Audi · Model Report
Showing safety data for the 2001 model year only.
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
FUEL AND FUEL VAPOR LEAKS FROM THE TOP OF THE FUEL TANK PRESENTING A SERIOUS FIRE HAZARD WHEN MOVING (SLOWLY OR AT HIGHWAY SPEEDS) OR STATIONARY. THE FUEL LEAK IS MOST OBVIOUS WHEN THE TANK IS MORE THAN 1/2 FULL. VAPOR EMISSIONS OCCUR AT ALL TIMES RESULTING IN A FAILURE TO MEET EMISSIONS STANDARDS. A HARD PLASTIC MATERIAL IS USED FOR THE FUEL TANK'S VENT. IT IS CONNECTED TO A RIGID ALUMINUM VENT LINE. RELATIVE MOVEMENT AND AGING HAS RESULTED IN A FAILURE OF THE PLASTIC VENT. AUDI'S RECALL FIX FROM 2008 (NHTSA 08V-157) - I.E., INSTALLING AN EPOXY-FILLED MOLD - HAS NOT PREVENTED FAILURE OF THE PLASTIC VENT. SINCE THE PLASTIC VENT IS 'WELDED' TO THE TOP OF THE HDPE TANK, THE ENTIRE TANK MUST BE REPLACED TO ADDRESS THE FAILED VENT.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 AUDI ALLROAD. WHEN FILLING THE FUEL TANK, THE CONTACT NOTICED THAT THE TANK LEAKED FUEL. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V157000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,800.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 AUDI ALLROAD. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER AND IT WAS DETERMINED THAT THE REINFORCEMENT NIPPLE TO THE ROLLOVER ON THE FUEL TANK FAILED. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V157000 (FUEL SYSTEM) AND WOULD NOT BE REPAIRED UNDER THE RECALL. THE FAILURE MILEAGE WAS UNKNOWN.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 AUDI ALLROAD QUATTRO. WHILE DRIVING APPROXIMATELY 30 MPH, THE FRONT DRIVER SIDE AIR SUSPENSION SYSTEM FAILED WITHOUT WARNING CAUSING THE VEHICLE TO COLLAPSE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO AN AUTHORIZED DEALER WHERE THEY INFORMED HIM THAT THERE WAS A LEAK IN THE AIR SUSPENSION AIR BAG. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE AIR BAG SUSPENSION WERE PREVIOUSLY REPLACED IN 2005 AND 2006. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.
No injuries · No fire · No crash
AIRBAG LIGHT ON AND CONTROL MODULE NEEDS REPLACING. *TR
No injuries · No fire · No crash