Audi A3 Complaints

905 consumer complaints on file.

#11690869October 1, 2025
FUEL/PROPULSION SYSTEM
FUEL LEAKED ALL MY GARAGE ALMOST CAUSING A FIRE IN MY HOME WHILE I WAS SLEEPING. I HAVE HAD THE FUEL TANK REPLACED 3 TIMES. AND I HAD TO PAY OUT OF POCKET TO HAVE IT REPLACED BECAUSE AUDI WOULD NOT REPLACE THE RECALL OF IT SO I AM REACHING OUT TO YOU SO YOU CAN REACH OUT TO AUDI ABOUT NOT STANDING BY THE RECALL PROCEDURE!
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11689623September 25, 2025
FUEL/PROPULSION SYSTEM, SEATS
Subject: Complaint regarding refusal to perform recall repairs outside the U.S. – VIN [XXX] Dear NHTSA Office of Defects Investigation, I am the owner of an Audi A3, model year 2015, VIN [XXX] . According to the NHTSA database, my vehicle is subject to two open recall campaigns: – 69BY / 21V198 – Passenger Occupant Detection System (PODS) – 20YF / 24V110 – EVAP Suction Pump I currently reside in Ukraine, where the vehicle has been legally imported and registered. Despite the recalls being active and safety-related, the official Audi importer and dealers in Ukraine have refused to perform the repairs free of charge. They argue that these recalls apply only to the U.S. market and therefore decline service, which contradicts the global principle of mandatory recall repairs. This situation puts me and other drivers at risk, as the unresolved recall issues directly affect vehicle safety. I kindly ask NHTSA to review this case and provide guidance on ensuring that recall obligations are respected internationally, or to instruct Audi AG / Audi of America to facilitate the execution of these recalls regardless of the vehicle’s current market. Attached, please find copies of my correspondence with Audi dealers in Ukraine and Audi of America. Thank you for your assistance. Best regards, [XXX] Ukraine Phone: [XXX] Email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689751September 25, 2025
ELECTRICAL SYSTEM
My 2016 Audi A3 Sportsback E-tron vehicle was parked at my house. When I went to start it the engine did nothing, no power. The message “Driver System Fault” and a red triangle with a red ! in the middle was displayed on the instrument panel. I was unable to start or operate the vehicle. I called AAA and they towed the vehicle to a Recharge Hybrid pump location near my house. I tired to charge the battery and it would just turn off. Then I called AAA again and they towed my car back to my house and checked the small 12 volt battery to see if that was the problem, they determined that the 12 volt battery still had 75% life in it. They were unable to get my vehicle started. The same message is still on the dashboard “Driver System Fault." The failure mileage is approximately 81,567. I want to know before I call the Dealer and get it towed again if this issue is the Hybrid High-Voltage Battery or the housing bonded seam could have lead to corrosion the service recall from a while ago. Service Action Code 93D2
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688724September 21, 2025
TIRES, TIRES:SIDEWALL
225/45-R18 DOT(17/22) On September 6, 2025, I purchased a 2018 Audi A3 (VIN [VIN], 56,634 miles) delivered by Carvana. Within days, I had the vehicle inspected at multiple independent repair shops. Each shop documented that all four tires showed dry rot and cracking and advised immediate replacement due to risk of tire failure. On September 10, 2025, I contacted Carvana and followed their warranty claim process. After escalation, on September 18, 2025, I was informed that Carvana determined “the tires are not bad enough” and denied replacement. The vehicle was delivered with unsafe tires that pose a serious risk of blowout or loss of vehicle control, endangering both the driver and others on the road. DOT date codes and photos of the cracks confirm the condition of the tires at the time of delivery. This complaint is being filed so NHTSA is aware of the issue and to request investigation into Carvana’s sale of vehicles with dry-rotted, unsafe tires.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11686827September 12, 2025
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The contact owns a 2016 Audi A3. The contact stated that while the vehicle was parked with the engine running, the vehicle experienced a sudden loss of motive power. During the failure, the message “Driver System Fault” was displayed on the instrument panel. The contact was unable to restart or operate the vehicle. The vehicle was towed to the dealer, where it was diagnosed and determined that the Hybrid battery had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 83,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11686190September 10, 2025
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, UNKNOWN OR OTHER
1) Electronic emergency brake goes on repeatedly when attempting to put vehicle in gear. 2) Speed control has coasted to a very low speed while on the highway several times, on its own with no vehicles in front of me. 3) Numerous other “glitchy” electrical issues exist. Dealer says they are collaborating with engineers in Germany. There is currently no fix. It is as if the vehicle is always cycling through various “glitches”.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11683973August 29, 2025
AIR BAGS
Passenger airbag not activated when passenger is seated
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11680876August 15, 2025
AIR BAGS
Passenger Occupancy Detection System is malfunctioning. Pre-sense system fault
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11680457August 13, 2025
ELECTRICAL SYSTEM, POWER TRAIN
My 2015 Audi A3 1.8T is experiencing the exact same failure symptoms and operational hazards as those described in Audi’s own Warranty Extension U49, which covers certain 2017 and 2018 Audi A3 and A3 Cabriolet 2.0 TFSI models. According to Audi’s bulletin, vehicles with faulty mechatronic units are eligible for replacement under an extended warranty due to safety concerns — sudden loss of drive, vehicle being stuck in neutral, and PRNDS flashing while in traffic. My vehicle is now exhibiting these identical symptoms: (1) Sudden disengagement of all gears while driving when it tries to go to fourth gear. At this point, there is a (2) flashing PRNDS indicator and “Reverse Gear Not Available” message. (3) Loss of ability to accelerate in moving traffic, requiring emergency maneuvers, and halting traffic. (4) Temporary restoration of function after shutting off and restarting the engine, only for the problem to happen again. (5) Check Engine Light. This is a serious safety hazard that puts both the driver and other road users at risk. The only reason my vehicle is excluded from the coverage appears to be its model year (2015), despite the fact that the mechatronic unit and failure mode are identical to the covered 2017–2018 vehicles. I believe Audi overlooked this issue in other year models and, as such, I respectfully request that the NHTSA investigate why Audi is limiting this safety-related repair to only certain VIN ranges and model years, when vehicles just a couple of years older are exhibiting the exact same dangerous defect. A sudden loss of propulsion at highway speeds is a serious risk that warrants broader manufacturer accountability. The company should fix this issue as soon as possible.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679093August 7, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2015 Audi A3. The contact stated while driving at an undisclosed speed, several unknown warning lights illuminated and the engine overheated. There was an abnormal sound coming from the transmission. Additionally, the vehicle was consuming abnormal amounts of coolant without signs of a coolant leak. The contact stated that the engine seized. The coolant reservoir was inspected and there was no coolant in the reservoir. While attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact recently replaced the coolant pump, coolant control valve and the expansion tank. The manufacturer was made aware of the failure. The contact referenced NHTSA Campaign Number: 16V619000 (Engine and Engine Cooling); however, the VIN, nor the model were included. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 122,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676430July 27, 2025
STRUCTURE:BODY
The plastic roof trim panel on my 2015 Audi A3 is peeling and deteriorating significantly. This is not painted metal—it’s a separate, non-paintable plastic component that runs along the sunroof and roofline. The surface began flaking and lifting over time, and multiple independent body shops confirmed the panel is failing structurally and cannot be refinished—it must be replaced. While this may appear cosmetic, it’s not. The panel helps protect the roof seam and substructure. Its failure opens the door to water intrusion, corrosion, and potential roof integrity compromise—a serious safety concern, particularly in the event of a rollover or high-impact collision. Other owners of vehicles built on the same MQB/8V platform—including the VW Golf and SEAT Leon (not sold in the U.S., but structurally similar)—have reported identical issues, often followed by cracking or detachment of the panel. Despite multiple attempts to resolve this, Audi of America has been largely uncooperative. Their warranty process requires a diagnosis from a dealership, but most Audi dealers do not perform bodywork and refer customers to third-party shops—whose assessments Audi then refuses to accept. I’ve been left in a loop with no meaningful support, despite the issue being widespread and well-documented. I believe this is a design or materials defect that should be reviewed before it leads to broader safety or structural failures. See the below URL's for similar issues. [XXX] [XXX] [XXX] [XXX] [XXX] [XXX] [XXX] Excuse the shortened URL's, I need to meet your character count. I also cannot seem to upload images (despite being under the file size). I can email them later. I do find it interesting how all the affected cars seem to be blue (or at least darker in color). Perhaps excess heat is causing the issue? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675534July 23, 2025
ENGINE, FUEL/PROPULSION SYSTEM
Hello, I dropped my car off at Audi and Dominion in San Antonio Texas on Thursday July 10th for a repair this was a recall for the fuel pump system in something in the mechatronic controls. They had my car until Saturday I was informed that the repairs were done under warranty. Then on Saturday July 19th as I began to drive the vehicle a alert for my transmission malfunction appeared on my dashboard and I Lost first gear. I had my car taken to Audi on Dominion where I was informed by several service staff that this is a common malfunction after the last software update that was done the week prior and that it could take up to 48 hours to do the repair and recall warranty work on my vehicle. Audi on Dominion has had my vehicle for 5 days and has not given me an answer as to know whether or not the repairs will be approved as this is covered under my extended warranty. My car was working perfectly fine until I was forced to take it in for this recall of which Audi has failed to provide a loaner vehicle or give accurate information as to whether or not the repairs will be covered. I have been informed that I will be responsible for the cost of the repairs. These repairs are only brought upon due to Audis forcing me to bring the car in for the recall repair as it would have voided out the rest of my vehicles warranty. As of today I am still without a vehicle and without an answer from Audi. I have tried reaching out to Audi of America without any response.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674377July 17, 2025
UNKNOWN OR OTHER
The rearview camera is failed. Yes I can have an inspection done. Yes, dealer confirmed that camera is failed but wanted hundreds of dollars to troubleshoot. Has not been inspected by police or insurance. No it just stopped working one day.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669583June 26, 2025
TIRES:SIDEWALL
Tire Brand: Continental Tire Line / Model: ProContact TX Tire Size: 225/40R18 What Happened: This is the second tire failure I’ve experienced on Continental ProContact TX tires (OEM on my 2020 Audi A3 S Line). At only 13,000 total miles, I’ve had two separate instances of sidewall bubbles on different tires. •The first occurred in 2022 at just under 7,000 miles and caused the vehicle to fail PA state inspection. Continental covered 50% of the replacement cost after I submitted a warranty claim. •The second bubble appeared in June 2025 on the front passenger tire. At that point, I replaced all four tires out of safety concerns and disposed of the Continentals. The vehicle is in excellent condition, lightly driven, and is not exposed to potholes, curbs, or harsh use. I work remotely, so mileage is extremely low. Both tire failures were from normal road use and developed without any impact or external damage. I contacted Continental again in June 2025 with a full explanation and referenced my prior case. They refused to offer any goodwill or further investigation, stating that I had already disposed of the tires. ⸻ Why This Matters: Experiencing two identical sidewall failures within 13,000 miles on different tires under light driving conditions suggests a potential design or manufacturing defect. I’m reporting this in the interest of safety and awareness, as a sidewall failure at highway speed could be far more dangerous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668621June 23, 2025
AIR BAGS, ELECTRICAL SYSTEM
Audi had a recall on my 2018 A3 for a Passenger Occupant Detection System. in July 2023, Audi replaced the PODS Sensor mat. Recently, the same car has encountered the same issue. The PODS light indicates the airbag is off even if a passenger is sitting in the seat. There has been not repair work since July 2023, that would impact the PODS. And the warning lights reappeared after a period of normalcy. I feel this is an incomplete recall remedy and Audi is now wanting to charge me for the repair
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668082June 20, 2025
FUEL/PROPULSION SYSTEM
My 2018 Audi A3 began having fuel-related issues after receiving the recall service for campaign 20YF (Suction Jet Pump Seal) at an authorized Audi dealership. I first took the vehicle to an independent mechanic, because the check engine light came on, and there was a strong fuel smell. Most concerning, fuel leaked heavily from the front part of the engine, posing an extreme fire risk. who performed a diagnostic and found the following faults: Cold start fuel pressure performance fault Fuel rail/system pressure too low Fuel rail pump control valve stuck open Injector 4 leaking fuel The mechanic replaced injector 4 and installed new seals. However, the fuel leak continued, so I decided to take the car back to the Audi dealership, since they had previously performed recall work on the vehicle. I was concerned that the fuel leak might be related to the recall. The dealership told me the issue was not related to the recall and required a new in-depth diagnostic, which I would have to pay for. I accepted, and they charged me $876 for a deeper inspection. After their diagnosis, they said the only issue was that the previous mechanic had installed the seals incorrectly. They replaced the seals again and charged me for the repair. When I picked up the vehicle, the check engine light was still on. I immediately reported it to the dealership, and they asked me to return the car, saying the light should not be on. Once I brought it back, they told me it was now a new issue unrelated to their work, and that I would need to pay for another diagnostic. I believe this ongoing problem is directly related to the fuel system recall or to the dealership’s repair, and I feel that I am being charged repeatedly for an issue that was never fully resolved. Despite my efforts to follow Audi’s process, I am being held financially responsible for what I believe is a safety-related failure that began after the recall was performed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666478June 12, 2025
VISIBILITY/WIPER
The rear wiper hose is consistently getting completely clogged so that no fluid comes out when the spray mechanism is engaged. The dealership has replaced it for a fee two or three times. At the last service they told us they cleaned it and did not charge a fee. However, within two months it was clogged again. I have noticed that the issue is more likely to occur after (intentionally or accidentally) using the rear window defroster. I am therefore wondering whether the hose is made of a plastic that is too soft, causing it to change shape as a response to the defroster heat.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666282June 11, 2025
AIR BAGS
For recall 21V198-69BY, I took my car to Audi of Birmingham on recall. They provided me a service form to show the repair had been made, but my passenger side air bag off light is still on because they didn't make the repair. It wasn't brought to my attention until I took my car for another repair job and the didn't make that repair, either.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662230May 20, 2025
POWER TRAIN, ENGINE
I was driving on the freeway at 60 mph when I received a warning code of a transmission problem. The code said the car was driveable but I should take it in for service. About 1-2 minutes after that the car lost all power. Unfortunately I broke down in the left lane in a construction zone without a shoulder. The state patrol had to temporarily shut down all three lanes of the highway to push me out of the traffic lane I was blocking. That was unsafe for me and for the state patrol and for the tow truck driver. The car was up to date on all recommended service, had been acting normally until the moment it failed, had not given me any warnings and is only 6 years old. I had the car towed to the dealer and the dealer reported that the Mechatronic unit (transmission computer) failed. Replacing the Mechatronic took a week and cost $5000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11654220April 12, 2025
POWER TRAIN
Car has 50,000 miles and vehicle has a bulletin on the vehicle from Audi, where the vehicle goes into limp mode and only shift through certain gears, rendering the vehicle, unable to drive and creating a safety hazard due to the fact that it can’t drive at Highway speed and or jolt and skips gears. Code for the P173600 known issue by Audi, went into mode while merging onto freeway and a lost control of vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Audi A3