Chevrolet Malibu Complaints (2004)

1,582 consumer complaints on file.

#11774522October 29, 2026
STEERING
The contact owns a 2004 Chevrolet Malibu. The contact stated that while driving at 15 MPH, a whining noise was heard coming from the steering system when attempting to turn. The failure mileage was 133,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706192December 19, 2025
STEERING
Electric Power Steering has failed on my car. Warning shows up saying power steering. Live in a snowy deer populated area impossible to turn wheel in these situations to avoid a collision. There was no actual accident that occured but there more than likely could be.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651207March 27, 2025
STEERING
The steering system gets extremely sensitive towards highway speeds to where a slight touch of the steering wheel could cause the car to move a significant amount no warning lamps or messages
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11586159April 30, 2024
STEERING
The contact owns a 2004 Chevrolet Malibu. The contact stated that the power steering failure message was displayed on the instrument panel. The vehicle was taken to an independent mechanic where it was diagnosed however, there was no DTC code retrieved for the power steering failure. The local dealer was contacted, but the vehicle was not diagnosed or repaired due to costs. The contact linked the failure to NHTSA Campaign Number: 14V153000 (Steering) however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579145March 24, 2024
SERVICE BRAKES, VEHICLE SPEED CONTROL, AIR BAGS
The Grumman LLV was hit by the driver of the Chevy Malibu. The Grumman LLV had seatbelt issues with impact. The LLV was forced over on two wheels with left side impact from the driver of Chevy Malibu. [XXX] was the driver of the USPS Grumman LLV at the time of accident sustaining neck injuries requiring medical attention. Multiple medical procedures paid out of pocket followed to include surgeries The driver of Chevy Malibu was injured and received coverage by State Farm insurance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11545475September 19, 2023
STEERING
The contact's friend owns a 2004 Chevrolet Malibu. The contact stated that while his friend was driving at various speeds, the vehicle experienced a loss of power steering assist. The oil and theft warning lights were illuminated. The Service Power Steering message was displayed. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537946August 11, 2023
STEERING
On multiple occasions driving at slow speeds and parallel parking, the steering wheel locked and I was unable to turn the car. This has occurred numerous times and I am very concerned about my safety as this is extremely hazardous. I am aware that this, power steering failure, is a known issue. Please advise.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11523825May 25, 2023
AIR BAGS
The contact owns a 2004 Chevrolet Malibu Maxx. The contact stated that after he turned off and restarted the vehicle, the air bag warning light illuminated. The vehicle was taken to Bruce’s auto body shop where it was diagnosed that the air bag side impact sensor failed to reset and needed to be replaced. The vehicle was not repaired. The manufacturer was notified by the dealer and the contact was informed that the parts were no longer being manufactured and was unavailable. The failure mileage was approximately 164,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11521181May 9, 2023
STEERING
The contact owns a 2004 Chevrolet Malibu. The contact stated while driving 50 MPH, the vehicle experienced a loss of power steering assist. The contact related the failure to NHTSA Campaign Number: 14E044000 (Steering) however, the VIN was not included. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11520441May 4, 2023
VEHICLE SPEED CONTROL, STEERING
1. A known about the recall for the power steering to go out. This was repaired as a recall a in 2014. It was replaced at no charge. In the last year the same thing happened again. I was charged over $1400 for repair at the dealership. Why was this not covered as well. Same part. Same problem a second time. ? 2. Also, cruise control has gone out over a year ago. No one told me there was a recall. I did not get it fixed due to cost.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11510689March 7, 2023
STEERING
My 16 yr old was driving to school when the power steering stopped working. The vehicle was around 151,850 miles. The vehicle steering light came on, the vehicle was still drivable but was very difficult to turn. I’ve taken it to a GM verified dealership to get repaired. The recall that was on the vehicle shows completed 05/2014. The vehicle has never been repaired and I have pictures of the original parts that were replaced in case you need to verify part numbers and prove it has never been repaired. I would really like to be reimbursed as this was a recall that my vehicle was never repaired for.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503268January 23, 2023
STEERING
In March of 2015 recall for steering shift was done. The car is loosing power again when you are turning a corner it has happened several times. A powere steering code was on. A local shop looked at it and cleared it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498265December 20, 2022
STEERING
The contact owns a 2004 Chevrolet Malibu. The contact stated while reversing the power steering failed without warning. The vehicle was taken to the dealer and they stated the steering shaft needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and they stated that the vehicle was not under warranty. The failure mileage 139,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11469559June 16, 2022
STEERING
Driving along the power steering goes out. You have to pull over, turn engine off and on and ok until the next time. This was a recall that was fixed in 2014. It’s happening again. Happens everywhere. Slowly out to parking lot to highway speeds and everywhere in between. Exactly same when it happened in 2014. Recall 14116
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463018May 2, 2022
STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID
The contact owns a 2004 Chevrolet Malibu Maxx. The contact stated while driving approximately 30 MPH, the vehicle lost power steering functionality. The power steering warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed with power steering failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 117,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460088April 7, 2022
STEERING
The 2004 Chevy Malibu Maxx equipped with Electric Power Steering experienced a sudden loss of power steering assist. The power steering loss made it extremely difficult to control the direction of the car and can cause crash. The problem has been confirmed by the dealer after a $185 inspection to just read a code. The problem has been covered by recall Bulletin No. 14116. However, the recall DID NOT fix the problem and the exact problem showed up. Mike Maroone Chevrolet North and GM stated "when the recall is done it's done", although the problem was still there. A message was displayed on the Driver Information Center and a chime sounds to inform the driver. The Bulletin is https://static.nhtsa.gov/odi/rcl/2014/RCRIT-14V153-6084.pdf. There is also news on GM's website. https://media.gm.com/media/us/en/gm/home.detail.html/content/Pages/news/us/en/2014/mar/0331-power-steering.html
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456584March 14, 2022
STEERING
EPS went out, warning message for steering on message board. Cannot steer very easily. Have not taken to dealer due to not wanting to operate unnecessarily
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11436957October 15, 2021
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, STEERING
I was driving to work with my son and sister in the car when the steering wheel suddenly got very tight and started jerking when I attempted to make a left or right turn. I then stopped at a gas station and as soon as I came to a complete stop the vehicle shut off before I could turn it off manually. I then attempted to turn the key on and start the vehicle but it would not turn over, it would only make a clicking sound. I called a friend that was close by to come and assist me so when they arrived I asked them to jump my vehicle off via jumper cables which did get my vehicle's engine to finally start. The car sounded very weak as if it was going to shut off again once we disconnected the jumper cables but it didn't shut off. Nothing was working inside the car or outside meaning I had no radio, no interior lights and nothing on my dash was working. The speedometer wasn't working, the rims Guage wasn't working, the temp Guage wasn't working nor was anything else working on my dash. The turn signals were not working for either side and none of my headlights or taillights were working either. And I still did not safely have control of the steering. The only warning lamp, which didn't appear until my friend jumped my car off, was what looked like a symbol of a vehicle with a symbol of a locked lock in front of it. This failure just happened so I have not taken the car to a certified mechanic to inspect it but the car is available for inspection at any time. I can not afford to put my car in the shop, I work part time at a restaurant in my town and I'm also disabled and I also care for my 8 year old son who is severely autistic so I have no extra money to fix these problems. Please I need help.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11430503August 25, 2021
EXTERIOR LIGHTING:HEADLIGHTS:CONCEALMENT DEVICES
The contact owns a 2004 Chevrolet Malibu. The contact stated while the vehicle was parked and the engine running the contact noticed that their front driver and passenger headlight were very low in both low beam and high beam and that the light eventually burned out. The contact inspected the vehicle and saw that the light bulb sockets for both the front driver side and passenger had melted. The contact stated the cause of the failure is the wiring behind the headlight assembly that is causing the headlight socket to melt. The contact replaced the headlight bulb sockets themselves with aftermarket parts to repair the failure, however, the failure persisted and reoccurred. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11429981August 21, 2021
ELECTRICAL SYSTEM, STEERING
The power steering went out while driving. The car was being backed out of the driveway. The car had lights go off when it happened. Once the car was restarted power steering worked again. This problem has only occurred once as far as known. The steering was incredibly hard to move when the issue occurred. It is foreseeable that if issue happens at the wrong time on the freeway it could lead to injury or death of driver, passenger, or others outside the vehicle. If it happens at high speeds during a turn any number of serous damage or injuries could occur. The vehicle was taken to a mechanic who said a dealership would have the equipment properly diagnose the problem. If the mechanic did it himself he would have to replace several parts one a time and it might not be fixed. I will have my son take it to a dealership to look at it. Lights went off during the problem, but it is UNKNOWN which ones lit up. The lights went off, but since significant force had to be used to pull the wheel even slightly the exact lights that went off are unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Malibu