Volkswagen · Model Report
Showing safety data for the 2018 model year only.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan and 2018-2021 Tiguan long wheel base (LWB) vehicles. Due to incorrect installation instructions, the accessory rear hatch spoiler may be insufficiently attached to the vehicle.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan vehicles. During the repair of roof damage, an incorrect roof reinforcement assembly may have been installed.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan LWB vehicles. In the event of a crash, one or both of the front seat belt's webbing may tear.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
The contact owns a 2018 Volkswagen Tiguan. The contact stated that while driving at various speeds, there was a clunking sound coming from the vehicle while depressing the brake pedal and making left turns. The contact stated that the failure became worse over time. The vehicle was taken to the local dealer to be diagnosed, and it was determined that the steering rack mounting bolt was fractured due to corrosion and half of the bolt had seized. The contact was advised that the steering rack needed to be replaced. The vehicle was not yet repaired. The contact was notified about NHTSA Campaign Number: 26V590000 (STEERING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 82,000.
No injuries · No fire · No crash
My vehicle is under safety recall NHTSA 26V590 (Volkswagen 48LG / 48VT). The steering rack mounting bolt can corrode and break, which can cause a loss of steering control. I was notified of this recall about a month ago. As of October 21, 2026, there is still no remedy available, and I am told owner letters may not go out until around November 10 — nearly two months after the recall was announced — with no date for when a repair will actually exist. This is my only vehicle, and I have to commute to work in it every day. On October 21, 2026, I contacted Volkswagen customer care and asked for a loaner or alternative transportation until the remedy is available. I was offered nothing — only told to keep driving the vehicle and wait. I do not think it is acceptable for owners to be told to keep driving a car with a known steering defect, with no repair available and no alternative transportation offered. I am asking NHTSA to press Volkswagen on the remedy timeline and on providing interim transportation for owners who have no other vehicle.
No injuries · No fire · No crash
Within 6 months of purchasing car CPO from dealer, car went into limp mode. Was less than 35k miles, still having same issues at 85k miles. Took to dealer, they said nothing was wrong with car. Car began to have ECU light come on frequently in the middle of driving, took back to dealer. They replaced the fuel injector harness under warranty. Began to have issues with fuel injector misfires, car stalling and lagging at stop signs, sputtering when given gas. When driven for long periods at a time, would intermittently not start. Took back to dealer within a year, spent 1800 on maybe fixes, modules and carbon filter replacement. Same issues. Took back again, spent another 1800 replacing modules. Same issues repeated. Took to a european car specialist as we were frustrated with not getting the vehicle properly fixed for years at the dealer, had the engine walnut blasted for any carbon buildup and fuel injectors cleaned, they diagnosed and said the fuel rail harness is bad. Took back to Volkswagen, they re-evaluated and said there was no issue- my husband had to explain to them that there was a repair just done so code reading would not be sufficient and they needed to get under the car and use a multimeter to diagnose the wiring harness. Service team needs additional training- after doing so they found the fuel harness used may in fact be bad and replaced it a second time. Called VW corporate who was no help and told me we are at the discretion of the dealer and they years of the same issues are just what happens at times when the vehicle is out of warranty. There are thousands of reports online- I have been out of use of the vehicle for at least 6 months in my 5 years of ownership. I cannot believe that VW has consistently faulty product relating to the fuel rail system and has not recalled the vehicles.
No injuries · No fire · No crash
Suspected Electrical Defect and Potential Fire Hazard – 2018 Volkswagen Tiguan SEL I am reporting a suspected electrical safety defect involving the sunroof wiring harness in my 2018 Volkswagen Tiguan SEL. While my vehicle was parked, an attempt was made to replace a blown F23 fuse. Smoke began coming from the sunroof area and filled the cabin. Afterward, multiple warning lights illuminated, the vehicle displayed a “turn car off” warning, the door locks repeatedly cycled, the climate control stopped working, and the infotainment/navigation screen shut off and restarted. A mechanic subsequently determined that the sunroof wiring harness had melted and required replacement. I was informed that the wiring harness (part number 5NA971648C) is unavailable and has been placed under Volkswagen’s “quality inspection” process due to suspected fire-hazard concerns. Volkswagen reportedly no longer supplies this harness separately, requiring replacement of the entire sunroof assembly, including the glass, even though the glass is not the source of the problem. The repair is estimated at $3,900 and requires extensive labor, including dashboard removal and a VIN-specific part from Germany. My primary concern is safety, not cost. A wiring harness that melts and produces enough smoke to fill a vehicle’s cabin could potentially cause a fire, damage other electrical systems, or endanger occupants. I am concerned other owners may face the same hazard. I request that NHTSA investigate whether the sunroof wiring harness or associated electrical system in 2018 Volkswagen Tiguan vehicles presents a safety defect, review similar reports, and determine whether further investigation or corrective action is warranted.
No injuries · No fire · No crash
While opening the sunroof, the front end of the sunroof began to billow smoke. The cabin filled with smoke. The car was immediately turned off and the fuse was removed. While attempting to drive the vehicle closer to the dealership, the car experienced a total electrical failure and stalled on the side of the road. The car will require a tow. There is a known recall on this matter, however, my VIN does not fall under this recall. The recall explains the exact issue we experienced with the smoking sunroof motor from the faulty lighting causing a serious fire risk.
No injuries · No fire · No crash