CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUE AND 45 DEGREES AS SPECIFIED IN THE STANDARD.
ON CERTAIN MOTOR HOMES, LIQUID PROPANE (LP) GAS COOK TOPS WERE INSTALLED USING A FLEXIBLE RUBBER HOSE THAT COULD BURN OR MELT.
ON CERTAIN MOTOR HOMES, A CIRCUIT BREAKER IN THE CLEARANCE LIGHT CIRCUIT DOES NOT PROTECT THE CIRCUIT FROM A TOO HIGH AMPERAGE DRAW CAUSED BY A TOWED PASSENGER VEHICLE.
ON CERTAIN MOTOR HOMES EQUIPPED WITH AN INDEPENDENT FRONT SUSPENSION (IFS) GEN II BUILT BY HOLLAND USA, THE GEAR PLATE SUPPORT GUSSETS WERE REMOVED. THIS CAN ALLOW THE PLATE TO FLEX DURING A STATIC STEER CONDITION.
HOLLAND INDEPENDENT FRONT SUSPENSIONS P/N 90547917 IFS-114 WITH THE 90547978 SUBFRAME FOR USE ON CERTAIN COUNTRY COACH VEHICLES AND SHIPPED BETWEEN MARCH 5, 2003, AND JUNE 28, 2004. EARLY IFS-114 UNITS WITH P/N 90546687 USED A DIFFERENT SUBFRAME, P/N 90546691 THAT IS NOT AFFECTED BY THIS RECALL. THE NEW SUBFRAME DID NOT HAVE GUSSETS THAT HELP SUPPORT THE STEERING GEAR MOUNTING PLATE. THE LACK OF GUSSETS ALLOWS EXCESSIVE FLEXING OF THE STEERING GEAR MOUNTING PLATE WHICH MAY LEAD TO FATIGUE CRACKS.
2005 COUNTRY COACH / INSPIRE- SUDDEN LOSS OF STEERING AND CONTROL OF MOTOR HOME DUE TO COMPLETE FAILURE OF POWER TAKE OFF AND PUMPS. THE GEARS HAVE NO LUBRICATION AND COMPLETELY STRIPPED RESULTING IN A SUDDEN AND COMPLETE FAILURE OF STEERING CAPABILITY THIS STRANDED US IN THE MIDDLE OF I10 WEST BLOCKING TRAFFIC ON THE INTERSTATE. UPDATED 05/26/11 *BF *TR UPDATED 2/9/12 *CN
No injuries · No fire · No crash
TL*THE CONTACT OWNS A 2005 COUNTRY COACH INSPIRE RV. THE CONTACT STATED THAT THE PTO WAS DETERIORATED BECAUSE IT WAS DRY LUBRICATED. HE HAS NOT TAKEN THE VEHICLE TO THE DEALER, BUT SPECULATED THAT IF THE COMPONENT WAS WET LUBRICATED, THE FAILURE WOULD BE CORRECTED. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 12,000.
No injuries · No fire · No crash
WHILE TRAVELING TO ALASKA IN OUR 2005 COUNTRY COACH INSPIRE WE HAD A TRANSMISSION OIL COOLER FAILURE WHICH CAUSED THE ENGINE COOLANT TO DRAIN INTO THE TRANSMISSION AND CAUSING IT TO FAIL. WE HAD TO BE TOWED 100 MILES TO A REPAIR FACILITY IN COBURG, OR, WHERE THE FOUND THAT BESIDES THE OIL COOLER, THE CHARGE AIR COOLER AND THE CHELSEA PTO WERE ALSO DEFECTIVE AND HAD TO BE REPLACED. THE PTO ON OUR UNIT DRIVES BOTH THE FAN AND THE POWER STEERING. IT IS THE SAME UNIT PRESENTLY ON RECALL FOR THE CC MAGNA AND INFINITY MODELS. THE REPLACEMENT FOR THE DEFECTIVE PTO WHICH WAS A DRY SPLINE IS A WET UNIT SO THAT SPLINE FAILURE WILL NOT OCCUR IN THE FUTURE. IF THE DEFECTIVE PTO HAD NOT BEEN FOUND AT THIS TIME. THE SPLINES WOULD HAVE FAILED COMPLETELY RESULTING IN THE LOSS OF POWER STEERING WHICH COULD BE FATAL. THE DEFECTIVE UNIT IS AT PACIFIC POWER PRODUCTS, COBURG, OR. OUR UNIT ONLY HAS 39,000 MILES ON IT AT THIS TIME. IT IS MY UNDERSTANDING THAT CHELSEA ADVISED CC THAT THESE UNITS ONLY HAD A LIFE OF 30,000 MILES BUT THEY CHOSE TO IGNORE THIS AND FAILED TO ADVISE OWNERS OF THE POTENTIAL FOR FAILURE. *TR
No injuries · No fire · No crash
TL*THE CONTACT OWNS A 2005 COUNTRY COACH INSPIRE. THE CONTACT DID NOT RECEIVE A NOTICE REGARDING NHTSA CAMPAIGN ID NUMBER 07V241000 (EXTERIOR LIGHTING). HE CALLED THE MANUFACTURER AND THEY STATED THAT NO RECALL WAS AVAILABLE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 23,000. UPDATED 01-14-08. *KB UPDATED 12/12/07. *JB
No injuries · No fire · No crash
UNABLE TO SEE DASHBOARD DISPLAY/WARNING LIGHTS IN DAYTIME. HAVE COMPLAINED SINCE JANUARY 2005. ALL COUNTRY COACH "INSPIRE" MODELS 2005-2006,2007 HAVE SAME PROBLEM. HAVE BEEN TOLD A FIX IS BEING WORKED ON, BUT TO DATE NOTHING. *TR
No injuries · No fire · No crash