Super Duty/Explorer, 2021-2022 Bronco/Corsair/Escape/Bronco Sport, 2022 Maverick vehicles may exhibit the wireless charger inoperative or poor performance when using some Apple iPhone models that use MagSafe wireless charging including iPhone 12 and 13. This may be due to limited compatibility with the wireless accessory charging module (WACM). To correct the condition, follow the Service Procedure to update the WACM. Note: The WACM software is designed to improve the compatibility between some Apple MagSafe charging iPhones, including iPhone 12 and 13 models, and the Ford Qi wireless charging module.
Associated Products (15)Associated Documents - December 8, 2022•Document ID: 10228751Service Bulletin/Repair InstructionsWHEELS
- Mfr Comm. #:
- TSB 22-2413
- Date Added:
- January 5, 2023
- Manufacturer:
- FORD
SummarySome 2022 Bronco Sport vehicles built on 04-Aug-2022 and through 05-Aug-2022 may exhibit an ABS warning indicator with diagnostic trouble code (DTC) C0030:07 stored in the ABS module. The vehicle may also exhibit a squeal noise from the left front wheel area. This may be due to a condition where the wheel bearing and snap ring are not fully seated in the left wheel knuckle causing contact between the front halfshaft and wheel knuckle. To correct this condition, follow the Service Procedure to diagnose and replace the wheel knuckle, hub, bearing and front halfshaft.
Associated Products (1)Associated Documents - December 1, 2022•Document ID: 10228846Service Bulletin/Repair InstructionsCOMMUNICATION:MANUFACTURER TELEMATICS
- Mfr Comm. #:
- SSM 51228
- Date Added:
- January 5, 2023
- Manufacturer:
- FORD
SummarySome 2020-2023 Ford and Lincoln vehicles equipped with a telematic control unit (TCU) may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization, and/or modem electronic serial number (ESN) could not be displayed in the center display screen. To correct this condition prior to programming, remove the TCU fuse for 5-minutes then reinstall. Delete all previous session files for the vehicle. Start a new Ford Diagnosis and Repair System (FDRS) session. Perform a TCU provisioning and Program the TCU to the latest FDRS version level. If the concern is still present, follow normal diagnostics in Workshop Manual (WSM), Section 415-00. Refer to PTS OASIS home page for TCU version identification. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (22)2023 Lincoln Aviator2022 Ford Bronco Sport2022 Ford Escape2022 Ford Explorer2022 Ford Maverick2022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Ford Transit Connect2022 Lincoln Aviator2022 Lincoln Corsair2021 Ford Bronco Sport2021 Ford Escape2021 Ford Expedition2021 Ford Explorer2021 Ford Mustang2021 Ford Ranger2021 Ford Transit2021 Ford Transit Connect2021 Lincoln Aviator+ 2 moreAssociated Documents - November 10, 2022•Document ID: 10226757Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 51191
- Date Added:
- November 30, 2022
- Manufacturer:
- FORD
SummarySome 2021-2022 Mustang Mach-E built on or before 17-Jan-2022, 2022 Escape built on or before 03-Mar-2022, Bronco Sport built on or before 04-Mar-2022, 2022 Maverick built on or before 25-Jan-2022 and 2022 Transit built on or before 17-May-2022 may exhibit a powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P0929:77 stored in the gear shift module (GSM). This may be due to the software in the GSM. To correct this condition, perform Pinpoint Test D. Refer to Workshop Manual (WSM), Section 307-05 > Diagnosis and Testing. If the GSM is not operating correctly, perform the replacement of the GSM. Do not perform a PMI after installing a new GSM assembly. The GSM is shipped with the latest software level. For claiming, use causal part 7P155 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (4)Associated Documents - November 7, 2022•Document ID: 10226753Service Bulletin/Repair InstructionsPARKING BRAKE
- Mfr Comm. #:
- SSM 51184
- Date Added:
- November 29, 2022
- Manufacturer:
- FORD
SummarySome 2020-2022 Escape/Corsair vehicles built on or before 17-May-2022 and 2021-2022 Bronco Sport vehicles built on or before 25-Feb-2022 may exhibit a hiss or rattle noise while driving. This may be due to an internal issue with the manual park release cable. If the noise is eliminated when the cable is disconnected from the transmission, install a new manual park release cable assembly LX6Z-7D246-T. Refer to the Workshop Manual (WSM), Section 307-05 > Automatic Transmission External Controls > Removal and Installation.
Associated Products (6)Associated Documents