Toyota Tundra Complaints (2003)

399 consumer complaints on file.

#11208037May 16, 2019
STRUCTURE:BODY
I HAD A SAFETY RECALL FOR CORROSION AND HAD IT REPAIRED AT THE DEALERSHIP IN JULY, 2015. RECENTLY I RETURNED TO THE DEALERSHIP FOR AN EXHAUST LEAK. WHEN THEY PUT IT ON THE RACK THEY NOTED SEVERAL AREAS ON THE FRAME WHICH HAD RUSTED ALL THE WAY THROUGH. THE MECHANIC INFORMED ME THE TRUCK WAS UNSAFE TO DRIVE AND THE FRAME NEEDED TO BE REPLACED. I CONTACTED TOYOTA AND WAS TOLD MY VIN WAS NOT PART OF ANY RECALL AND THEREFOR TOYOTA WOULD NOT REPLACE THE FRAME. I BELIEVE THE SAME INFERIOR STEEL WAS USED ON MY FRAME AS WAS ON THE RECALLED TOYOTAS. I LIVE IN VIRGINIA WHICH WHILE WE DON'T EXPERIENCE THE LARGE AMOUNTS OF SNOW HERE, WE ARE STILL CONSIDERED A NORTHERN STATE PER TOYOTA. THE TRUCK HAS NEVER BEEN IN AN ACCIDENT AND WAS USED AS A DAILY DRIVER AND NOW WILL BE A TOTAL LOSS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11204005April 26, 2019
FUEL/PROPULSION SYSTEM, STRUCTURE:BODY, ENGINE
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. WHILE DRIVING 65 MPH, THE CONTACT HEARD AN ABNORMAL DRAGGING NOISE COMING FROM THE VEHICLE. UPON EXITING THE VEHICLE, THE CONTACT NOTICED THAT THE FUEL TANK WAS RUSTED AND DETACHED. ALSO, THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT CALLED DON MOORE TOYOTA (4216 FREDERICA ST, OWENSBORO, KY 42301, (270) 926-2500) AND WAS INFORMED TO HAVE THE VEHICLE TOWED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 129,000. *BF *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11203115April 23, 2019
SEAT BELTS
SEAT BELT UNLOCK BY ITSELF. HAD THIS HAPPEN MULTIPLE TIMES DURING HARD BRAKING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11203011April 22, 2019
AIR BAGS, STRUCTURE:BODY, UNKNOWN OR OTHER
TAKATA RECALL, I WAS INVOLVED IN A COLLISION WITH MY TOYOTA TUNDRA WHEN A NISSAN ALTIMA FAILED TO STOP FOR A STOP SIGN. AT WITCH POINT MY AIR BAGS DID NOT GO OFF. THE TRUCK IS TOTALED AND SO WAS THE NISSAN! I WAS DRIVING EAST ON QUINCY AVE. AND THE NISSAN WAS DRIVING SOUTH ON B ST. WHEN SHE FAILED TO STOP AT THE STOP SIGN.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11189746March 18, 2019
POWER TRAIN, SUSPENSION
2003 TOYOTA TUNDRA FRONT END MAKING A SEVERE GRINDING, SQUEAKING, AND KNOCKING NOISE. THE CV AXLE BOOTS ARE DESTROYED AND SEEMS LIKE THE WHEEL BEARINGS AND HUB IS GOING OUT QUICKLY AS WELL. ALSO HAVE TRANSMISSION LEAKAGE AND NOISE WHEN TURNING. VEHICLE ONLY HAS 86,000 MILES ON IT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11185443March 8, 2019
STRUCTURE:BODY, SUSPENSION, UNKNOWN OR OTHER
THE FRAME BY THE DRIVER SIDE FRONT WHEEL IS ALMOST BROKEN IN HALF...IT HAS A 2 FOOT LONG SECTION MISSING...OTHER STEERING COMPONENT AFFECTED STABLIZER BAR ALMOST RUSTED IN HALF..BRACKET AND BUSHING ALMOST NONEXISTENT...THIS IS MY DAILY DRIVER FOR ME,MY WIFE AND MY 10 YEAR OLD DAUGHTER...I FEAR FOR THEIR SAFETY SHOULD IT COMPLETELY LET LOOSE...I DRIVE VERY SLOW...I AM 59 YEARS OLD...PLZ HELP ME GET A NEW FRAMEFROM TOYOTA...THANX
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11180244February 15, 2019
TIRES
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA EQUIPPED WITH DEFINITY DAKOTA H/T TIRES, SIZE: P265/70R17. THE CONTACT STATED THAT ALL FOUR TIRES WOULD DEFLATE RAPIDLY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12T013000 (TIRES). PEP BOYS INSPECTED THE TIRES AND STATED THAT THEY WERE NOT INCLUDED IN THE RECALL. THE CONTACT SHOWED PEP BOYS THE RECALL LETTER AND THEY KEPT IT, STATING THAT THEY HAD NO WAY TO COPY THE LETTER IN ORDER TO RETURN THE ORIGINAL TO THE CONTACT. THE VEHICLE FAILURE MILEAGE WAS 160,000. THE TIRE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11174426February 5, 2019
STRUCTURE:BODY
MY COMPLAINT IS WITH TOYOTA MOTOR COMPANY AND THEIR ADMISSION BUT YET NO RESOLUTION TO A KNOWN PROBLEM. MY STORY OF THIS TOYOTA TRUCK BEGINS WITH MY SON OWNING THIS TUNDRA FOR ABOUT 5-7 YEARS THEN SELLING ME, HIS FATHER THE SAME TUNDRA. BEFORE BUYING SAID TRUCK I WAS ASSURED IT WAS OF GOD STRUCTURAL INTEGRITY, DUE TO AN INSPECTION AT A TOYOTA DEALERSHIP. UPON INSPECTION THEY DID FIND THAT THE FRAME HAD VISIBLE RUST AND PROCEEDED TO TREAT IT WITH ANTI-CORROSION. FORWARD TO THREE WEEKS AGO A LOCAL INSPECTION WAS TO BE DONE IN WHICH I WAS TOLD THAT IT WOULD NOT PASS DUE TO FRAME PROBLEMS AS IT WAS NOT SAFE TO DRIVE. TOYOTA ENGINEERS KNOW THAT THE FRAMES ARE GOING TO RUST BECAUSE NO EXTERIOR APPLICATION OF ANY ANTI-CORROSION IS GOING TO PREVENT ANY CORROSION WITHIN A TUBULAR BOXED FRAME. I WAS REFUSED ANY SOLUTION FROM TOYOTA, WHO HAVE PREVIOUSLY ADMITTED THAT THESE PARTICULAR TRUCKS ALL HAVE THE SAME ISSUE. HOW CAN YOU HELP WITH GETTING TOYOTA TO RESOLVE THIS COMPLETELY INSTEAD OF PASSING THE LITTLE GUY ASIDE?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11171454January 22, 2019
UNKNOWN OR OTHER
WE SENT OUR TRUCK FOR THE INSURANCE (PROGRESSIVE INSURANCE) COMPANY TO THE GARAGE FOR AN ALIGNMENT AND THEY TOLD US THE FRONT/RIGHT SIDE OF THE FRAME IS BROKE. MAKING THE TRUCK UNSAFE TO DRIVE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11165986January 9, 2019
SUSPENSION
THERE WERE 2 ISSUES WITH THE FRAME ON THE 2003 TOYOTA TUNDRA THAT WERE ADDRESSED ON MY SON'S TRUCK WHEN THEY WERE ISSUED. NOW, THE FRAME IS EXTREMELY RUSTED AND POSSIBLY A HAZARD TO DRIVE. THE TRUCK WAS TAKEN TO A LOCAL DEALER WHO DID NOT EVEN LOOK AT THE FRAME BUT, PULLED UP INFORMATION FROM TOYOTA AND TOLD US THAT THERE WAS NOTHING THEY COULD DO. I DO NOT UNDERSTAND AS I SEE OTHERS ONLINE TO THIS DAY GETTING FRAMES REPLACED. I CALLED TOYOTA CORPORATE WHO CLAIMS THAT IS NOT POSSIBLE AS THE FRAME IS NO LONGER AVAILABLE. THIS IS REALLY A POOR WAY TO TREAT CUSTOMERS THAT PAY VERY HEAVILY FOR THESE TRUCKS AND EXPECT THEM TO LAST. THE VEHICLE WAS PURCHASED ORIGINALLY IN NY AND EVENTUALLY PA WHICH ARE THE COLD WEATHER STATES THAT WERE INVOLVED. THE COATING PLACED ON THE TRUCK DID NOTHING AS FAR AS WE CAN TELL AS THERE IS NOTHING THAT SHOWS IT WAS EVER THERE. I HAVE ADDITIONAL DOCUMENTS, VIDEOS, ETC THAT I WAS UNABLE TO UPLOAD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11161917December 17, 2018
STRUCTURE:BODY, SUSPENSION
REAR CROSS MEMBER THAT HOLDS ON SPARE TIRE IS COMPLETELY RUSTED. TOYOTA REFUSES TO REPLACE BECAUSE THE RECALL HAS EXPIRED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11156412December 5, 2018
UNKNOWN OR OTHER
MY TRUCK'S FRAME HAS LARGE, MAJOR RUST PERFORATION HOLES ALL OVER THE FRAME AND WILL SOON NEED REPLACEMENT. I FEEL THAT THIS WILL SOON BE A SAFETY FACTOR, AS THE FRAME IS THE ONLY PART OF THE VEHICLE THAT HOLDS THE TRUCK IN ONE PIECE WHEN DRIVING DOWN THE ROAD. I'M AFRAID MY FRAME WILL NOT PROTECT ME IN A COLLISION AND THAT MY TRUCK MAY SNAP IN HALF DURING NORMAL DRIVING CONDITIONS. TOYOTA CORPORATE HAD ME IMMEDIATELY BRING THE VEHICLE IN TO MY LOCAL DEALER FOR A FRAME INSPECTION AND THE RUST PERFORATION WAS NOTED AND VERIFIED, BUT TOYOTA CORPORATE WILL NOT REPLACE MY FRAME BECAUSE THE AREAS SPECIFIED IN THEIR CURRENT OPEN RECALLS AREN'T AS RUSTED AS WHAT WOULD BE NORMALLY DEEMED QUALIFIED FOR FRAME REPLACEMENT. THE CONDITION OF MY FRAME IS TERRIBLE AND MAY BE CONSIDERED MORE DANGEROUS SOON, COMPARED TO WHAT COULD HAPPEN TO THE FRAME CONCERNS OF THE CURRENT RECALLS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11153974November 26, 2018
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. WHILE THE CONTACT WAS SERVICING HIS VEHICLE, HE LOOKED UNDERNEATH AND NOTICED THAT THE SWAY BAR WAS RUSTED ALONG WITH THE ENTIRE FRAME. THE CONTACT STATED THAT THE VEHICLE EXHIBITED THE SAME SYMPTOMS AS LISTED IN NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11153073November 21, 2018
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. WHILE DRIVING VARIOUS LOW SPEEDS AND APPROACHING A STOP, THE FUEL TANK DETACHED FROM THE VEHICLE AND FELL ONTO THE GROUND. THE CONTACT TEMPORARILY RE-ATTACHED THE FUEL TANK TO THE VEHICLE AND WAS ABLE TO DRIVE HOME. ROMANO TOYOTA (6400 BASILE ROWE, EAST SYRACUSE, NEW YORK 13057, (315) 445-1070) WAS MADE AWARE OF THE FAILURE AND REQUESTED THAT A DIAGNOSTIC TEST BE PERFORMED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). THE FAILURE MILEAGE WAS APPROXIMATELY 155,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11153169November 21, 2018
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. WHILE THE VEHICLE WAS STATIONARY, THE CONTACT NOTICED THAT THE SPARE TIRE WAS ABSENT FROM THE UNDERCARRIAGE OF THE VEHICLE. ALSO, THE SPARE TIRE CARRIER WAS SEVERELY RUSTED AND CORRODED. AS A RESULT, THE SPARE TIRE DETACHED FROM THE VEHICLE WHILE DRIVING VARIOUS SPEEDS. WALDORF TOYOTA (2600 CRAIN HIGHWAY, WALDORF, MARYLAND 20601, (301) 843-3700) WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE EXCEEDED THE THREE YEAR/36,000 MILE WARRANTY COVERAGE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED THE CONTACT WITH CASE NUMBER: 1811171313. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE WAS COATED WITH A PREVENTATIVE RUST PROTECTION ON DECEMBER 24, 2011 PER AN UNKNOWN RECALL THAT EXPIRED. THE FAILURE MILEAGE WAS 453,839.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11143338October 27, 2018
STRUCTURE:BODY, SERVICE BRAKES, SUSPENSION
FRAME CORROSION WAS NOT PROPERLY ADDRESSED DURING 2012 RECALL. AS A RESULT THE FRAME HAS CORRODED IN MULTIPLE AREAS AND THE BRAKES JUST FAILED DUE TO BRAKE LINE CORROSION. TOYOTA IS REFUSING ANY ADDITIONAL CLAIMS FOR DAMAGES. HOWEVER THEY SHOULD HAVE DONE MORE TO ADDRESS THE FRAME CORROSION DURING THE 2012 RECALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11131146September 25, 2018
EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. WHEN THE VEHICLE WAS PREPARING TO UNDERGO A STATE INSPECTION, THE CONTACT WAS INFORMED THAT THE BRAKE AND BACK UP LIGHTS ON TOP OF THE CABIN WOULD NOT ILLUMINATE. WHILE REPLACING THE LIGHT BULBS, THE CONTACT NOTICED THAT THE LIGHT FIXTURES ON BOTH SIDES WERE MELTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 109,000. *DT UPDATED 11/2/18*JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11131494September 25, 2018
STRUCTURE:BODY
AFTER MECHANIC RECENTLY INSPECTED UNDER SIDE, IT WAS FOUND THAT THE FRAME HAD SIGNIFICANT RUST AND ROT. FRAME IS NOT EXPECT TO MAINTAIN STRUCTURE FOR VERY LONG.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11121088August 20, 2018
POWER TRAIN, STEERING, UNKNOWN OR OTHER
STEERING COLUMN SHIFT BRACKET BROKE IN 3 PLACES WHEN TRYING TO SHIFT FROM PARK TO DRIVE, MAKING SHIFTING IMPOSSIBLE. SEE PICTURES FROM 2 OF 3 FRACTURE LOCATIONS, 3RD FRACTURE IS AT AN ATTACHMENT SCREW (NOT SHOWN). THIS IS CAUSE BY AN PUNDERDESIGNED PART MADE OF INFERIOR CAST ALUMINUM. THERE ARE THOUSANDS OF REPORTS OF THIS PROBLEM ON TUNDRAS AND OTHER TOYOTA MODELS WITH SAME DEFECTIVE BRACKET. THIS DANGEROUS DEFECT MUST BE RECALLED AND FIXED BY TOYOTA WITH A REDESIGNED PART.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11120683August 17, 2018
SUSPENSION
TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE BALL JOINT WAS FAULTY, RUSTED, AND COULD NO LONGER SUPPORT THE FRONT DRIVER'S SIDE OF THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 133,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra