Chevrolet Blazer Complaints (2020)

224 consumer complaints on file.

#11667096June 16, 2025
POWER TRAIN, ELECTRICAL SYSTEM
My vehicle has been throwing an error code related to the thermostat. The temperature gauge will remain on C resulting in the fan running loudly, the air conditioner not cooling the cabin of the vehicle well, and a message displaying "steering assist is reduced drive with care". When I check the fluid levels everything is fine without issue. I'm VERY frustrated and want to get rid of my Blazer ASAP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11667110June 16, 2025
POWER TRAIN, ELECTRICAL SYSTEM
The contact owns a 2020 Chevrolet Blazer. The contact stated upon shifting to park(P) and attempting to turn off the vehicle, the message that the transmission was not in park(P) was displayed. The contact stated that the failure recurred several times, and the vehicle responded as needed after several attempts. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 38,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666687June 13, 2025
POWER TRAIN
A few months ago had Blazer in for oil change. That same day check engine light came on. Was told thermostat needed to be replaced. Needed to order part. Check engine light went out then steering maybe reduced just a week ago eventually check engine light came on. Took to dealership and thermostat needed to be replaced also radiator developed a leak. Just over 60000 miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665308June 6, 2025
STEERING, ENGINE
The blazer's check engine light came on and I had it scanned. The code was PO128 indicating that the engine coolant temperature is consistently below the thermostat regulating temperature. We are also getting a message on the vehicle that states the steering assist is reduced, drive with care. The car is also blowing hot air when the AC is on, the temperature gauge is staying at the lowest setting and the fans are running full blast. This seems to be a very common problem with the Chevrolet Blazer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664630June 3, 2025
STEERING, ENGINE AND ENGINE COOLING
The contact owns a 2020 Chevrolet Blazer. The contact stated that while driving at an undisclosed speed, the steering wheel became inoperable. The contact stated that the steering wheel became difficult to turn with a reduced steering message displayed. The vehicle was taken to the dealer, where it was diagnosed that the thermostat had failed, which caused the steering wheel to fail, and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 54,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664003May 30, 2025
ENGINE
I have an oil leak and now they are saying both of my camshaft housing gaskets are leaking it's going to take weeks to repair cause it's such a major leak
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663671May 29, 2025
STEERING, ENGINE
Vehicle gives warning that steering assist is disabled. I should drive carefully. Also cooling fans run on high and temp gauge reads zero. P0128 I'd code given by computer. When code is cleared vehicle returns to normal operation. I read many, many people have this same problem with no clear correction. Many have replaced thermostat, temp sensors, and problem returns. Sounds like defective wiring to me and if it impacts steering should be an OEM problem to remedy
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662418May 21, 2025
POWER TRAIN
When car is parked and shifted to Park massage is sent put car in Park.was a shifter problem dealer fix for 463.00.58000 mi. 2020 Blazer
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662076May 20, 2025
POWER TRAIN, STEERING
The contact owns a 2020 Chevrolet Blazer. The contact stated that the transmission was slipping while driving in the lower gears. The contact stated that the message “Reduced Steering - Drive with Caution” was displayed. The vehicle was taken to the dealer but was not diagnosed or repaired. The contact stated that the failure persisted, and the vehicle became inoperable. The manufacturer was informed of the failure and opened a case. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662080May 20, 2025
AIR BAGS
The contact owns a 2020 Chevrolet Blazer. The contact stated that while driving at approximately 65 MPH when a semi-truck crashed into the rear of the vehicle on the driver's side of the vehicle. The vehicle began to spin, causing it to go into the lane the semi-truck was in, and it was hit on the driver's side of the vehicle several times. The vehicle ended up crashing into the median and coming to a stop. The air bags did not deploy. The contact received neck injuries, spinal injuries, headaches, consistent ringing of the ears, shoulder injuries, and hip injuries. Medical attention was needed. A police report was filed. The vehicle was towed and taken to the dealer, who repaired the driver's side doors, tires, rims, and other parts of the body of the vehicle that the contact was unable to identify. The air bag failure was not diagnosed or repaired. The manufacturer was made aware of the failure and opened a case. The failure mileage was approximately 72,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11662171May 20, 2025
ELECTRICAL SYSTEM
when you put your Blazer in Park you get the warning light and chime to 'shift it into park'. So far it has happened to me 5 or 6 times in the past couple days. I can jiggle the shifter handle to get the chime to stop but it has me concerned. I have seen numerous posts about this same problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662174May 20, 2025
ELECTRICAL SYSTEM
I started receiving the message “steering assist reduced, drive with care” although I’ve noticed no reduction in power steering. This has happened multiple times. The A/C stops working, the Temperature Gauge moves to 0 degrees and the engine fan goes to maximum speed. I have noted that this is a common issue with the Blazer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662176May 20, 2025
ELECTRICAL SYSTEM
Almost every time I start the car up it asks me if the vehicle is a Demo. I will sign in as a user and identify the vehicle and keys, but it seems to lose some of the information when it is turned off. It has happened hundreds of times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661541May 16, 2025
POWER TRAIN
The contact owns a 2020 Chevrolet Blazer. The contact stated that while attempting to park the vehicle, the shift lever became inoperable. The contact stated that the shift into park message was displayed. The vehicle was taken to the dealer, where it was diagnosed and determined that the shift assembly had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 20,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661250May 15, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2020 Chevrolet Blazer. The contact stated while driving at approximately 55 MPH and driving up an incline in the road, the check engine warning light had illuminated. The contact stated that the vehicle was shuddering. The contact stated that the failure only occurred while driving uphill. The contact had only recently taken the vehicle to a local dealer because the check engine warning light was illuminated. The vehicle was diagnosed, and the dealer determined that the thermostat and the engine control sensor needed to be replaced. The vehicle was repaired. The contact stated that approximately 1,800 miles after the first repair, the check engine warning was illuminated again. The vehicle was taken back to the same dealer. The vehicle was diagnosed, and it was determined that the air flow shutters had been damaged and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and had referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 97,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11660419May 12, 2025
ENGINE, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
To Whom It May Concern, I am writing to formally file a complaint regarding ongoing and persistent issues with my 2020 Chevrolet Blazer. The vehicle has exhibited repeated problems that I believe may indicate a broader safety or mechanical defect, and I am requesting that the NHTSA investigate these concerns further. Since purchasing the vehicle, I have experienced the check engine light turning on and off repeatedly, without consistent resolution. The following issues have occurred over time, all seemingly related to the engine or control systems: Engine Cooling System Failure: The first major issue involved the engine cooling system. This caused the vehicle to overheat and required service. I was concerned about the potential for engine damage or fire risk due to excessive heat. Variable Valve Timing (VVT) System Malfunction: Shortly after the cooling system issue, the vehicle began experiencing problems with the variable valve timing system. This not only affected performance and fuel efficiency but also caused the check engine light to illuminate again. Steering Control Assist Sensor Warnings: Most recently, the steering control assist sensor has started to malfunction, with warnings frequently popping up on the dashboard. This has impacted steering feel and raises serious safety concerns. Despite multiple service appointments and repairs, these problems persist or reappear. This cycle of temporary fixes without a lasting resolution is both frustrating and concerning from a safety standpoint. I am requesting that the NHTSA look into whether these recurring engine and control system issues are part of a known defect or recall-worthy problem affecting the 2020 Chevy Blazer. Thank you for your attention to this matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659872May 9, 2025
ENGINE
Car gets “assisted steering is turned off. Drive with caution.” Warning, temperature gauge in vehicle remains at zero/cold. Engine fan runs at full blast. Sensor gauge/thermostat is broken.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659678May 8, 2025
POWER TRAIN
The thermostat is getting stuck open and giving me a reduced steering assist error. My safety was put at risk because of the steering assist being reduced. The problem has not been reproduced but there are many issues online about the same model, year, and mileage all having the same issue. The component is going to be inspected by a service manufacturer. There were no warning lamps prior to error.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659624May 7, 2025
ENGINE, LANE DEPARTURE: BLIND SPOT DETECTION
Ongoing Engine and Steering Sensor Issues – 2020 Chevrolet Blazer I am filing a complaint regarding repeated safety and mechanical issues with my 2020 Chevrolet Blazer. The vehicle’s check engine light frequently turns on and off, and I have been informed by technicians that it is related to the thermostat system. This issue negatively affects the vehicle’s performance and reliability. Additionally, the “Steering Assist is Reduced – Drive with Care” warning continues to appear while driving, even when weather and road conditions are normal. This error is reportedly due to a steering control assist sensor, and it raises serious concerns about the safety and handling of the vehicle. The alert causes uncertainty and could potentially impact the power steering functionality, creating a hazardous driving situation. These issues have occurred multiple times despite maintenance, and they appear to be part of a broader pattern of defects affecting other owners of this model year. It is unacceptable for a vehicle this new to have persistent problems that affect both engine operation and steering safety. I urge the NHTSA to investigate these recurring issues with the 2020 Chevy Blazer’s thermostat system and steering assist sensor to determine whether a recall or manufacturer intervention is warranted. Safety should not be compromised due to what seems to be systemic defects. Thank you for your attention to this matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659014May 5, 2025
POWER TRAIN, ENGINE, VEHICLE SPEED CONTROL
What component or system failed or malfunctioned, and is it available for inspection upon request? Multiple components in the engine timing and transmission system have failed. These include: Camshaft actuator solenoid valve failed twice (at ~30,000 and ~60,000 miles), each time with different DTC codes. Camshaft positioning sensor failed, triggering P0024 (“timing advanced and bouncing around”). Timing chain tensioner spring failed, requiring re-timing. Camshaft carrier case gasket experienced a major oil leak at 59,000 miles. Thermostat failed. Battery was replaced, but no diagnostic testing was performed—only code clearing. At 82,000 miles: Torque converter has failed, transmission fluid is tarnished, and the radiator is leaking internally. Yes, the vehicle is available for inspection upon request and has been registered as non-operational. How was your safety or the safety of others put at risk? The vehicle exhibited repeated hesitation, delays when accelerating, and revving while braking. In stop-and-go traffic, it now sputters as if it may stall. These behaviors create unsafe driving conditions, especially at intersections and in congested areas, putting both myself and other drivers at risk. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The torque converter failure and transmission issues were confirmed by National Transmission in Long Beach, CA. Prior component failures were confirmed by Martin Chevrolet, who performed both camshaft actuator solenoid valve replacements under warranty. Multiple DTC codes were recorded and cleared, but no electrical testing was performed. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been serviced by authorized GM dealerships, but GM did not escalate the issue to their TAC (Technical Assistance Center) or assign a field engineer, in violation of GM's internal escalation policy. No inspections
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Blazer