Toyota Tundra Complaints (2005)

377 consumer complaints on file.

#11306888February 3, 2020
SERVICE BRAKES, SUSPENSION
THE FRAME RUSTED TO THE POINT THAT IT WILL NOT PASS A STATE INSPECTION. THE BRAKES WOULD NOT STOP THE VEHICLE WHEN IN FORWARD MOTION, WHICH CAUSED AN ACCIDENT.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11302247January 27, 2020
ENGINE, FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
2005 TOYOTA TUNDRA DOUBLE CAB. WHEN STATIONARY ON COLD START: VEHICLE PRODUCES A LOUD NOISE AND ADDITIONAL CARBON MONOXIDE/EXHAUST, CAUSING ADDITIONAL DANGER WHEN STARTING IN A GARAGE. WHEN IN MOTION: TRUCK OPERATES AS INTENDED UNTIL ACCELERATION IS ATTEMPTED, CAUSING A MAJOR SAFETY CONCERN WHEN MERGING ONTO HIGHWAYS, DRIVING UP AN INCLINE, OR ANY OTHER DRIVING SITUATION WHERE THE GAS APPLICATION IS NECESSARY. WHEN IN MOTION: VENTING AND INTERIOR AIR CONTROLS CANNOT BE USED BASED ON THE AMOUNT OF EXHAUST THAT WILL SPILL INTO THE CAB OF THE TRUCK. THIS IS A PROBLEM THAT IS WIDELY KNOWN TO THE TOYOTA COMMUNITY, AND TO DRIVERS OF TOYOTA TUNDRAS IN PARTICULAR. OF NOTE, THOUSANDS OF MESSAGES CAN BE EASILY ACCESSED IN THE TOYOTA MESSAGE BOARDS (TUNDRA TALK, TOYOTA NATION, TUNDRAS.COM, TUNDRA SOLUTIONS). IN ADDITION, THERE IS A SEPARATE COTTAGE INDUSTRY THAT HAS SPRUNG UP AS A RESULT, WHERE MANUFACTURERS ARE PRODUCING BYPASS KITS THAT COMPROMISE THE EXHAUST STANDARDS SET BY YOU ALL, WHERE AN ENTIRE BUSINESS MODEL HAS BEEN CREATED TO PROFIT OFF OF THESE ISSUES. ONE OF THE PRIMARY PARTIES IS HEWITT-TECH. WHEN ADVISED AT A TOYOTA DEALERSHIP, THE REPAIR QUOTE WAS $2568 OUT OF POCKET. WHEN SPEAKING TO TOYOTA CUSTOMER EXPERIENCE, I WAS TOLD THEY DO NOT ANTICIPATE ADDRESSING THE ISSUE, AS IT IS NOT ENOUGH OF A PROBLEM. IN GREATER RESEARCH, IT IS APPARENT THEY ARE EITHER AWARE BUT UNWILLING TO REMEDY THE SITUATION BECAUSE A) THE SCOPE IS FAR TOO WIDESPREAD WITHIN THEIR TRUCK MARKET (EVERY TOYOTA TUNDRA IS SUBJECT TO RECALL) OR B) THE SCOPE IS TOO WIDESPREAD THROUGHOUT THEIR ENTIRE MARKETSHARE (SIMILAR PROBLEMS ARE INDICATED WITH THE COROLLA AND OTHER PASSENGER CARS). THIS IS NEGLIGENT AND DANGEROUS AND NEEDS TO BE ADDRESSED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11299398January 14, 2020
SUSPENSION
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED WHILE DRIVING AT 40 MPH, WHEN THE FRONT PASSENGER SIDE TIRE DETACHED AND ROLLED AWAY ON THE ROAD. THE CONTACT STATED THE FRONT PASSENGER SIDE DOOR AND FENDER HIT A CURB. THE AIR BAGS DID NOT DEPLOY. THE CONTACT STATED HE DID NOT SUSTAIN ANY INJURIES OR SEEK MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND WAS INFORMED THAT THE LOWER BALL BEARING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AS OF YET AWAITING THE PART. THE CONTACT CALLED LOCAL DEALER MAITA TOYOTA OF SACRAMENTO LOCATED AT 2500 AUBURN BLVD, SACRAMENTO, CA 95821, (916) 481-0855 AND NOTIFIED THAT THE VEHICLE WAS REPAIRED PREVIOUSLY UNDER NHTSA CAMPAIGN NUMBER: 07V013000 (SUSPENSION) BACK IN 2007. THE MANUFACTURER WAS NOT INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 330,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11297878January 8, 2020
STRUCTURE:BODY
MAIN FRAME OF THE 2005 TUNDRA IS ROTTEN FROM RUST AND A CHUNK OF THE FRAME HAS FALLEN OUT. SEE PICTURE. I CONTACTED LOCAL TOYOTA DEALER AND THEY SAID THERE IS NOTHING THEY CAN DO AS RECALL HAS EXPIRED AND TOYOTA CORPORATE WILL NOT DO ABSOLUTELY NOTHING. THIS TUNDRA WAS SUPPOSED TO BE SPRAYED IN 2014 AS PART OF THE "FIX" BUT THE FRAME IS RUSTING AND ROTTING APART. MORE SIGNS OF ROTS ARE VISIBLE ON THE FRAME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11289509December 16, 2019
POWER TRAIN, STRUCTURE:BODY, ENGINE
I OWN A 2005 TOYOTA TUNDRA WITH JUST 60,000 MILES. IN 2014 TOYOTA WAS ALLOWED TO PUT A BAND-AID ON A PROBLEM THAT NEEDED A TOURNIQUET - APPLYING A RUST CONVERTER COATING TO A FRAME THAT, BECAUSE OF THEIR FAILURE TO MANUFACTURER IT PROPERLY, DESERVED REPLACING. I WAS TOLD BY TOYOTA (CASE NUMBER [XXX]) THAT BECAUSE THE PREVIOUS OWNER TOOK THE BAND-AID THEY WERE NO LONGER LIABLE UNTIL THE GOVERNMENT FORCED THEM VIA FURTHER GOVERNMENT SAFETY RECALL ACTIONS TO DO MORE. MY HOPE IS BY WRITING THIS THAT THE GOVERNMENT CAN BE PROACTIVE AND SOLVE THIS SAFETY CONCERN BEFORE THEY HAVE TO COLLECT ENOUGH DEATH AND ACCIDENT STATISTICS TO TAKE NOTICE OF THIS ISSUE. NOT ONLY THAT, I SEE THAT TOYOTA IS BEING OFFERED THE SAME BAND-AID SOLUTION ON A NUMBER OF NEW MODELS WITH THE SAME ISSUE - PROVING THAT THEY DIDN'T LEARN ANY LESSON JUST HOW THEY CAN GET AWAY WITH ACTUAL MURDER. THE RESULT WILL BE MORE VEHICLES IN 5 YEARS IN WORSE SHAPE DUE TO THE LENIENT RECONCILIATION MANDATED BY THE GOVERNMENT. DO NOT PUT MORE LIVES AT RISK IN ORDER TO SAVE A MULTI-BILLION DOLLAR COMPANIES BOTTOM LINE. THE FRAME WHICH IS KNOWN TO BE PRONE TO EXCESSIVE, PREMATURE RUST CORROSION BECAUSE THE FRAMES WERE NOT PROPERLY PREPARED AND TREATED AGAINST RUST CORROSION WHEN THEY WERE MANUFACTURED SHOULD ALL HAVE TO BE REPLACED UNDER THIS RECALL TO PROTECT AMERICAN DRIVERS. THIS EXCESSIVE RUST CORROSION COMPROMISES THE VEHICLES' SAFETY, STABILITY, AND CRASH-WORTHINESS BECAUSE IMPORTANT SUSPENSION COMPONENTS, ENGINE MOUNTS, TRANSMISSION MOUNTS, AND BODY MOUNTS ANCHORED TO THE VEHICLES' FRAMES ARE AT RISK OF FAILURE. DO YOU WANT THIS VEHICLE (PICTURE ATTACHED) PASSING YOUR FAMILY ON A TWO-LANE HIGHWAY, BECAUSE I CAN TELL YOU THERE ARE A LOT, AND SOON TO BE EVEN MORE, DOING IT EVERY DAY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11288820December 13, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT EXPERIENCED ISSUES WITH THE VEHICLE'S FRAME EVER SINCE IT WAS PURCHASED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE WHO STATED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO PRIME TOYOTA (783 PORTLAND ROAD, SACO, ME 04072, 202 252-6161) WHERE IT WAS DIAGNOSED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 1912111347. THE CONTACT WAS INFORMED THAT THE REPAIRS WERE NOT COVERED. THE FAILURE MILEAGE WAS 156,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11287912December 9, 2019
STRUCTURE:BODY
I WENT TO HAVE MY 2005 TOYOTA TUNDRA INSPECTED AND IT FAILED DUE TO FRAME CORROSION CAUSING FRACTURE AND SPLINTERING OF THE FRAME SUPPORTS. THE FRAME OF MY 2005 TOYOTA TUNDRA HAS RUSTED THROUGH AT 4 POINTS, FRACTURING AND SPLINTERING AT 3 OF THE POINTS OF FAILURE. THE VEHICLE CAN NOT PASS THE VIRGINIA INSPECTION AND IS NOW UNDRIVEABLE. IT IS NOT SAVE TO HAUL OR TOW ANYTHING, THE TWO MAIN FUNCTIONS OF MY TRUCK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11287224December 5, 2019
AIR BAGS
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. AFTER THE VEHICLE WAS REPAIRED PER AN UNKNOWN RECALL FOR THE FRONT PASSENGER AIR BAG, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO TOYOTA PLACE (LOCATED AT 9670 TRASK AVE, GARDEN GROVE, CA 92844, (714) 243-8973) WHERE THE RECALL REPAIR WAS COMPLETED, BUT A DIAGNOSIS WAS NOT PERFORMED. THE VEHICLE WAS TAKEN TO SOUTH COAST TOYOTA (LOCATED AT 1966 HARBOR BLVD, COSTA MESA, CA 92627,(949) 722-2000) WHERE IT WAS DIAGNOSED THAT THE SPIRAL CABLE ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 38,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11282541November 26, 2019
AIR BAGS
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT RECEIVED A NOTIFICATION IN THE MAIL FOR NHTSA CAMPAIGN NUMBER: 19V741000 (AIR BAGS). THE CONTACT SPOKE WITH OXMOOR TOYOTA (8003 SHELBYVILLE RD, LOUISVILLE, KY 40222, (502) 565-0086) AND WAS INFORMED THAT THE PARTS WERE ON BACKORDER AND WOULD NOT BE AVAILABLE FOR THREE WEEKS. THE MANUFACTURER WAS NOTIFIED OF THE RECALL AND INFORMED THE CONTACT THAT HE WOULD HAVE TO WAIT A WEEK. THE CONTACT WAS ADVISED TO KEEP PASSENGERS OUT OF THE PASSENGER SEAT. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11280690November 17, 2019
AIR BAGS
AIRBAG CAME ON. I IMMEDIATELY TAKE IT TO DEALER. THEY CHARGED ME FOR THE DIAGNOSTIC. THEY ALSO SAID THE CONTACT SPIRAL NEED REPLACING
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11276894October 29, 2019
SUSPENSION
ON SEPTEMBER 30, 2019, MY 2005 TOYOTA TUNDRA (PURCHASED NEW IN 2004) DID NOT PASS INSPECTION DUE TO RUST HOLES ON THE FRAME; MILEAGE WAS 81,147. I LOOKED UP VIN NUMBER ON NHTSA AND THERE IS ONLY ONE RECALL DATED OCTOBER 2019 NOT FULFILLED FOR MY VEHICLE. A LOCAL DEALER INVESTIGATED MY VIN NUMBER, AND TOLD ME THERE WAS A D ZERO D/LIMITED SERVICE CAMPAIGN (EXPIRED 2015) REGARDING RUST PROBLEMS WITH THIS VEHICLE. I WAS NOT NOTIFIED BY TOYOTA ABOUT THIS. I HAVE NOT MOVED/CHANGED ADDRESS SINCE I PURCHASED THIS VEHICLE, AND I DID RECEIVE AND FULFILL THE 2016 AND 2007 RECALL NOTICES. I CALLED NHTSA AND TOLD THE WOMAN ON PHONE ABOUT THE D0D/LSC AND SHE FOUND IT FOR ME UNDER 'MANUFACTURER COMMUNICATIONS'. I HAVE TAKEN GOOD CARE OF IT AND HAVE ALL OF MY SERVICE RECORDS. I EXPECTED IT TO LAST AND AM DISAPPOINTED TOYOTA DID NOT NOTIFY ME. I AM REQUESTING NHTSA MAKE THESE LIMITED SERVICE CAMPAIGNS FOR VEHICLES VISIBLE WITH THE OTHER RECALLS. I LOOK FORWARD TO HEARING BACK FROM YOU AND A RESOLUTION OF THIS PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11268193October 13, 2019
STRUCTURE:BODY
FRAME IS RUSTING , AND WILL NOT PASS PA STATE INSPECTION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11254166September 9, 2019
STRUCTURE:BODY, SUSPENSION
FRAME HAS PREMATURELY RUSTED RESULTING IN THE SWAY BAR MOUNTING BRACKET TO BREAK OFF. FRAME IS CLOSE TO COMPLETE FAILURE WHICH WOULD RESULT IN FUEL AND BRAKE LINES SEVERING WITH CATASTROPHIC RESULT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11245821August 22, 2019
STRUCTURE:BODY
BRAKES FAILED2 TIMES IN LESS THAN 1 YEAR CAUSE OF FAILURE,BRAKE LINES RUSTED THROUGH. FRAME IS VERY RUSTY THE TRUCK WAS IN MOTION BOTH TIMES
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11244824August 18, 2019
STRUCTURE:BODY
WHILE DRIVING TRUCK ON PUBLIC ROAD, I HEARD A LOUD POP SOUND. PULLED OFF THE ROAD AND LOOKED UNDER THE TRUCK AND LOOKED LIKE THE SPARE TIRE WAS LOOSE. REMOVED THE SPARE TIRE AND PLACED IN THE BED OF THE TRUCK AND FURTHER INSPECTED THE REAR CROSS MEMBER. IT APPEARED TO BE CRACKED. CALLED TOYOTA DEALERSHIP TO HAVE TRUCK FRAME INSPECTED SPECIFICALLY THE REAR CROSS MEMBER. I HAVE ATTACHED THE WORK ORDER FROM HICKORY TOYOTA WHICH STATES DO NOT RECOMMEND DRIVING VEHICLE. HAVE ALSO ATTACHED A COUPLE OF PICTURES WHERE I HAVE HAD TO REPLACE THE REAR SHACKLE BRACKET ON THE REAR DRIVERS SIDE AND ALSO THE RACK PORTION OF THE RACK& PINION STEERING. I HAVE ATTACHED THE INVOICE FOR THE REAR BRACKET AND CAN SUPPLY AN INVOICE FOR THE RACK IF NEEDED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11242079August 6, 2019
STRUCTURE:BODY, SERVICE BRAKES
TOYOTA TUNDRA FRAME RECALL - FRAME COATING APPLIED PER RECALL IN 2014. VEHICLE INSPECTED TWICE BY DEALER IN 2018 & 2019 AND VEHICLE DETERMINED TO BE OK. RECENTLY EXPERIENCED LOSS OF BRAKES AND CRASH INTO GARAGE. VEHICLE INSPECTED BY INDEPENDENT MECHANIC AND FOUND 2 PERFORATED AND RUSTED BRAKE LINES. SCRAPING AWAY THE UNDERCOATING UNCOVERED OTHER CORROSION IN VARIOUS DEGREES. DETERMINED THAT SPRAY UNDERCOATING CAME WAY TO LATE AS TRUCK ALREADY HAD 9 YEARS OF CORROSION. UNDERCOATING ONLY HID THE PROBLEM. SUBMITTED A CLAIM WITH TOYOTA WHO OFFERED NO ASSISTANCE.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11233561July 20, 2019
STRUCTURE:BODY
DURING ANNUAL INSPECTION ON JULY 19, 2019, RUST HOLES FOUND IN THE FRAME. ONE HOLE WAS ALMOST 2 INCHES IN DIAMETER. ADDITIONAL PERFORATIONS FOUND NEAR THE LEAF SPRING AREA. VEHICLE WAS SUBJECT TO LSC IN 2014 AND TREATED WITH CRC COMPOUND. THIS JUST APPEARS TO HAVE DELAYED THE ONSET OF THE FRAME CANCER. TOYOTA WAS NOTIFIED. NO SUPPORT FROM THEM - THEY ARE SAYING IT IS MY PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11228453June 29, 2019
TIRES, TIRES:SIDEWALL
275/45R20 SUMITOMO HTR SPORT H/P 110H THIS TIRE BLOWOUT AT ABOUT 45 MILES PER HOUR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11221939June 22, 2019
SERVICE BRAKES
THE LAST 3 VEHICLES I'VE OWNED HAVE HAD TOTAL BRAKE FAILURE DUE TO BRAKE LINE FAILURE/ WITH VEHICLES LASTING LONGER AND SALT TREATING FOR WINTER PRECIPITATION, STAINLESS SHOULD BE REQUIRED. THE MOST RECENT WAS A TOYOTA TUNDRA. PREVIOUSLY AN EXPEDITION AND A LEXUS RX300
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11218618June 8, 2019
STRUCTURE:BODY
SEPT 2014 MY TRUCKS FRAME WAS RECALLED FOR THE RUST PROBLEM. THE FRAME WAS SCALED AND SPRAYED. MILEAGE 134,500. 6/2018 WITH MILEAGE 164,301 DEALER ADVISES ME FRAME IS GETTING RUSTY! I SAID YOU SCALED AND COATED IT IN 2014 ISN'T IT WARRANTED? THERE ANSWER WAS THAT ENDED LAST MONTH. NOW IT'S A YEAR LATER JUNE 2019 IT ONLY HAS 171,000 AND ONLY 36,500 MILES SINCE THE FRAME WAS COATED. THE TOYOTA DEALER FAILED THE NH STATE INSPECTION. I AM VERY UPSET AS I HAVE SPENT OVER $4500 IN THE PAST 18 MONTHS ON OTHER REPAIRS AND ON GONE 8K MILES. I NEVER WOULD HAVE DONE THOSE REPAIRS IF I WAS ADVISE HOW BAD IR HOW FAST THE RUST WAS GOING TO MAKE MY TRUCK UNSAFE TO DRIVE. WHY DID OTHER TRUCKS GET NEW FRAMES BECAUSE THEY DROVE MORE MILES THEN ME AND HAD THERE FRAMES RUST FASTED. THERE ARE TRUCKS NOW OF THE SAME AGE WITH NEW FRAMES WITH WELL OVER 200K +MILES BECAUSE THERE FRAMES RUSTED FASTER( TIME WISE). THIS IS NOT FAIR FOR THOSE WHO STILL HAVE JUNK FRAMES. ALL THE FRAMED ARE JUNK! BUT MANY GET STUCK WITH THEM BECAUSE IT TOOK LONGER TO RUST TO THE POINT OF FAILER BECAUSE WE DROVE THEM FEWER MILES PER YEAR! MY FRAME HAS FAILED IN THE SAME PLACES AS EVERY FRAME THAT HAS BEEN REPLACED,BUT BECAUSE IT LASTED PAST MAY 2018 MY TRUCK IS JUNK NOW BUT THE PERSON WHO'S FRAME RUSTED OUT BEFORE MAY 18 GETS TO CONTINUE DRIVING IT WITH THERE REPLACEMENT FRAME! HOW IS THIS FAIR???? IF MY FRAME WASN'T SCALED AND COATED IT WOULD HAVE RUSTED BEFORE MAY 2018 AND BEEN REPLACE! THEY JUST MADE IT LAST LONGER TO GET PAST THE MAY 2018 DATE!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra