BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
The contact owns a 2010 BMW 335I. The vehicle was a custom-modified vehicle and a company mascot. The contact received notification of NHTSA Campaign Number: 17V676000 (Electrical System); however, the vehicle was not repaired. The contact self-identified as an independent mechanic who wanted to be present when recall repair was performed; however, the contact preferred to have the recall disassociated with the VIN and to perform the recall repair himself. The local dealer was contacted and declined the contact to be present during the recall remedy process. The manufacturer was contacted, but the contact was advised that the request was denied. In addition, the contact was not advised on the recall reimbursement process. The contact wished to perform the recall repair himself and be granted reimbursement. The contact had not experienced a failure.
No injuries · No fire · No crash
Good Morning Folks, I own a 2010 BMW 335i sedan with approximately 110k miles and I will have to be replacing AGAIN, the valve cover gaskets in the car. The first time I had to replace the VCGs was back in 2016 and the vehicle barely had 50k miles on it. Had to replace the VCGs again in 2020. Milage was approximately 92k miles. Fast forward to today and once again, the VCG are leaking. This is an obvious manufacturer defect and I would request that the NHTSA look into to this reoccurring problem with BMW North America. The replacement cost of the VCGs on these vehicles is costly and because it is happening so frequently, BMW should not only be required to cover the cost of replacement but should also be required to remedy the problem permanently. The leakage could lead to possible ignition and a fire within the engine compartment. Thank you for your attention to this matter. [XXX] Grovetown, Ga 2010 BMW 335i owner [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
The contact owns a 2010 BMW 335I. The contact stated while driving 45 MPH, the vehicle went into LIMP Mode, and the check engine warning light illuminated. The vehicle was not taken to a dealer or an independent mechanic. The vehicle was self-diagnosed, and the contact stated that the camshaft timing bolts needed to be replaced. The vehicle was repaired by the contact. The contact related the failure to NHTSA Campaign Number: 23V707000 (ENGINE AND ENGINE COOLING); however, the VIN was not included in the recall. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was 150,000.
No injuries · No fire · No crash
RECALL 17V-676: BLOWER MOTOR WIRING was preformed several years ago. Today the wiring connection added during the recall work failed and the blower motor stopped working.
No injuries · No fire · No crash
The engine stalled multiple times driving on the highway. When I turn off the car and turn on the car, it would go back to normal. I researched this is a problem for 335d, I think im experiencing the same problem, not sure why 335i is not included in the recall list. This happened multiple times for me and I ignored it at that time, other person has also experienced the same issue when he was driving my car. Now the electrical battery power is completely shut off and there is no recall, this really bothers me.
No injuries · No fire · No crash