Country Coach Intrigue Recalls

23 recalls on file.

• Recall08V119000March 13, 2008
  EXTERIOR LIGHTING

  COUNTRY COACH IS RECALLING 1,228 MY 2004-2008 MAGNA, AFFINITY AND INTRIGUE MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUES SPECIFIED IN FMVSS NO. 108.

  Remedy

  DEALERS WILL REPLACE THE MARKER LIGHTS ON THE SIDE OF EACH MOTOR HOME AS CLOSE AS REASONABLE TO THE FRONT AND REAR CORNERS AND WIRED INTO THE PARK LIGHT SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall07V239000June 13, 2007
  ENGINE AND ENGINE COOLING:ENGINE:DIESEL

  ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

  Remedy

  COUNTRY COACH IS WORKING WITH CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 800-343-7357 OR COUNTRY COACH AT 1-541-998-3720.

• Recall07V031000February 1, 2007
  EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

  CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

  Remedy

  COUNTRY COACH WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). A SECONDARY BURNER HOUSING WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON MARCH 28, 2007. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COUNTRY COACH AT 1-800-452-8015.

• Recall07V037000February 1, 2007
  SERVICE BRAKES, AIR

  CERTAIN MOTOR HOMES EQUIPPED WITH TUTHILL 1660 INDEPENDENT FRONT SUSPENSION HAVE FRONT AIR BRAKE HOSES THAT COULD POTENTIALLY BE CHAFFED AND RUBBED BY THE STEER AXLE TIRES OR CHASSIS COMPONENTS UNDER CERTAIN CONDITIONS.

  Remedy

  DEALERS WILL RE-ROUTE AND SECURE THE BRAKE HOSES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 19, 2007. OWNERS MAY CONTACT COUNTRY COACH AT 800-547-8015.

• Recall06V262000July 13, 2006
  TIRES

  COUNTRY COACH HAS REPORTED THAT THE TOYO 275/70R M102Z TIRES ON CERTAIN MOTOR HOMES ARE DEFECTIVE AND COULD FAIL UNEXPECTEDLY.

  Remedy

  DEALERS WILL REPLACE THESE TIRES WITH MICHELIN 275/70R XZA2 TIRES. THE FEDERAL TIRE LABELS WILL ALSO BE REPLACED. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall05V398000September 14, 2005
  TIRES

  CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THESE MOTOR HOMES WERE INADVERTENTLY ASSIGNED INADEQUATE COLD TIRE INFLATION PRESSURES GIVING THE TIRES A LOWER WEIGHT CARRYING CAPACITY THAN THE FRONT AND REAR AXLE WEIGHT RATINGS.

  Remedy

  DEALERS WILL REPLACE BOTH THE FRONT AND REAR TIRES AND ISSUE A NEW FEDERAL TIRE LABEL REFLECTING THE CORRECTED COLD TIRE INFLATION PRESSURES. THE RECALL BEGAN ON NOVEMBER 7, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall05V373000August 29, 2005
  EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

  ON CERTAIN MOTOR HOMES, THE HYDRAULIC SLIDE ROOM HOSES COULD BLISTER AND LEAK DUE TO ENGINE HEAT.

  Remedy

  DEALERS WILL RELOCATE THE HYDRAULIC HOSES OUTSIDE OF THE ENGINE COMPARTMENT AND REPLACE ANY HOSES THAT EXHIBIT SIGNS OF BLISTERING OR LEAKAGE. THE RECALL BEGAN ON SEPTEMBER 12, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall05V360000August 16, 2005
  ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

  ON CERTAIN MOTOR HOMES, THE USE OF A 20 AMP CIRCUIT BREAKER IN THE 120V AC PANEL FOR AUDIO/VIDEO EQUIPMENT DOES NOT PROTECT THE CIRCUIT AGAINST COMPONENT FAILURES. THE CIRCUIT IS ONLY RATED FOR A 15 AMP CIRCUIT BREAKER.

  Remedy

  DEALERS WILL REMOVE THE 20 AMP CIRCUIT BREAKER, AND INSTALL A 15 AMP CIRCUIT BREAKER. THE RECALL BEGAN ON AUGUST 29, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 800-547-8015.

• Recall05V277000June 14, 2005
  TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

  CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE FRONT AND REAR TIRE COLD TIRE INFLATION PRESSURES OF 125 PSI EXCEED THE MANUFACTURER'S RECOMMENDED MAXIMUM COLD INFLATION PRESSURE OF 120 PSI.

  Remedy

  COUNTRY COACH WILL ISSUE REPLACEMENT FEDERAL TIRE LABELS REFLECTING THE CORRECTED COLD TIRE INFLATION PRESSURE OF 120 PSI FOR BOTH THE FRONT AND REAR TIRES. THIS CHANGE WILL RESULT IN A REDUCTION OF THE COLD INFLATION TIRE PRESSURE OF EACH FRONT AND REAR TIRE BY 5 PSI. THE RECALL BEGAN ON JUNE 23, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall05V209000May 9, 2005
  EQUIPMENT

  ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.

  Remedy

  VEHICLE SYSTEMS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT VEHICLE SYSTEMS AT 1-800-685-4298 OR COUNTRY COACH AT 1-800-547-8015.

• Recall04V259000June 7, 2004
  STEERING

  ON CERTAIN MOTOR HOMES EQUIPPED WITH AN INDEPENDENT FRONT SUSPENSION (IFS) GEN II BUILT BY HOLLAND USA, THE GEAR PLATE SUPPORT GUSSETS WERE REMOVED. THIS CAN ALLOW THE PLATE TO FLEX DURING A STATIC STEER CONDITION.

  Remedy

  HOLLAND USA IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. A BOLT-ON STRENGTHENING OF THE STEERING GEAR PLATE WITH U-BOLTS CONNECTING THE CROSS MEMBER TO EACH SIDE OF THE GEAR PLATE AT THE REAR PLUS A TUBE SUPPORT IN THE FRONT WITH J-BOLTS TO THE GEAR PLATE WILL BE INSTALLED. OWNERS SHOULD CONTACT HOLLAND USA CUSTOMER SERVICE AT 1-888-396-6501 FOR INFORMATION AND INSTRUCTIONS FOR WHERE CUSTOMERS CAN TAKE THEIR VEHICLES TO HAVE THE REPAIRS DONE FREE OF CHARGE.

• Recall04E040000May 28, 2004
  STEERING

  HOLLAND INDEPENDENT FRONT SUSPENSIONS P/N 90547917 IFS-114 WITH THE 90547978 SUBFRAME FOR USE ON CERTAIN COUNTRY COACH VEHICLES AND SHIPPED BETWEEN MARCH 5, 2003, AND JUNE 28, 2004. EARLY IFS-114 UNITS WITH P/N 90546687 USED A DIFFERENT SUBFRAME, P/N 90546691 THAT IS NOT AFFECTED BY THIS RECALL. THE NEW SUBFRAME DID NOT HAVE GUSSETS THAT HELP SUPPORT THE STEERING GEAR MOUNTING PLATE. THE LACK OF GUSSETS ALLOWS EXCESSIVE FLEXING OF THE STEERING GEAR MOUNTING PLATE WHICH MAY LEAD TO FATIGUE CRACKS.

  Remedy

  HOLLAND WILL NOTIFY COUNTRY COACH'S CUSTOMERS AND PROVIDE REMEDY FREE OF CHARGE. OWNER NOTIFICATION BEGAN JULY 28, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HOLLAND USA CUSTOMER SERVICE AT 1-888-396-6501.

• Recall03V109000March 26, 2003
  EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

  ON CERTAIN MOTORHOMES EQUIPPED WITH INTERNATIONAL THERMAL RESEARCH (ITR)HURRICANE HOT WATER HEATERS, THE ELECTRONIC CONTROL BOARD MAY ADVERSELY AFFECT SAFETY FEATURES IN SOME OF THE SYSTEMS PROTECTING AGAINST OVERHEATING AND POTENTIAL FIRE SITUATION.

  Remedy

  THE DEFECTIVE ELECTRONIC CONTROL BOARD WILL BE REPLACED. IN THE MEANTIME, CUSTOMERS SHOULD TURN THE SYSTEM OFF USING THE MASTER ON/OFF SWITCH LOCATED ON THE SIDE OF THE ELECTRONIC CONTROL BOX WHICH IS ADJACENT TO THE HEATER. OWNERS WHO TAKE THEIR MOTORHOMES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ITR AT 1-800-755-1272 OR COUNTRY COACH AT 1-800-547-8015.

• Recall02V229000August 22, 2002
  EQUIPMENT:OTHER:LABELS

  CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE MOTOR HOMES WERE ERRONEOUSLY ASSIGNED INADEQUATE COLD TIRE INFLATION PRESSURES AND INADEQUATE AXLE WEIGHT RATINGS ON THE FRONT AND/OR REAR AXLES AS A RESULT OF MATHEMATICAL MISCALCULATIONS.

  Remedy

  DEALERS WILL REPLACE THE FRONT AND/OR REAR TIRES. IN SOME INSTANCES, THE MOTOR HOMES MAY ONLY HAVE AN INADEQUATE FAWR AND/OR RAWR STATED ON THE FEDERAL TIRE LABEL AND ONLY THE FEDERAL TIRE LABEL WILL BE REPLACED. OWNER NOTIFICATION IS EXPECTED TO BEGIN AUGUST 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.

• Recall01V322003November 26, 2001
  VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

  VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES. THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.

  Remedy

  DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING DECEMBER 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.

• Recall01V358000November 23, 2001
  VISIBILITY:WINDSHIELD WIPER/WASHER

  VEHICLE DESCRIPTION: MOTOR HOMES. THE WINDSHIELD WIPERS EQUIPPED WITH THE SMARTWHEEL OPTION WERE IMPROPERLY GROUNDED. THE IMPROPER GROUND CAUSES THE WIPER MOTORS AND BLADES TO PERIODICALLY STOP WHEN THE MOTOR HOME IS IN TRANSIT AT FREEWAY SPEEDS.

  Remedy

  DEALERS WILL CORRECTLY GROUND THE WINDSHIELD WIPER MOTOR CASE. OWNER NOTIFICATION BEGAN DECEMBER 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.

• Recall01V111002June 26, 2001
  SERVICE BRAKES, AIR:SUPPLY:COMPRESSOR

  VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH CUMMINS ISC AND ISL DIESEL ENGINES. THE INTERNAL FRONT BUSHING CAN SPIN, CAUSING DAMAGE TO THE AIR COMPRESSOR, AND POSSIBLY TO THE SPINDLE DRIVE AT THE REAR FACE OF THE AIR COMPRESSOR WHICH IS USED TO PROVIDE POWER TO THE VEHICLE HYDRAULIC PUMP. FAILURE OF THE AIR COMPRESSOR'S SPINDLE DRIVE COULD LEAD TO LOSS OF POWER ASSIST IF THE HYDRAULIC PUMP CEASES TO OPERATE.

  Remedy

  CUMMINS WILL NOTIFY COUNTRY COACH CUSTOMERS AND REPLACE THE AIR COMPRESSOR FREE OF CHARGE. OWNER NOTIFICATION BEGAN MARCH 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CUMMINS CUSTOMER ASSISTANCE CENTER 1-800-343-7357.

• Recall01V170000May 29, 2001
  EQUIPMENT:OTHER:LABELS

  CERTAIN MOTOR HOMES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE VEHICLES HAVE AN INEQUITABLE WEIGHT DISTRIBUTION BETWEEN THE FRONT LEFT AND RIGHT TIRES ON THE FRONT AXLE. THIS WEIGHT INEQUITY CAN CAUSE THE LEFT FRONT TIRE WEIGHT RATING TO BE EXCEEDED.

  Remedy

  DEALERS WILL REPLACE THE HEIGHT CONTROL VALVES AND THE HEIGHT CONTROL VALVE CONFIGURATION REVERSED TO REMEDY THIS NONCOMPLIANCE. OWNER NOTIFICATION BEGAN MAY 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.

• Recall01V084000March 16, 2001
  SERVICE BRAKES, AIR

  VEHICLE DESCRIPTION: MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THESE VEHICLES WERE ASSIGNED AN INADEQUATE FRONT AXLE WEIGHT RATING (FAWR). AS A CONSEQUENCE, THE FRONT BRAKE CANISTERS AND SLACK ADJUSTERS DO NOT COMPLY WITH THE STANDARD REQUIREMENTS.

  Remedy

  DEALERS WILL INSPECT THE FRONT BRAKE CANISTERS AND REPLACE THEM IF NECESSARY. OWNER NOTIFICATION BEGAN MARCH 15, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.

• Recall99V082003August 21, 2000
  SERVICE BRAKES, AIR:SLACK ADJUSTERS

  VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH 15" (WIDTHS: 4" AND 5") AIR-ACTUATED Q-PLUS CAM BRAKE EQUIPPED WITH FEDERAL MOGUL FRICTION PRODUCTS 3030-197 BRAKE LINING (MERITOR R201) BRAKE LININGS AND ACTUATED WITH TYPE 20 AIR CHAMBERS X 5.5" SLACK ADJUSTERS. THESE ASSEMBLIES DO NOT FULLY SATISFY THE TEST PERFORMANCE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS."

  Remedy

  THE BRAKE LINING WILL BE REPLACED WITH UPGRADED BRAKE LININGS.