Volvo S90 Complaints (2018)

16 consumer complaints on file.

#11754063July 31, 2026
AIR BAGS, ELECTRICAL SYSTEM
Volvo is aware of a major safety issue that has to do with the drain hose of AC. They have issued a recall on models 2016 and 2017 and produced replacement parts.My car was purchased in 2017, but is a 2018. I have had the AC hose leak into my passenger compartment and cause my filter behind my glove box to be soaking wet. This has also damaged my speaker in my passenger door. I have paid over two thousand dollars.Trying to get this a c fixed with no results before finding out about the recalls. I have since found out.This leakage can prevent the passenger airbag from deploying in an accident. I have reached out to volvo directly they are denying any responsibility. I not only can not afford what could end up being over 5,000 dollars if not more to repair the AC the speaker and potentially the airbag as I am disabled. Although volvo is refusing to do the right thing, even though they know this is a problem. I have asked them what changes were made between 2016 to 2018 in the production of my vehicle. They are not responding.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735364May 3, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS, BACK OVER PREVENTION: WARNINGS
ISSUE 1 – VOLVO ON CALL / VCM "SERVICE REQUIRED" MESSAGE: My vehicle has displayed a persistent "Volvo On Call Service Required" error message in the Driver Information Module (DIM) for over one year. This is directly covered by: • Volvo Technical Journal TJ 36916.1.0 (NHTSA ID: MC-10253788), issued April 2024 • Fault code: VCM-U105000 (Vehicle Communication Module) • TSB explicitly covers 2018 S90 vehicles • The TSB states the required software packages are free of charge I contacted Volvo Cars USA at [XXX] , who acknowledged the issue and arranged a complimentary diagnostic and fix with the Manasquan dealer. But, the dealer would not perform the diagnostic at no charge, leaving me unable to confirm the fault code or proceed with the TSB-specified remedy without paying out of pocket. I have had this unresolved warning message for over one year now. The dealer told me that if I did not pay for the repair my car could lose power and stop suddenly. ISSUE 2 – PARK ASSIST SYSTEM FALSE ALERTS: My Park Assist System sensors generate false proximity warnings for objects more than 20 feet away — far beyond the system's normal detection range. Cleaning the sensors did not resolve the issue. This is directly covered by: • Volvo Technical Journal TJ 31558.8.0 (NHTSA ID: 10161789), issued April 2019 • Root cause: Water ingress into park assist sensors and connectors due to a defective splice in the cable harness • Volvo introduced a harness splice correction in production starting June 2018 — meaning vehicles built before that correction may contain the defective harness • TSB covers 2016–2019 Volvo vehicles A malfunctioning park assist system is a direct safety concern — drivers rely on accurate proximity alerts when maneuvering, and persistent false alerts undermine confidence in the system and may cause drivers to disregard genuine warnings. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717421February 11, 2026
WHEELS
There is a great deal of vibration at highway speeds. It has been like this since I purchased the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692511October 10, 2025
UNKNOWN OR OTHER
The AC system releases refrigerant into the cabin due to Volvo improperly engineering the climate control and allowing the evaporator core to freeze and crack. They acknowledge the issue and have released a resister cable to prevent the evaporator core from cracking. I have tested the air in the cabin, and the VOC level is at a dangerous level due to the refrigerant leak. I have the car currently at a dealer, where they have quoted over $3,800 to repair the issue. A quick search shows a large and quickly growing number of people complaining about this. The leaks in some cases are so bad that you can smell the refrigerant when you open the car door, as was the case with ours. This is a huge environmental and health safety issue. I have reached out to Volvo, and they refuse to assist with the repair, despite acknowledging that it is an engineering error. I don't feel safe having my kids be exposed to that level of refrigerant gas, and we don't know what to do with the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647854March 12, 2025
LATCHES/LOCKS/LINKAGES:DOORS:LATCH, LATCHES/LOCKS/LINKAGES:DOORS:LOCK
Rear right door lock failed, stuck closed. Extremely unsafe if someone was sitting in the back and unable to leave vehicle. It has been confirmed by others. It has been inspected by an independent mechanic. There has been zero warning lights to indicate the issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11643791February 19, 2025
ELECTRICAL SYSTEM
At 5pm while driving home, which was 2 hours away, I needed to stop and refuel. At the pump I pushed the fuel door and it would not release to open. After many tries it would not open. I called Volvo On Call and informed them of the problem. The agent relayed that I should go to the back of the car near the fuel door, and with the remote lock and unlock the door which should release the door. It did not work. I tried it again with no success. The agent then informed me that there is no other way to open the door and to go to a Volvo dealership to get repaired. I asked the agent is there a way to open the door from the trunk, for instance like a rope to pull to manually open the door. He said unfortunately no. So, I am no where near a dealership and if I was it would be closed, it is after 5pm on February 17 and its 20 degrees outside and I need fuel to get home. I get in my car and search the internet on a possible way to open the door and I see that this is a big problem with Volvo that has affected many families and individuals that, as I, have been put in a compromised possibly dangerous position. While at the gas station I fortunately saw a tow truck and asked the driver if I could borrow a screw driver to try to pry open the door to which I was successful. A simple pull cord in the trunk, as some vehicles have, would have solved this issue without putting anyone in a precarious situation. I took my car to a mechanic and he replaced the fuel door lock solenoid.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11573556February 23, 2024
ELECTRICAL SYSTEM, LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The rear door will not open from the inside or the outside. Apparently this is a door lock actuator issue experinced by many volvo owners. It is extremely dangerous not to be able to open a rear door in the case of an accident or other incident where you need to enter or exit the car. Dealer confirms that there is an issue with these. No warning message appears when inoperable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11551417October 23, 2023
TIRES:SIDEWALL, TIRES:TREAD/BELT
255/35 R20 Bleb in sidewall with air leak through tread adjacent. No unusual trauma to tire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11490684October 24, 2022
UNKNOWN OR OTHER, SEATS
water get inside the car in the back on the floor mat behind driver seat. was not aware of this problem at all.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11469647June 16, 2022
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
The contact owns a 2018 Volvo S90. The contact stated that upon the depression of the brake pedal, the steering wheel would violently shake without warning. The contact has had two sets of brake rotors replaced on the vehicle due to the failure. Since owning the vehicle, the contact stated that the failure would occur approximately every 8,000-10,000 miles. After the third failure, the contact was informed that the repair for the rotors would not be covered under warranty. The contact was provided an estimate for the repair. The manufacturer was notified of the failure and filed a claim; the contact was called back and was informed that the claim was denied. The vehicle had been repaired. The failure mileage was approximately 47,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463882May 9, 2022
ELECTRICAL SYSTEM
The contact owns a 2018 Volvo S90. The contact stated that the Vehicle Connectivity Module (VCM) had an error causing the Telematics and Driver Support Systems to function improperly. The contact stated the "Volvo on Call Service Required" warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the software installed in the Vehicle Connectivity Module (VCM) needed to be updated. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 18V800000 (Electrical System). The manufacturer had been informed of the failure. The failure mileage was approximately 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11429514August 17, 2021
VEHICLE SPEED CONTROL, WHEELS, UNKNOWN OR OTHER
Hi, When you drive over 70mph, steering, floors and whole cabin start vibrates, I have changed tires as Volvo recommended, alignment done. Everything dealer requested I have done. I have driven couple of more volvo as a loaners and noticed they all vibrates , but not bad as mine. Try to reach out Volvo head office but no proper resolution. They are keep blaming tires which I have changed 3 times but actually vibration happen from engine or somewhere else. Lots of Volvo owners online shares same issues online. Please help me out on this matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11354712September 15, 2020
STRUCTURE
2018 VOLVO S-90. CONSUMER WRITES IN REGARDS TO A PRODUCT FLAW. *LD THE CONSUMER STATED THE VEHICLES FLOOR MAT HAD UNSNAPPED AND BECOME WEDGED UNDER THE ACCELERATOR PEDAL. THE CONSUMER WAS UNABLE TO DRIVE FORWARD OR IN REVERSE. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11232055July 15, 2019
UNKNOWN OR OTHER
I PURCHASED A VOLVO S90 2018 FROM ECAR ONE . ON JULY 6 2019. I WAS TOLD BY THE SALEMAN VIRGIL . THAT THERE WAS A RECALL ON THE DASHBOARD AND ALL I HAVE TO DO WAS CALL VOLVO DEALERSHIP AND THEY WOULD FIX FOR FREE. WHEN I CALLED VOLVO AFTER MY PURCHASE THEY SAID NO RECALL ON THIS VEHICLE. 0709
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11210221May 27, 2019
SERVICE BRAKES
WHILE DRIVING AT LOW SPEEDS THERE IS A LOUD SCREECHING SOUND WHEN BREAKING. THE DEALERSHIP HAS HAD THE CAR IN FOR REPAIR 4 TIMES, THE CURRENT MILEAGE IS 10,100. THE DEALERSHIP HAS NOT TOLD US WHAT IS THE ISSUE BUT THE NOISE REMAINS. I AM CONCERNED BECAUSE I DRIVE WITH MY KIDS AND THEIR FRIENDS IN THE CAR AND WE HAVE NO INFORMATION ON WHAT IS GOING ON WITH THE BREAKS. WE DO NOT KNOW IF THE CAR IS A SAFETY HAZARD SINCE THEY HAVE TOLD US NOTHING. WE HAVE MANY AUDIOS WITH THE NOISE, WHICH THE DEALERSHIP RMCHOOSES TO IGNORE BUT THE NOISE PERSISTS AFTER EACH REPAIR. WE ARE AFRAID THEY ARE HIDING THE REAL ISSUE AND IT MAY BE DANGEROUS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11084567April 11, 2018
FUEL/PROPULSION SYSTEM, ENGINE
TL* THE CONTACT OWNS A 2018 VOLVO S90. THE CONTACT STATED THAT THE SERVICE ENGINE INDICATOR ILLUMINATED. IN ADDITION, THE FUEL MILEAGE WAS LESS THAN WHAT WAS STATED IN THE OWNER'S MANUAL. THE VEHICLE WAS TAKEN TO THE DEALER (GUNTHER VOLVO CARS COCONUT CREEK, 4300 SR 7, COCONUT CREEK, FL 33073, (954) 590-3760) MORE THAN TWICE FOR DIAGNOSTIC TESTING AND TO BE TEST DRIVEN, BUT THERE WAS NO PERMANENT REMEDY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND HAD NOT ISSUED ANY RECALLS. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S90