Chevrolet · Model Report
Showing safety data for the 2001 model year only.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE GEAR SHIFT WAS DIFFICULT TO MOVE AND THE LEVER BECAME STUCK. OCCASIONALLY, THE KEY BECAME STUCK IN THE IGNITION AND THE GEAR SHIFT WOULD NOT GO INTO GEAR. ALSO, THE HOOD WAS HOT, THE ENGINE OVERHEATED, AND THE VEHICLE EXPERIENCED ELECTRICAL FAILURES. THERE WERE ALSO MULTIPLE UNKNOWN WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT SCHEDULED A DIAGNOSTIC APPOINTMENT WITH AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 138,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. UPON EXITING THE VEHICLE AND CLOSING THE DOORS, THE INTERIOR DOME LIGHT REMAINED ILLUMINATED. THE CONTACT ALSO NOTICED A BURNING ODOR COMING FROM THE LIGHT BULB WIRING IN THE ROOF. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. *LN
IGNITION SWITCH AND THE IGNITION LOCK CYLINDER MALFUNCTIONED IN 2009, ROUGHLY FIVE YEARS AFTER GM'S RECALL. THE ORIGINAL OWNER OF THE VEHICLE TOOK ADVANTAGE OF THE IGNITION SWITCH'S SERVICE. IN ADDITION TO THE RECALL, GM INSTALLED AN IGNITION WIRING HARNESS. BACK IN 2009, THE VEHICLE'S IGNITION WOULD OVERTURN, AND THEN, THE ENGINE WOULD AUTOMATICALLY SHUT-OFF. TO REPAIR THE PROBLEM, BOTH THE IGNITION SWITCH AND LOCK CYLINDER WERE REPLACED AT A COST OF $492. IN 2014, THE IGNITION SWITCH MALFUNCTIONS. THIS TIME, IT APPEARS THE IGNITION LOCK CYLINDER TO BE WORKING PROPERLY. THE IGNITION SWITCH BECAME DAMAGE DUE TO CURRENT FLOW TO THE IGNITION WHEN HOLDING THE KEY IN THE START POSITION. THE HEAT MELTED THE INTERNAL SWITCH. I HAD NOT KNOWN IN 2014 THAT THE PROBLEM WAS THE IGNITION SWITCH. IN THE SAME YEAR, HOWEVER, GM RECALLED A MASSIVE NUMBER OF VEHICLES FOR IGNITION SWITCH DEFECT. CHEVROLET CAVALIER WAS NOT ON THE LIST. TODAY, IT COSTS $180.00, EXCLUDING TAXES AND FEES, TO GET THE IGNITION SWITCH INSTALLED BY A CHEVROLET TECHNICIAN. A LOCKSMITH RATE STARTS AT $90 BUT DOES NOT INCLUDE SERVICE FEE, AND LABOR. BASED ON FEW ONLINE REPORTS, THE INSTALLATION TAKES A MINIMUM OF 20 MINUTES. WOULD INSTALLED THE IGNITION SWITCH MYSELF BUT CANNOT LOCATE STEP BY STEP INSTRUCTIONS. ALL THE CHEVROLET MANUALS OWNED DO NOT PROVIDE INSTRUCTIONS ON REPLACING THE IGNITION SWITCH. IF I DO INSTALL THE IGNITION SWITCH, I AM UNSURE IF THE VEHICLE'S COMPUTER WILL NEED REPROGRAMMING. A FEW REPORTS MADE REFERENCE TO REPROGRAMMING THE VEHICLE'S COMPUTER FOLLOWING THE CHANGING OF THE IGNITION SWITCH. SOLUTION: I THINK GM NEEDS TO ADD CHEVROLET CAVALIER TO THE "RECALL" LIST. THE ALTERNATIVE, IGNITION WIRING HARNESS DOES NOT SUPPORT THE ELECTRICAL SYSTEM ENTIRELY WHEN THE CHARGING SYSTEM LIGHT REMAINS ON THE DASHBOARD.
No injuries · No fire · No crash
THE WHOLE FRONT DASH HAS MANY CRACKS IN IT AND APPEARS TO BE DANGER SINCE PIECES ARE FLYING OFF AS I DRIVE.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATLEY 35 MPH, AN UNUSUAL NOISE EMITTED FROM THE STEERING WHEEL AND THE ENTIRE INSTRUMENT PANEL ILLUMINATED. IN ADDITION, THE VEHICLE BEGAN TO JERK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TROUBLE CODE DETECTED A FAILURE WITHIN THE STEERING COLUMN. THE MECHANIC RESET THE STEERING COLUMN SENSOR; HOWEVER, THE FAILURE PERSISTED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08E063000 (STEERING). THE VEHICLE WAS NOT REPAIRED FOR A SECOND TIME. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
No injuries · No fire · No crash