Volkswagen Jetta Complaints (2006)

580 consumer complaints on file.

#10351657August 25, 2010
POWER TRAIN:MANUAL TRANSMISSION
THE DMF FLYWHEEL ON 2006 VOLKSWAGEN JETTA TDI COMES APART. MINE SEPARATED AND WAS SCRAPING SO I STOPPED DRIVING IT UNTIL I RECEIVED THE NEW FLYWHEEL AND CLUTCH. IT STARTED WITH A SCRAPING SOUND THAT HAPPENED MORE FREQUENT EVERYDAY AND A LITTLE LOUDER. AFTER 5 DAYS I REALIZED IT WAS COMING FROM THE FLYWHEEL. THERE ARE NUMEROUS PROBLEMS WITH THESE I HAVE FOUND ON FREDS TDI PAGE. MOST WERE FROM A DIFFERENT FLYWHEEL MANUFACTURER AND I WAS SURPRISED TO SEE MINE WAS MADE BY SACHS THESE CAN CAUSE SERIOUS DAMAGE TO A VEHICLE IF IT BREAKS APART. THIS CAR SEEMS REALLY WELL MADE AND IS ALOT OF FUN TO DRIVE. I HAVE BEEN REAL HAPPY WITH IT BUT THINK THIS SHOULD NOT HAVE HAPPENED AND COULD BE DANGEROUS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351260August 23, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT WAS DRIVING 25 MPH WHEN THE VEHICLE ABNORMALLY DECELERATED AND WOULD NOT RESPOND TO THE CONTACT'S ATTEMPTS TO DRIVE FORWARD OR IN REVERSE. THE CONTACT WAS UNABLE TO MOVE THE VEHICLE AND IT WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER ADVISED THAT THE TRANSMISSION WOULD NEED REPLACING. A DIAGNOSTIC WAS PERFORMED BUT PRODUCED NO FAILURE CODES. THE MANUFACTURER OFFERED TO COVER ONE HALF OF THE REPAIR COSTS. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 68,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10350333August 18, 2010
STRUCTURE:FRAME AND MEMBERS
THE 2006 JETTA GLI HEADLINER FABRIC IS HAVING SHRINKAGE AND FALLING OFF. THE CAR INTERIOR LOOKS UGLY THE VW DEALER IS CHARGING $1100.00 TO CHANGE THE WHOLE HEADLINER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10348971August 12, 2010
ENGINE AND ENGINE COOLING, POWER TRAIN, FUEL SYSTEM, GASOLINE, VISIBILITY:SUN/MOON ROOF ASSEMBLY
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE VEHICLE EXPERIENCED VARIOUS RECURRING FAILURES SINCE THE DATE IT WAS PURCHASED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON NUMEROUS OCCASIONS WHERE THE BATTERY WAS REPLACED, THROTTLE VALVES WERE CLEANED, THE RECIRCULATION VALVE WAS REPLACED, THE ENGINE FAN CONTROL MODULE WAS REPLACED, THE FUEL PRESSURE SENSOR WAS REPLACED, THE CRANK CASE BREEDER VALVE WAS REPLACED, THE HIGH PRESSURE FUEL PUMP WAS REPLACED, AND THE CAM SHAFT FOLLOWER WAS REPLACED. THE VEHICLE WAS ALSO REPAIRED UNDER THE RECALL 09V164000, POWER TRAIN DRIVELINE, DRIVESHAFT AND HAD THE SUNROOF DRAINED DUE TO WATER LEAKAGE. THE FAILURE MILEAGE WAS 16,257 AND THE CURRENT MILEAGE WAS 47,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10348438August 10, 2010
STRUCTURE
FABRIC HEADLINER ON INTERIOR ROOF OF 2006 VW JETTA IS SEPARATING, SAGGING DOWN SO THAT I CANNOT SEE OUT OF REARVIEW MIRROR. APPARENTLY THIS IS COMMON DEFECT W/THE CAR- THE GLUE SEPARATES AFTER ONLY A FEW YEARS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10347898August 7, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
VW JETTA TDI 2006, MILEAGE 177 000KM ON AUG 5, 2010, I HEARD A STRANGE NOISE FROM THE ENGINE /TRANSMISSION, AS I WAS DRIVING ON THE HWY. AND I ALSO FELT VIBRATION AT 120-130KM /H. I PULLED INTO A VW DEALERSHIP TO CHECK IT OUT. THE SERVICE ADVISOR TOOK THE CAR FOR A TEST DRIVE AND TOLD ME THAT THERE IS A NOISE COMING FROM THE FLYWHEEL, BUT NOTHING SERIOUS. THE VERY NEXT DAY ON AUG 6,2010 WHILE DRIVING IN THE CITY I HEARD MORE AND LOUDER NOISE FROM THE TRANS. AN AT I DROVE SLOWLY FOR ABOUT 7KM. INTO ANOTHER VW DEALER. AT THIS POINT AFTER A THEY RAISED THE CAR ON THE HOIST THEY TOLD ME THAT THE SPRINGS FROM THE FLYWHEEL ARE BROKEN AND THE FLYWHEEL NEEDS TO BE CHANGED. THEY TOLD ME THAT THIS IS COMMON ISSUE DUE TO WEAR AND TEAR. THE REPLACEMENT PART ( THE FLYWHEEL) WILL COST ABOUT $900CND. AND THE LABOR THEY TOLD ME WOULD BE 8H WHICH IS $800 SO TO TOTAL COST IS $2100. I DO NOT THINK THAT THIS A NORMAL TO HAVE THE FLYWHEEL BROKEN JUST LIKE THAT. I ALSO WON AN ODER CAR WHICH I DROVE OVER 400 000 AND NEVER HAD PROBLEMS WITH THE FLYWHEEL. PLEASE ADVISE ON WHAT ARE MY OPTIONS AT THIS POINT. THANK YOU *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10344256July 20, 2010
POWER TRAIN
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE TRANSMISSION SHIFTED INTO NEUTRAL GEAR WHILE DRIVING. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN RECALL 09V333000 POWER TRAIN: AUTOMATIC TRANSMISSION. THE VEHICLE WILL BE REPAIRED. THE FAILURE MILEAGE WAS 91,000 AND THE CURRENT MILEAGE WAS 91, 5000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10341858July 7, 2010
POWER TRAIN:MANUAL TRANSMISSION
PURCHASED A 2006 VW JETTA TDI, USED, WITH 61,800 MILES. CLUTCH FELT WEIRD TO ME WHEN I PURCHASED THE CAR BUT THOUGHT IT WAS NORMAL. LESS THEN TWO WEEKS AFTER PURCHASE I NOTICED GEARS SLIPPING. THE DEALERSHIP DIAGNOSED WORN CLUTCH DISK AND DAMAGED THROW-OUT BEARING. A PROPERLY MANUFACTURED CLUTCH ASSEMBLY SHOULD NOT FAIL AT 61,000 MILES, IF EVER. FROM WHAT I'VE READ IT MAY BE DUE TO BAD DESIGN OF THE DUAL MASS FLYWHEEL, WHICH OVER-HEATS THE DISK AND CAUSES DAMAGE. THIS IS A SERIOUS ISSUE WHICH MAY CAUSE SUDDEN LOSS OF CONTROL OF YOUR VEHICLE WHILE DRIVING DOWN THE HIGHWAY. MANY DRIVERS ARE NOT "IN-TUNE" WITH THEIR VEHICLE AND MAY NOT RECOGNIZE THE PROBLEM UNTIL A SERIOUS ACCIDENT LIKE THIS DOES HAPPEN. THE ISSUE IS RAMPANT, AND SEEMS IT MAY BE INEVITABLE FOR MOST 2006 VW BUILDS. HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=137014. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10340866June 30, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
FLYWHEEL ISSUE IN A 2006 VW JETTA TDI. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10340002June 25, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
THE ENGINE BEGAN CHATTERING WHILE IDLING. IT HAS 80K MILES. THE CHATTERING BECAME WORSE SO I TOOK IT TO THE LOCAL DEALER. THE TRANSMISSION HOUSING WAS CRACKED, THE FLYWHEEL BROKEN AND SLIP KIT CRACKED. IT WAS LEAKING OIL FROM THE TRANSMISSION. TOTAL REPAIR WILL BE MORE THAN $6000 AND TAKE MORE THAN 6 WEEKS TO COMPLETE THE REPAIR. THE PARTS DEALERS ARE HAVING A HARD TIME FINDING A FLYWHEEL. I HAVE HAD THE CAR SERVICED AT THE DEALER SINCE I BOUGHT IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10336882June 17, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
DRIVING HOME ON COUNTRY ROAD IN THE POURING DOWN RAIN WHEN AT ABOUT 50 MPH THE ENGINE RPM REVVED, DASH WARNING LIGHTS LIT, FLASHED AND RANG. THE PRND WAS FLASHING. LUCKILY A DRIVEWAY WAS NEARBY TO GET OUT OF TRAFFIC. KNEW AT THIS POINT WHAT HAD HAPPENED BECAUSE WE HAD THE VERY SAME THING HAPPEN IN OCTOBER OF 2009. MEGATRONICS UNIT HAD FAILED AND WAS REPLACED AT A COST OF $1900. CALLED DEALERSHIP FOR APPOINTMENT ON JUNE 8TH. HAPPENED AGAIN 5 TIMES ON WAY TO DEALERSHIP. TOLD FROM DIAGNOSTIC TEST THAT IT HAD A BAD STEERING ANGLE SENSOR AND GATEWAY MODULE. NO PARTS WERE AVAILABLE. HAD TO TAKE CAR 70+ MILES BACK HOME. THE CAR MALFUNCTIONED ON THE WAY HOME IN A CONSTRUCTION ZONE. FELT IT WAS UNSAFE TO DRIVE ANY FURTHER. STOPPED AT A DIFFERENT DEALERSHIP. LEFT CAR FOR THEM TO DIAGNOSE. FOUND A SECOND BAD MEGATRONICS UNIT. REPLACED UNDER WARRANTY FROM THE FIRST REPLACEMENT. I FEEL THAT THIS CAR NEEDS TO BE RECALLED FOR THE SAFETY CONCERN THAT THE VEHICLE LOSES POWER AT ANY GIVEN TIME, IN ANY ROAD SITUATION YOU CAN THINK OF. YOU CANNOT ALWAYS BE PREPARED TO REACT TO THIS. YOU HAVE NO POWER TO GET OUT OF HARMS WAY. THE ONLY WAY TO CORRECT THIS IS TO SHUT THE CAR OFF AND RESTART AND HOPE IT WORKS. PREVIOUS ODI #10286197. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10336167June 14, 2010
POWER TRAIN:MANUAL TRANSMISSION
CLUTCH FAILURE, PROBLEM DISENGAGING CLUTCH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10335246June 8, 2010
SERVICE BRAKES, HYDRAULIC
2006 VW JETTA 2.5L VALUE EDITION MY CAR IS AT 60,000 MILES AND I HAVE CHANGED THE BRAKES 3 TIMES ALREADY. NOW THE BRAKE PAD WARNING LIGHT IS ON AGAIN. I HAVE ALREADY SPENT 1,000 DOLLARS IN FIXING THE BRAKES. CHECKING DIFFERENT WEB FORUMS, AND A LOT OF JETTA OWNERS ARE COMPLAINING ABOUT THE SAME PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10334688June 4, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
FAILURE OF DSG TRANSMISSION AND DUAL MASS FLYWHEEL ON 2006 VOLKSWAGEN JETTA TDI. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10331889May 24, 2010
FUEL SYSTEM, DIESEL, ELECTRICAL SYSTEM
2006 JETTA TDI 58,229 MILES TODAY / PURCHASED FROM 2ND OWNER AT 53K MILES 34MPG IN TOWN / 42.5MPG HIGHWAY WIFE DRIVEN WITH LIGHT FOOT. OIL CHANGE AND FUEL FILTER REPLACED AT 53K MILES BACKGROUND: CAR WAS PURCHASED EARLY DEC 2009, WITH IN 2 WEEKS IT WAS AT THE DEALER FOR A NON START ISSUE. CAR WAS GARAGED OVER A 3 DAY WEEKEND AND NOT DRIVEN AT ALL. MONDAY MY WIFE GOES TO START IT AND IT WILL NOT START, AFTER TELLING ME I TRY FOR 3 MINUTES TO GET IT STARTED AND IT FINALLY STARTS. TAKEN TO DEALERSHIP AND THEY FIND NO ISSUES, THEY BLAME COLD START AS THE CULPRIT. THIS IS A BS CALL AS THE CAR WAS AND IS ALWAYS GARAGED AT 50+ DEGREES F. ROUGHLY 3 WEEKS LATER THE SAME SITUATION HAPPENS AND THE CAR GOES BACK TO THE DEALER. TO NO AVAIL THEY STILL COULD NOT REPLICATE THE ISSUE NOR FIND A SOLUTION. THE NO START ISSUE/ HARD START ISSUE SEEMED TO PROGRESS FROM SITTING FOR 3 DAYS AND NOT STARTING TO RANDOMLY MULTIPLE TIMES A WEEK NOT STARTING. THEY STILL CANNOT FIND A SOLUTION. I FIRMLY BELIEVE THIS IS A FUEL ISSUE. ON TO TODAY'S ISSUE: FIRST NOTICED 3 WEEKS AGO WHILE ATTEMPTING TO PASS A CAR ON THE INTERSTATE AT 70MPH (AROUND 4K RPM), THE CAR DOWN SHIFTED AND STUTTERED RATHER THEN INCREASING SPEED. I THOUGHT IT WAS A 1 TIME ISSUE UNTIL I STARTED NOTICING IT MORE AND MORE. NOW IT HAPPENS FREQUENTLY AND MORE PRONOUNCED STARTING AT EVEN 35MPH/3400 RPM IN 3RD GEAR. FROM 10AM TUESDAY TO 5PM FRIDAY OUR JETTA WAS BACK AT THE DEALERSHIP BECAUSE OF A STUTTER/POWER LOSS ISSUE. THEY DID REPLACE THE FUEL FILTER TODAY AS WELL AS TEST THE FUEL (WHICH TESTED FINE), THE EGR VALVE WAS CLEANED WITH A CARB CLEANER. THE SERVICE MANAGER DROVE THE CAR OFTEN AND HAS BEEN ABLE TO REPLICATE THE POWER LOSS / STUTTER, HOWEVER THEY CANNOT FIND ANYTHING WRONG. THEY CALLED THE VW TECH LINE MULTIPLE TIMES AND STILL NO FIX ONCE AGAIN. CAR DIED SEVERAL TIMES TODAY. TURNING ONTO THE HIGHWAY THE CAR STUTTERED AND THEN .5 MILES LATER IT DIED AT 45MPH IN TRAFFIC. PULLED OVER AND CRANKED FOR 3 MINUTES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10332014May 24, 2010
POWER TRAIN:MANUAL TRANSMISSION
AT APPROXIMATELY 79K MILES MY 2006 VW JETTA TDI BEGAN TO RATTLE LOUDLY IN THE ENGINE COMPARTMENT AT IDLE AND LOW RPMS. SIGNIFICANT ENGINE SHUDDER ALSO. THE DEALER REPORTS THAT THE DUAL-MASS FLYWHEEL AND PRESSURE PLATE HAVE FAILED. FLYWHEEL FAILURE IS A SERIOUS SAFETY DEFECT. THIS IS A KNOWN ISSUE AND VW HAS REPLACED THIS FLYWHEEL WITH A MORE RELIABLE DESIGN. BELIEVE THIS DMF HAS ALREADY BEEN A SAFETY RECALL IN EUROPE AND AUSTRALIA, BUT BEING CALLED NORMAL WEAR AND TEAR IN THE U.S. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10331098May 18, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
WHILE DRIVING A 2006 VW JETTA DIESEL, ALL POWER WAS LOST TO THE DRIVE WHEELS WITH THE PRNDS DISPLAY ON THE DASHBOARD FLASHING. CAR HAS 46,000 MILES ON IT. THIS HAS BEEN REFERRED TO AS A FALSE NEUTRAL. I WAS ABLE TO COAST TO THE ROAD SIDE, TURN OFF THE CAR AND RESTART IT WITH NORMAL FUNCTION OF 300 YARDS THEN PROBLEM REPEATED REQUIRING A TOW TO THE DEALER. A FAILURE OF THE MECHATRONIX UNIT IN THE DSG WAS DISCOVERED AND PART REPLACED. A SIMILAR ISSUE HAD OCCURRED AT AROUND 10, 000 MILES , WAS LOOKED AT BY THE DEALER WITH NO ISSUE FOUND. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10330818May 17, 2010
POWER TRAIN:DRIVELINE:DRIVESHAFT
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT HEARD NOISES WITHIN THE VEHICLE WAS IDLING. WHEN DRIVING, HE NOTICED THAT THE TRANSMISSION WAS NOT SHIFTING PROPERLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE DUAL MASS FLY WHEEL WAS REPAIRED. THE CONTACT REFERENCED RECALL 09V164000 (POWER TRAIN: DRIVELINE: DRIVESHAFT) AS RELATED TO THE FAILURE HE EXPERIENCED. THE CURRENT MILEAGE WAS APPROXIMATELY 68,000. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10329289May 7, 2010
ELECTRICAL SYSTEM
THERE IS A DEFECT WITHIN THE WIRING HARNESS THAT CAUSES MOST OF THE VEHICLE ELECTRONICS TO SHUTDOWN AND OCCASIONALLY STOPS THE VEHICLE WHILE DRIVING. I CAN PROVIDE PICS OF THE WIRING ISSUE IF NEEDED. THE ISSUE USUALLY OCCURRED WHEN DRIVING IN VERY WET CONDITIONS. AFTER THE FIRST TIME IT HAPPENED, THE PROBLEM GREW WORSE AS THE WIRING WAS CHAFED MORE & MORE OVER TIME. THE JETTA TDI'S SHOULD BE RECALLED TO HAVE THE HARNESS CHECKED & REPAIRED BEFORE SOMEONE DIES IN A CAR CRASH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10328693May 3, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
I PURCHASED THE 2006 VOLKSWAGEN JETTA TDI FROM A PRIVATE OWNER 6 MONTHS AGO. THERE WAS A SOUND APPARENT WHEN I PURCHASED IT BUT I THOUGHT IT WAS TYPICAL FOR A DIESEL VEHICLE, AFTER 6 MONTHS OF DRIVING I TOOK IT TO MY MECHANIC AND WAS TOLD THAT THE DMF (DUAL MASS FLYWHEEL) WAS FAILING. I'VE DONE RESEARCH ONLINE TO FIND THAT THE DMF MANUFACTURED BY SACHS THAT VOLKSWAGEN USES IN THEIR 2000 AND LATER MODELS HAVE A HIGH RATE FAILURE AFTER IN AS LITTLE AS 10,000 MILES. CAUSING COMPLETE TRANSMISSION OR ENGINE FAILURE OF VARYING DEGREES. THE COST FOR THIS REPAIR CAN RANGE BETWEEN $2000.00 - $8000.00. NOT ONLY IS THE EXPENSE HIGH DUE TO A MANUFACTURER DEFECT IN THE FLYWHEEL, BUT THE RISK IS EVEN HIGHER, CAUSING HESITATION IN ACCELERATION WHEN PULLING OUT INTO TRAFFIC OR SUDDEN WHEEL LOCK AND LOSS OF CONTROL AT ANY GIVEN MOMENT WHILE TRAVELING. IT IS HIGHLY RECOMMENDED THAT THIS PROBLEM BE ADDRESS FOR THE SAFETY AND CONCERN OF ANY VOLKSWAGEN VEHICLE OWNER WITH THIS DEFECTIVE FLYWHEEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volkswagen Jetta