Chevrolet Monte Carlo Complaints (2002)

230 consumer complaints on file.

#11564051January 7, 2024
FUEL/PROPULSION SYSTEM
My car has the engine 3.1 L automatic. On January 4, I was going to go run errands so I went out to my car and cranked it to start the engine but instead, I heard a loud explosion, causing the front tires of the car to go up in the air and then land back on the ground. Smoke started coming out from the hood and a fire almost got started. I was scared to half to death causing me to almost have a heart attack. Morning inspection, I found that the intake manifold had exploded on the car and pieces of it were all over the engine. I feel that the pressure regulator may have been the culprit, but the plastic upper intake just literally blew up. Nobody was injured neighbors came out to see what the explosion had been, the window on my windshield cracked and major damage has been done to the Plenum. I have pictures but I’ve been unable to upload them but they are available. If you need them I went to Mission Chevrolet where I purchased the car but was referred to contact you in general. no recalls sent over this issue, but have I been driving when the explosion occurred it may have caused fatalities to myself, and perhaps other drivers on the freeway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11407830April 13, 2021
ELECTRICAL SYSTEM
MY INSTRUMENT CLUSTER WILL RESET WHILE I AM DRIVING. THE GUAGES WILL SWEEP AND ALL THE WARNING LIGHTS COME ON AND THE CAR WILL DING AS IF IT WAS JUST STARTED HOWEVER THE CAR NEVER STALLS AND THE RADIO STAYS ON ALONG WITH EVERYTHING ELSE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11407573April 12, 2021
FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNED 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED AT APPLE VALLEY CHEVROLET (650 FOXCROFT AVE, MARTINSBURG, WV 25401) FOR A FUEL CONTROL SENSOR REPLACEMENT. THE VEHICLE WOULD NOT START AFTER IT WAS SERVICED AT THE DEALER THEN CAUGHT ON FIRE WHILE THE CONTACT'S HUSBAND WAS TRYING TO START IT UP. THE CONTACT'S HUSBAND WAS ABLE TO PUT OUT THE FIRE WITH A HOSE. NO POLICE REPORT WAS FILED. THE VEHICLE WAS STILL AT THE CONTACT'S RESIDENCE. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 96,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11318928March 22, 2020
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
STARTED CAR AND HEARD A LOUD BOOM AND THEN SMOKE UNDER THE HOOD AND INTAKE COVER AND HARNESS ON FIRE
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11278261November 5, 2019
ELECTRICAL SYSTEM
WAS GOING ABOUT 55-60 MPH DOWN THE HIGHWAY AND MY RPMS STARTED TO DROP AND I LET OFF GAS AND IT JUST DIED. IT CRANKS AND TURNS OVER BUT WILL NOT FIRE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11207045May 11, 2019
ENGINE, FUEL/PROPULSION SYSTEM
THE CAR'S FUEL GAGE STOPPED WORKING. THE CAR WOULDN'T TURN OVER WHEN I STARTED IT SO I GOT A NEW BATTERY SINCE IT SAID MY OLD ONE WAS BAD, BUT IT'S STILL NOT WORKING. THE SECURITY LIGHT IS ON AND I DON'T UNDERSTAND WHY AND IF THIS IS AFFECTING IT FROM TURNING ON
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11185841March 11, 2019
SERVICE BRAKES
THE BRAKE LINES ARE RUSTED OUT CAR ONLY HAS 55,000 MILES IT IS SITTING OUTSIDE BUT ON BLACKTOP IN OUR DRIVE WAY. WE WENT TO USE IT AND THE DASH LIT LIKE MAD CHECKED BRAKE FLUID IT WAS LOW DROVE IT AND ALMOST DID,NT MAKE IT HOME WITH BRAKES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11120458August 16, 2018
AIR BAGS, SERVICE BRAKES
ABS LIGHT TRACTION CONTROL LIGHT AND AIR BAG LIGHT ARE CONSTANTLY ON..,SINCE IVE OWNED IT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11047285November 19, 2017
SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
ABOUT OCTOBER 10TH, 2017 I WAS COMING UP ON A TRAFFIC LIGHT AND WHEN I APPLIED THE BRAKES, THE PEDAL WOULD NOT GO DOWN. I WAS GOING ABOUT 45 MPH BY THE GRACE OF GOD I WAS ABLE TO BLAST THROUGH AN INTERSECTION AND MISS EVERYONE, EVERYTHING!. RATTLED I GUESS I SHUT THE CAR OFF WHEN I REGAINED MY COMPOSER I STARTED THE CAR AND EVERYTHING WAS FINE. I DID NOT WANT TO BELIEVE THIS HAPPENED! I THOUGHT I DID SOMETHING WRONG MAYBE HAD MY FOOT UNDER THE BRAKE PEDAL OR SOMETHING. HAVE BEEN DRIVING THE CAR SINCE 2 WEEKS AGO WAS STRANDED IN A PARKING LOT, WOULD NOT START. HAD THE CAR TOWED HOME, TRIED TO START IT AND STARTED RIGHT UP. NOW SERVICE TRACK LIGHT IS ON AND ANTI LOCK BRAKES IS ON AND SERVICE ENGINE LIGHT IS ON SOMETIME AND THE CRUISE LIGHT IS ON. YESTERDAY WIFE WAS DRIVING THE CAR AND SAME THING NO BRAKES, YOU COULD NOT PUSH THE PEDAL DOWN IT IS AS IF THERE IS SOMETHING UNDER THE PEDAL IT'S THAT SOLID. MY CONCERN FOR MY OWN SAFETY AS WELL AS OTHER MONTE CARLO OWNERS IS MOST IMPORTANT. IF EITHER TIME WE WOULD HAVE BEEN ON A EXPRESSWAY WHERE WE COULD NOT TURN TO A SHOULDER THIS WOULD BE CATASTROPHIC . CALLED THE SERVICE MANAGER WHERE THE CAR WAS PURCHASED, ALSO HARBOR CHEVY IN MICHIGAN CITY, IN AND GATES CHEVY IN SOUTH BEND, INDIANA, ALL SAID THEY HAVE NEVER HEARD OF THIS BEFORE. GOT ON THE INTERNET AND FOUND SIMILAR POSTS IN CAR COMPLAINTS WITHOUT ANY PROBLEM, SEEMS ODD GM DOES NOT KNOW ANYTHING ABOUT THIS. FOR EVERY ONES OWN SAFETY THIS SHOULD BE A REDUNDANT SYSTEM IN OLDER CARS YOU WOULD NOT LOSE ALL BRAKES. COULD UNDERSTAND IF YOU LOST ANTI LOCK PART BUT STILL COULD STOP. THIS HAS TO BE A OVERLOOKED FLAW IN DESIGN AND GM SHOULD BE MADE TO CORRECT THIS BEFORE SOMEONE GETS KILLED. IF SOMEONES BEEN KILLED BY THIS HOW COULD THEY TELL YOU THAT HE LOST HIS BRAKES? THANK YOU MIKE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11043601November 5, 2017
UNKNOWN OR OTHER
RECALL NO.14V400
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11001693June 27, 2017
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING 2 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE CONTACT OBSERVED FLAMES UNDER THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE FIRE DEPARTMENT STATED THAT THE FIRE OCCURRED DUE TO A FUEL LEAK. PRIOR TO THE FIRE, THERE WERE NO LEAKS PRESENT. THE CONTACT ALSO STATED THAT THE FIRE OCCURRED AFTER THE VEHICLE WAS FUELED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT A CASE MANAGER WOULD BE ASSIGNED TO THE CASE. THE FAILURE MILEAGE WAS APPROXIMATELY 32,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11001289June 25, 2017
ELECTRICAL SYSTEM
PASSLOCK SYSTEM; CAR WILL RANDOMLY (TEMPERATURE BASED?) REFUSE TO START DUE TO POORLY CONSTRUCTED PASSLOCK SENSOR. I KEEP MY DASH APART SO I CAN POKE AT THE CONTACTS (CORRODED? CHEAP TIN PLATING) TO HOTWIRE MY CAR WHEN IT LOCKS OUT. TOOK 20 MINUTES TO GO SEE IF MY WIFE WAS OK AT THE ER, THANKS CHEVY!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10955888June 8, 2017
ENGINE
2002 CHEVROLET MONTE CARLO. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE AND REQUESTS REIMBURSEMENT FOR ENGINE REPAIRS. *SMD THE CONSUMER STATED THE ENGINE FAILED WHEN OIL GOT ONTO THE ENGINE AND CAUGHT FIRE. THE CONSUMER HAD NOT RECEIVED A RECALL UNTIL AFTER THE FAILURE. THE CONSUMER HAD THE ENGINE REPLACED. THE CONSUMER WOULD LIKE TO BE REIMBURSED FOR THE COST OF THE ENGINE REPLACEMENT. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10990882May 22, 2017
ENGINE
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHEN THE VEHICLE WAS STARTED, THE CONTACT HEARD A LOUD POPPING SOUND. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE FROM THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS NOTIFIED AND WAS ABLE TO EXTINGUISH THE FIRE. THERE WERE NO INJURIES AND A FIRE REPORT WAS NOT FILED. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10985900May 16, 2017
UNKNOWN OR OTHER
I TOOK MY VEHICLE TO HAVE SERVICE DONE ON A RECALL INVOLVING POTENTIAL UNDER HOOD FIRE TO REPLACE VALVE COVERS. THE OIL WAS/IS LEAKING ONTO THE MANIFOLD AND CAUSING THE CAR TO SMOKE. I BARELY DRIVE THIS CAR AND IT IS STILL LEAKING OIL ONTO THE MANIFOLD AND SMOKING. NOW THE DEALERSHIP WILL NOT FIX WHAT THEY SUPPOSEDLY FIXED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10980421April 25, 2017
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WERE VARIOUS ELECTRICAL SHORTS IN THE VEHICLE, WHICH PREVENTED THE WINDOWS FROM GOING UP AND DOWN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND SEVERAL INDEPENDENT MECHANICS FOR DIAGNOSTIC TESTING. THE MANUFACTURER PROVIDED NO SOLUTION AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10937285December 23, 2016
ELECTRICAL SYSTEM
HAD ISSUES WITH ELECTRICAL IN 2015 IN WHICH GAS GAUGE AND OTHER GAUGES, SPEEDOMETER WERE "BOUNCING". AUTO REPAIR DETERMINED IT WAS THE FUEL PUMP AND REPLACED IT TO THE TUNE OF $600. THIS YEAR, WHILE DRIVING AT HIGHWAY SPEEDS WHEN CAR SUDDENLY LOOSES ALL POWER AND TURNS OFF. BROUGHT BACK TO SAME REPAIR SHOP WHO STATED BATTERY CABLES WERE LOOSE AND TIGHTENED THEM FREE OF CHARGE. NOW 4-5 MONTHS LATER AND SAME ISSUE IS OCCURRING WHICH HAPPENED 4 TIMES TODAY. TWICE WHILE MAKING A HARD TURN. TERMINALS ARE COMPLETELY TIGHT. EARLIER THIS YEAR COULD NOT TURN IGNITION KEY AND TAPPED IT WITH A HAMMER TO GET IT TO TURN. I HAVE BEEN READING QUITE A BIT ABOUT AN IGNITION SWITCH RECALL, BUT NO MENTION OF IT BY THE DEALER FOR TWO RECALL FIXES THIS YEAR REGARDING THE IGNITION KEY AND FOB, AND SOME COVER ON THE ENGINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10926128November 15, 2016
ENGINE
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE THE VEHICLE WAS UNDERGOING A ROUTINE INSPECTION, THE TECHNICIAN NOTICED THAT THE BACK COVER GASKET WAS LEAKING OIL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 21,571.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10895843August 15, 2016
ELECTRICAL SYSTEM
ISSUES WITH THE BCM AND PASSLOCK SYSTEM. THE CAR WHILE ON AND DRIVING WILL DISPLAY SECURITY ALONGSIDE THE BATT GAUGE QUITS WORKING. IF SHUT OFF CAR WILL NOT START, AND LIGHT STAY ON. I HAVE TO DISCONNECT THE BATT FOR SOME TIME. WITH THE THE AUTO LIGHTS SOMETIMES COME ON DURING MID DAY WITH THE SUN SHINING. THIS IS BECOMING A HASSLE. I'D RATHER PURCHASE ANOTHER CAR THAN GO THREW DEALERSHIP HOOPS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10872816June 6, 2016
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING AT ANY SPEED, THE CONTACT NOTICED A BURNING ODOR INSIDE THE VEHICLE CAUSED BY THE EMITTING OIL FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY WERE UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000. .....UPDATED 08/11/16 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Monte Carlo