Toyota Tundra Complaints (2012)

156 consumer complaints on file.

#11300877January 21, 2020
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2012 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE WAS AT STAND STILL, THE IGNITION HESITATED TO START THE VEHICLE. THE CONTACT STATED HE REPLACED THE BATTERY BUT CONTINUED TO EXPERIENCE THE FAILURE. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC AND HAD THE STARTER AND ALTERNATOR INSPECTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED AS OF YET. A DEALER WAS NOT CONTACTED. THE VEHICLE CONTINUE TO EXPERIENCE THE FAILURE. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 86,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11300231January 18, 2020
ENGINE, FUEL/PROPULSION SYSTEM
MY TRUCK HAS BEEN HAVING HARD START ISSUES SINCE WINTER 2017. I FIGURED IT WAS MY BATTERY SO I REPLACED IT, BUT IT DIDNT HELP. THE HARD START WASN'T CONSISTENT SO I CHOSE TAKE SOME TIME TO SEE IF ANY OTHER PROBLEMS SURFACED. GOT THROUGH WINTER 2018 AND SPRING/SUMMER 2019 WITH IT STILL STARTING ROUGH ON OCCASION. BY OCTOBER 2019 MY TRUCK REACHED APPROX 78K MILES, AND ONE DAY IT DIDN'T START AT ALL. TOOK THREE TRIES TO GET IT GOING. I HAD THE BATTERY CHECKED ONCE AGAIN. IT TESTED BAD BUT IT WAS UNDER WARRANTY SO I HAD I LT SWAPPED OUT. THE PROBLEM PERSISTED. THIS TIME IT GAVE ME AN ENGINE LIGHT. MECHANIC SAID IT WAS AN 'EVAP CODE' AND RECOMMENDED I REPLACE THE GAS CAP TO START. CODE DIDNT RETURN BUT STILL HARD STARTING. TOOK ALMOST TWO MONTHS AND ENGINE LIGHT CAME BACK ON. THIS TIME P1604 STARTABILITY MALFUNCTION. WAS TOLD I HAD TO TAKE IT TO TOYOTA TO GET A REFLASH. I DECIDED TO DO SOME RESEARCH AND CAME ACROSS THE PROBLEMS TUNDRA OWNERS WERE HAVING WITH THIS FFV DENSITY SENSOR MALFUNCTION. PRINTED THE OLD SERVICE BULLETINS AND WENT TO TOYOTA TO TALK TO SERVICE DEPT ABOUT IT. THEY SAID TOYOTA JUST PUT OUT A NEW SERVICE BULLETIN IN DECEMBER 2019 FOR THE REFLASH BUT NOW ALSO REPLACING THE FUEL PUMP (TOYOTA TOLD ME DENSITY SENSOR ATTACHED TO THE PUMP). UNFORTUNATELY TOYOTA ALSO TOLD ME THEY WON'T COVER THE COST SINCE MY TRUCK HAD JUST GONE OVER 80K MILES, AND THEY ARE NOT FLEXIBLE WITH THAT AT ALL, EVEN THOUGH I TOLD THEM IT STARTED BEFORE 80K. T-SB-0166-19. SO I GOT PRICES. THE REFLASH IS ABOUT $140 AND JUST THE COST OF THE PUMP ITSELF IS $600, NOT INCLUDING LABOR. I HAVE SPOKEN TO THE TOYOTA USA CUSTOMER CARE TEAM AND THEY SAID THEY CANT HELP ME SINCE I DIDNT TAKE IT TO THE DEALER TO DIAGNOSE IT. APPARENTLY IT DOESNT MATTER IF YOU HAVE SERVICE RECORDS FROM ANOTHER SHOP. THIS IS MY 3RD TOYOTA, AND I LOVE MY TRUCK SO THIS BREAKS MY HEART.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11291204December 25, 2019
ENGINE
WHEN DRIVING MY CHECK ENGINE AND "TRAC OFF" LIGHT COMES ON AND THE ENGINEER WILL NOT ACCELERATE ABOVE THIRTY MILES AN HOURS. IF YOU DISCONNECT THE BATTERY AND RESET THE COMPUTER IT WILL WORK FOR ABOUT THREE MILE THEN THE CHECK ENGINE AND "TRAC OFF" LIGHT COMES ON. THIS IS THE SAME INDICATION EARLIER TUNDRA MODELS HAVE WITH SECONDARY AIR INJECTORS RECALL. AN IT IS WIDELY DOCUMENTED ONLINE AS A PROBLEM FOR 2012 TUNDRA'S. YET TOYOTA CONTINUES TO DENIES IT'S A PROBLEM AND IS NOT COVERED UNDER THE RECALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11288883December 13, 2019
SEAT BELTS
TL* THE CONTACT OWNS A 2012 TOYOTA TUNDRA. THE CONTACT STATED THAT THE DRIVER'S SIDE SEAT BELT BUCKLE FAILED TO LATCH ON SEVERAL OCCASIONS. THE CONTACT STATED THAT THE SEAT BELT TONGUE WAS NOT ABLE TO ENTER THE BUCKLE TO BE LATCHED. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. *BF*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11280445November 15, 2019
ENGINE
DRIVING IN HIGHWAY TRAFFIC AND ENGINE REDUCES POWER SIGNIFICANTLY CAUSING THE VEHICLE TO RAPIDLY SLOW DOWN AND BECOME A HAZARD IN TRAFFIC. TOOK IT TO DEALERSHIP AND THEY SAID THE SECONDARY AIR INJECTION SYSTEM NEEDS TO BE REPLACED FOR $3300. THIS IS A KNOWN DEFECT FOR THE PREVIOUS MODEL YEAR. I CONTACTED TOYOTA HQ AND THEY REFUSED TO COVER REPAIRS FOR THIS KNOW DESIGN DEFECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11268636October 15, 2019
ENGINE
* ONGOING MANUFACTURE DEFECT / SAFETY CONCERN WITH 2012 TOYOTA TUNDRA 4.6. CODE P2440, SECONDARY AIR INJECTION. BANK ONE OPEN.---CHECK ENGINE / TRAC OFF LIGHTS / ENGINE IN "LIMP MODE" * DOCUMENTED RECURRING INCIDENTS ON 4-2-19 AND AGAIN ON 10-12-19 AFTER COSTLY OUT OF POCKET REPAIR. * MY 2012 TOYOTA TUNDRA 4.6 MOTOR DOUBLE CAB HAS EXPERIENCED THE AIR INJECTION PUMP FAILURE TWICE IN A SIX MONTH PERIOD. THIS FAILURE IS A SAFETY HAZARD LEADING TO LOSS OF POWER AND VEHICLE CONTROL. THE FIRST OCCURRENCE WAS AFTER A 2,000 MILE TRIP. DRIVING DOWNHILL THE DASH LIGHTS (CHECK ENGINE / TRAC OFF) CAME AT HIGHWAY SPEED AND IMMEDIATELY VEHICLE POWER REDUCED AS WE TRIED TO POWER UP THE NEXT HILL. WE WERE ABLE TO AVOID BEING RUN OVER BY FOLLOWING VEHICLES BY PULLING OFF THE ROAD, AND LIMPED TO THE NEAREST MECHANIC SHOP. CONTACTED 3 DEALERS AND TOYOTA CORPORATE WITH NO POSITIVE OUTCOME. ALL PARTIES ACKNOWLEDGE THE ONGOING DEFECT BUT WILL NOT PAY OR OFFER A SOLUTION TO END THE PROBLEM. PAID OUT OF POCKET FOR EXPENSIVE REPAIR. THE 2ND OCCURRENCE SIX MONTHS LATER FOUND US AGAIN UNABLE TO REACH OR MAINTAIN SAFE HIGHWAY SPEEDS. AVOID DANGEROUS HIGHWAY SITUATIONS, OR ABILITY TO CLIMB HILLS. BOTH INSTANCES OCCURRED WITHOUT WARNING. * THIS EMISSION CONTROL DEFECT THAT TOYOTA HAS KNOWN ABOUT SINCE THE 2007 MODELS. THEY EVEN EXTENDED THE WARRANTY THROUGH THE 2011 MODEL YEAR. TOYOTA ALSO CLAIMS THE PROBLEM IS NEITHER DRIVE-TRAIN NOR EMISSIONS RELATED. AFTER MANY ATTEMPTS AT THE DEALER AND CORPORATE LEVEL, TOYOTA REFUSES TO EXTEND REPAIRS FOR THIS WELL DOCUMENTED DEFECT BEYOND THE 2011 MODEL. TOYOTA SUGGESTS THAT WHEN ENOUGH COMPLAINTS ARE RECORDED, THEY WILL EXTEND THE WARRANTY ON NEWER MODELS. THE LACK OF SUPPORT FROM DEALERS AND CORPORATE TOYOTA IS ALARMING. THE REPAIR OUT OF POCKET IS EXPENSIVE (FROM $500 FOR A TEMPORARY REPAIR TO $4000 FOR A REPLACEMENT FROM THE DEALER.)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11265884October 3, 2019
SUSPENSION
THE REAR LEAF SPRING BREAKING IN HALF FOR BOTH SIDES WITHOUT ANY EXTRA WEIGHT ON EXCEPT THE PASSENGERS AS RECOMMENDED BY THE MANUFACTURER. REGULAR DRIVING CONDITIONS, BOTH HIGHWAY AND STREET.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11258868September 29, 2019
AIR BAGS, STEERING
AIR BAG CLOCK SPRING BAD HORN DOES NOT WORK BUT WHEN YOU STEERING THE CAR LEFT OR RIGHT HORN WORKS NORMAL
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11257705September 24, 2019
ENGINE, POWER TRAIN, UNKNOWN OR OTHER
WHEN CRANKING THE VEHICLE ALL OF A SUDDEN AS OF 5 DAYS AGO THE CHECK ENGINE LIGHT APPEARS ALONG WITH 'TRACK OFF' INDICATOR. THIS THROWS THE TRUCK IN 'LIMP' MODE DECREASING THE POWER OF THE VEHICLE BY 50%. THIS HAPPENED THE FIRST MORNING AND I WAS ENTERING A ON RAMP TO GET ON THE HIGH FROM MY NEIGHBOR AND ALMOST GOT PLOWED OVER DUE TO NOT BEING ABLE TO PROPERLY ACCELERATE TO HIGHWAY SPEEDS WHILE ENTERING THE RAMP. I HAD A TECHNICIAN CHECK THE ISSUE AND WAS TOLD IT HAS TO DUE WITH THE 'SECONDARY AIR INJECTION VALVE' FAILING. AFTER ABOUT FOUR DAYS OF RESEARCH I FOUND THIS IS A COMMON PROBLEM IT NOT JUST MY VEHICLE BUT MULTIPLE YEARS AND MOTOR SIZES. TOYOTA APPARENTLY COVERED CERTAIN YEAR MODELS/VINE BUT WHEN CALLING REGARDING MINE THEY SAID MY VEHICLE WASN'T COVERED EVENING THOUGH THERE ARE THOUSAND OF CONSUMERS HAVING THE EXACT SAME ISSUE. THIS ISSUE IS ALSO AN EXPENSIVE REPAIRS COST UPWARDS TO $3,500-$400 TO FIX. TOYOTA IS AWARE OF THE PROBLEM AND APPARENTLY DOESN'T CARE THAT IT ALSO CAUSE SAFETY ISSUES WITH THE VEHICLE NOT HAVING PROPER POWER TO OPERATE. THIS IS A MANUFACTURING DEFECT PLAN AND SIMPLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11245782August 22, 2019
ENGINE
THIS COMPLAINT IS THE SAME AS MANY I SEE HERE AND ACROSS THE INTERNET. DRIVING ON THE WASHINGTON DC BELTWAY AND MY 2012 TUNDRA GOES INTO LIMP MODE WHICH REDUCED MY POWER SIGNIFICANTLY CAUSING A UNSAFE SITUATION TO SAY THE LEAST.. DEALER SAID PROBLEM WAS WITH SECONDARY AIR INJECTION SYSTEM AND THE REPAIR WAS VERY EXPENSIVE. NOW 12 MONTHS LATER THE TRUCK IS HAVING THE SAME PROBLEMS. THIS IS AN INFERIOR SYSTEM THAT TOYOTA SHOULD STAND BEHIND AND COVER ALL THE COSTS ASSOCIATED WITH FIXING INSTEAD OF CHARGING TUNDRA OWNERS AFTER THEY'VE ALREADY SPENT HARD EARNED MONEY ON THE VEHICLE PURCHASE. THIS IS A WIDE SPREAD PROBLEM THAT TOYOTA IS NOT OWNING UP TO.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11234781July 25, 2019
ELECTRONIC STABILITY CONTROL (ESC), ENGINE
I WAS COMING OFF AN ENTRANCE RAMP MERGING INTO TRAFFIC ON TO A 4 LANE HIGHWAY WHEN MY CHECK ENGINE LIGHT, TRAC OFF LIGHT AND BLINKING 4 LOE CAME ON. THE ENGINE WENT INTO LIMP MODE GREATLY REDUCING MY POWER AND IT FELT LIKE MY STEERING CONTROL GOT LOOSE. I HAD TO PULL OFF THE ROAD TO KEEP FROM BEING RUN OVER BY FASTER TRAFFIC. I WAS ABLE TO MAKE IT TO THE NEXT OFF RAMP AND GET TO A MECHANICS SHOP. THEY HOOKED UP A ANALYSIS COMPUTER AND CAME BACK WITH MAINTENANCE CODE P2432, SECONDARY AIR PUMPS AND SECONDARY AIR PUMP VALVES. UPON FURTHER RESEARCH OF THIS ISSUE I HAVE FOUND OUT THAT THIS HAS BEEN AN ONGOING ISSUE WITH TOYOTA TUNDRAS GOING BACK TO 2007 MODELS. THE WARRANTY HAS BEEN EXTENDED ON 2007 - 2010 MODELS BUT NOT NEWER MODELS WHICH ARE STILL EXPERIENCING THE SAME PROBLEM. MY VEHICLE IS CONSIDERED LOW MILEAGE FOR A 2012 WITH ONLY 79,786 MILES. I FEEL THIS PROBLEM CONSTITUTES A POTENTIALLY DANGEROUS SAFETY HAZARD DUE TO THE DRASTIC REDUCTION IN POWER WHICH COULD CAUSE AN ACCIDENT DEPENDING ON WHEN THE PARTS IN QUESTION FAIL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11231785July 14, 2019
STEERING
TOYOTA TUNDRA POWER STEERING RACK AND PINION FAILURE. WHILE DRIVING MY TRUCK THE POWER STEERING RACK AND PINION FAILED. I HEARD A POP SOUND AND PULLED OFF THE CITY ROAD TO INSPECT MY VEHICLE. UPON DOING SO I NOTICED THE STEERING WAS DIFFICULT TO MANIPULATE AND UPON INSPECTION FOUND POWER STEERING FLUID ACTIVELY LEAKING OUT OF THE FRONT PASSENGER SIDE BELLOWS BOOT. MY VEHICLE HAD APPROXIMATELY 47,000 MILES AT THIS TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11222498June 25, 2019
ELECTRONIC STABILITY CONTROL (ESC), ENGINE, UNKNOWN OR OTHER
SECONDARY AIR INJECTION PUMP AND SECONDARY AIR INJECTION SWITCHING VALUE CAUSING CHECK ENGINE AND TRAC CONTROL LIGHTS TO COME ON. I WAS TOLD BY THE DEALER THAT THE SAME PIECE AND DESIGN WAS RECALLED ON THE 2011 BUT NOT THE 2012 TUNDRA. IT COMES ON AND OFF BUT WHEN IT IS ON IT FEELS LIKE THAT THERE IS A LIMP MODE MAKING IT DIFFICULT TO GET UP TO SPEED ON THE HIGHWAY. THE STEERING FEELS DIFFERENT WHICH I THINK IS THE TRACTION CONTROL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11220491June 16, 2019
ENGINE, UNKNOWN OR OTHER
SECONDARY AIR PUMP AND CONTROL VALVES FAILING AND THIS IS A ON GOING ISSUE WITH THESE TRUCKS ALMOST $3000 TO FIX
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11206772May 10, 2019
FUEL/PROPULSION SYSTEM
MY 2012 TUNDRA HAS JUST UNDER 70,000 MILES ON IT AND THE TRAC LIGHT AND ENGINE LIGHT CAME ON YESTERDAY. HAD IT LOOKED AT AND THE MECHANIC SAYS THE PROBLEM IS WITH THE SECONDARY AIR PUMP AND IT IS A KNOWN PROBLEM. CALLED THE DEALER AND THEY KNEW OF THE PROBLEM AND TOLD ME THERE IS A CSP THAT COVERS CERTAIN 2012 TUNDRA'S. UNFORTUNATELY THE CSP ONLY COVERS THE 5.7 L. ENGINES AND NOT MY 4.6L MODEL. MY MECHANIC SAYS THAT EVERYTHING IS THE EXACT SAME SET UP AS FAR AS THE SECONDARY AIR PUMP, IT'S JUST A DIFFERENT SIZE ENGINE. NOT SURE WHY ONE IS COVERED BUT THE OTHER ISN'T BUT I'LL HAVE TO SUCK IT UP AND PAY THE PRICE. MAYBE IF MORE PEOPLE MAKE TOYOTA AWARE OF THIS THEY WILL EVENTUALLY COVER IT. I'M A TOYOTA FAN AND HAVE BEEN DRIVING THEM FOR 40 YEARS AND THIS WON'T PUSH ME AWAY BUT IT IS DISAPPOINTING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11203876April 26, 2019
ENGINE
P0418 SECONDARY AIR INJECTOR RELAY A MALFUNCTION. CHECK ENGINE LIGHT IS ON
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11203020April 22, 2019
ENGINE
I WAS PULLING OUT OF WORK. YOU MUST CROSS 3 LANES OF TRAFFIC PLUS THE CENTER MEDIAN TO TURN LEFT. THIS IS A CITY STREET. SPEED LIMIT IS 45 I BELIEVE WITH MANY VEHICLES GOING FASTER. VEHICLE HAD THE SMOG AIR INJECTION PUMPS AND VALVES FAIL. THIS CUTS POWER DRASTICALLY TO THE ENGINE AND PUTS IT INTO LIMP MODE. I WAS FORCED TO SWERVE BACK INTO AND STAY IN THE CENTER MEDIAN INSTEAD OF MERGE INTO TRAFFIC AS THE VEHICLE HAD LITTLE POWER. I WAS ABLE TO WAIT FOR A BIGGER GAP IN TRAFFIC AND LIMP THE VEHICLE TO THE REPAIR SHOP. I BELIEVE THIS COULD BE DEADLY SHOULD IT OCCUR IF TRYING TO GET ON THE FREEWAY OR PULLING A TRAILER AND THE ENGINE CUTS POWER DRASTICALLY. TOYOTA HAS A LONG HISTORY OF ISSUES WITH THESE PARTS FAILING GOING BACK TO 2007 AND POSSIBLY EARLIER. THERE IS NO NEED FOR A SMOG PUMP FAILURE THAT ONLY RUNS FOR 2 MINUTES ON COLD START TO DRASICALLY CUT ENGINE POWER AND ENDANGER THE DRIVER AND OTHER MOTORISTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11202842April 22, 2019
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM, VEHICLE SPEED CONTROL
CHECK ENGINE LIGHT CAME ON.THE CODE SHOES P0418 AIR INJECTION VALVE/PUMP. 76,000 MI ON ENGINE. CRUISING DOWN INTERSTATE LOST POWER. TOYOTA EXTENDED WARRANTY UP TO 2011 MODELS.KNOWN PROBLEM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11195714April 11, 2019
ENGINE, FUEL/PROPULSION SYSTEM
WHILE DRIVING, MULTIPLE DASHBOARD LIGHTS CAME ON AND MY TRUCK WENT INTO "LIMP MODE," MEANING I LOST ALMOST ALL POWER WHILE DRIVING IN HEAVY TRAFFIC. TURNS OUT THIS IS AN ISSUE WITH THE AIR INJECTION PUMP, WHICH IS A KNOWN PROBLEM IN TOYOTA TUNDRAS. I BELIEVE THIS IS A SAFETY ISSUE THAT TOYOTA NEEDS TO ADDRESS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11195048April 9, 2019
FUEL/PROPULSION SYSTEM
AT FIRST I STARTED HEARING WHAT SOUND LIKE A FAN RUNNING UNDER THE HOOD AFTER I STARTED MY TRUCK. ABOUT A WEEK LATER MY CHECK ENGINE LIGHT CAME ON FOLLOWED BY THE TRACK LIGHT. CODE P2442 WHICH STATED THAT THE AIR INJECTOR PUMPS AND VALVES WERE FAILING. WE BROUGHT THE TRUCK TO TOYOTA AND THEY HAD TOLD US THAT IT WOULD COST US 4000.00 TO GET IT FIXED, AFTER CHARGING US 144.72 TO HOOK A CODE READER TO IT WHICH WOULD OF COST US NOTHING TO TAKE IT TO AUTO ZONE. OUR WARRANTY WAS SUPPOSED TO COVER BUMPER TO BUMPER UP 10YRS OR 100,000 MILES WITH EVER CAME FIRST. THEY TOLD US THAT OUR WARRANTY EXPIRED THE WEEK BEFORE WE BROUGHT IT IN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra