Chevrolet · Model Report
Showing safety data for the 1999 model year only.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH A BRAKE WARNING INDICATOR. SOME OF THESE VEHICLES HAVE A POWER STEERING COOLER HOSE THAT CAN SEPARATE FROM THE POWER BRAKE BOOSTER FLUID FLOW SWITCH ASSEMBLY.
AN ASE/AAA CERTIFIED MECHANIC INSTALLED A PASSENGER CAR RATED TIRE ON THE VEHICLE, INFLATED TO 36 PSI. THE PLATE ON THE VEHICLE IS FOR AN E RATED TIRE (LT245/75R16E 80 PSI). THE TIRES INSTALLED WERE DOT R88Y 25BR0418 (OHTSU P245/75R16). WHEN ORIGINALLY CHALLENGED, THE SHOP ATTEMPTED TO HAVE ME KEEP THE TIRE ON THE VEHICLE. AFTER COMPLAINING THROUGH AAA THE TIRE SHOP ACCEPTED RETURN ON THE TIRES. AS I WAS REQUIRED TO WAIT FOR SOME TIME TO GET THE ORIGINAL SHOP TO ACCEPT RETURN I WENT TO ANOTHER SHOP TO HAVE THE P TIRES REPLACED WITH LT E-RATE TIRES. AT ANOTHER SHOP (A NATION CHAIN RETAIL CENTER) I WAS OFFERED FOR SALE C-RATE TIRES. NOW THAT THE FORD EXPLORER / FIRESTONE RECALL IS NOW A FADING MEMORY, I AM CONCERNED THAT MULTIPLE TIRE SHOPS OFFERED FOR SALE UNDER RATED TIRES FOR MY VEHICLE.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1999 CHEVROLET EXPRESS 3500. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO FIVE DIFFERENT DEALERS. THE TECHNICIAN DIAGNOSED THAT THE CRANK SHAFT SENSOR, OXYGEN SENSOR, FUEL FILTER, DISTRIBUTOR, COIL SPARK PLUG WIRES, TIMING GEARING CHAIN, AND FUSES WERE FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED OVER FIVE TIMES, HOWEVER, THE FAILURE RECURRED EACH TIME. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1999 CHEVROLET EXPRESS G3500. THE CONTACT STATED THAT WHILE AT A COMPLETE STOP, THE BRAKE PEDAL SUDDENLY FAILED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DETERMINED THAT THE BRAKES LINE WERE CORRODED UP TO THE MASTER CYLINDER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 128,000.
No injuries · No fire · No crash
I OWN A 1999 CHEVROLET EXPRESS 1500 VAN WITH LESS THAN 50,000 MILES ON IT. I PURCHASED THE VAN NEW IN 1999. I NOW HAVE A PROBLEM WITH THE OIL PRESSURE GAUGE FALLING PAST 80 PSI ALL THE TIME. EVEN WHEN THE VAN IS NOT RUNNING. I HAVE TRIED TWO DIFFERENT CLUSTER WITH THE SAME RESULTS. I HAVE NOT CONFIDENCE THAT ANYONE AT GM KNOWS HOW TO FIX THIS ISSUE. NO RESOLUTION CAN BE FOUND. *TR
No injuries · No fire · No crash
WITHOUT WARNING ALL HEADLAMPS WENT OUT DRL,LOW BEAMS AND HIGH BEAMS. ALL OTHER LIGHTS WORKED OK. NOT FUN AT NIGHT TO HAVE OCCUR. *TR
No injuries · No fire · No crash