Toyota Tundra Complaints (2005)

377 consumer complaints on file.

#11437867October 23, 2021
SERVICE BRAKES, SUSPENSION
I dont know exactly is the front ball joint or something else but something happen when run and stop the tundra, all the time hear a noise how to something is broke
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11437439October 20, 2021
STRUCTURE:BODY
This vehicle was purchased as a certified used vehicle from Johnston Toyota. It was recalled by Toyota for a rust problem. In October 2014 the vehicle was treated by the dealer (Johnston Toyota) with a rust inhibiting compound due to the rust problem. Approximately 1-2 years ago this vehicle was inspected by an independent mechanic who stated that the vehicle was badly rusted, and he believed that Toyota had a program to address this issue. I spoke to the Toyota service department and I was told that this vehicle is not covered. Approximately 2 weeks ago an independent mechanic advised the rust problem is extensive and the vehicle will be unsafe to operate. Although Toyota advises that this is a widespread problem for this type vehicle, they refuse to address it. Furthermore, when I asked them why the rust inhibiting compound they used to correct the problem did not solve the issue, they further refuse to respond.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11433998September 23, 2021
STRUCTURE
The contact owns a 2005 Toyota Tundra. The contact stated that while the vehicle was in for the state inspection, it was discovered that the subframe had sustained severe rusting and corrosion causing the vehicle to fail the state inspection. The cause of the rusting and corrosion was not determined. The local dealer and manufacturer were notified of the failure. The contact indicated that the vehicle was previously treated with a rust inhibitor coating, but the failure still occurred. The failure mileage was 311,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11431418September 1, 2021
SERVICE BRAKES, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
Gas tank Strap rusted thru and broke. Brake lines rusted thru and leaked Differential rusted thru and leaked. Frame excessively and extensively rusted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11428481August 10, 2021
SUSPENSION, SERVICE BRAKES
The leaf springs have broken and frame is showing serious rust damage. Brake lines were leaking and had to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11426572July 26, 2021
STRUCTURE:BODY
Frame is rusted. Whole on front passenger side frame.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11426059July 22, 2021
STRUCTURE:BODY
FRAME IS VERY RUSTY. STRAP HOLDING FUEL TANK IS DANGEROUS , REAR SUSPENTION ,AND SHOCKS BROKEN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11420939June 14, 2021
UNKNOWN OR OTHER, STRUCTURE:BODY
I seen that Toyota were recalled for the frame issues on 2004 and up, mine is 2005 tundra with frame issues, like it’s sad, such a nice truck, but frame is horrible. Why is mine not being shown as recalled, but yet I have frame problems? I got my truck from a 1 owner who had it since new, it just hit 100,000 miles on it, it was serviced by Toyota dealership, I’m not sure why they didn’t do nothing with it over the years to help or fix the rust issue on the frame. It’s not just a little rusty, it’s really rusty, and it was garage kept too. Did they forget to include my vin number when they started the recalls? Doesn’t make sense why they would fix some and not all, all around the same years. Thanks Jim
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11419380June 2, 2021
SUSPENSION, UNKNOWN OR OTHER
Perforations in frame along seams due to rust isolated to the driver side front frame rail. Toyota is aware of this problem and refuse service and repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11418258May 24, 2021
STEERING
Ever since I got it 2 years ago the steering has not been right with random vibration from the steering wheel to feeling like im trying harder to make it go straight. And also a clunk at low speed turns/ vibration on freeway. I was told the rack was going so I replaced it with new poly bushings and tie rods. Helped a little but no, got new rims and tires and no difference still vibration on freeway. It's weird if I pull down on the steering wheel it makes it less worse. Also it feels like all this is wearing my power steering pump as it's the only thing covered in oil under my hood. I'm. Seriousy scared to drive it on the freeway cause of the over correcting and vibration. I only have 82k on it. When I got it from the dealership nothing was said. I'm the second owner.I still have the original rack but the problem is still there. Service was done by independent shop. Airbag stickers on passenger visor are gone and passenger airbag cover sticks out more the it should I think. I received the car facts from the dealership and nothing is in there for all the recalls. As the website says there are none pending. I would like to get a print out of ALL recall repairs if possible. I still have the car fax from them.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11417915May 20, 2021
SUSPENSION, STRUCTURE:BODY, POWER TRAIN
The frame has several holes in it. Toyota said they did the corrosion prevension on it and said the repair is out of warranty. The sway bar has broken free of the frame and there are several hole and flaking spots on the frame.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11413421April 22, 2021
STRUCTURE:BODY
DISCOVERED SEVERE RUST THROUGH ON THE UNDERSIDE FRAME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11406794April 6, 2021
STRUCTURE:BODY, SUSPENSION, UNKNOWN OR OTHER
2005 TUNDRA FRAME IS RUSTED IN MANY PLACES. VERY BAD WHERE FRAME SECTIONS MEET AND NOW THE FRAME IS RUSTING THROUGH THE MAIN HORIZONAL FRAME ITSELF AS THE ATTACHED PICTURE INDICATES. THIS HAS BEEN AN ONGOING ISSUE FOR YEARS BUT IS BAD ENOUGH NOW THAT IT IS NOT SAFE AND WILL NOT PASS INSPECTION. I KNOW THERE WAS A RECALL ON THIS FRAME AND I WAS TOLD IT WAS OK WHEN I BROUGHT IT IN FOR THE RECALL. I T HAS BEEN RUSTING EVER SENSE. WE HAVE ONLY PURCHASED TOYOTAS AND LEXUS VEHICLES FOR THE LAST 20 OR MORE YEARS AND THIS IS THE THIRD TRUCK RUST HAS TOTALED. PLEASE HELP
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11406801April 6, 2021
STRUCTURE:BODY
I PURCHASED A 2005 TOYOTA TUNDRA UNAWARE OF THE WIDE-SPREAD RUST ISSUES THIS MODEL FROM TOYOTA IS SUFFERING. THE VEHICLE CAME WITH AN INSPECTION STICKER FROM THE DEALER SO IT WAS WELL PAST THE DEALER'S WARRANTY WINDOW TO DO ANYTHING ABOUT THIS ONCE I FOUND OUT ABOUT THE ISSUE. THE VEHICLE WAS PURCHASED IN MAINE AND WAS SOLD TO ME IN NEW YORK. I WAS INFORMED BY MY MECHANIC THAT THERE ARE 4 SERIOUS RUST ISSUES PRESENT ON THE VEHICLE THAT PREVENT IT FROM PASSING INSPECTION. 1) A LARGE SEVERAL SQUARE INCH PERFORATION IN THE CENTER OF THE FRAME MEMBER 2) "PANCAKING" PRESENT ON A LARGE SECTION OF THE FRAME 3) A LARGE PERFORATION IN ONE OF THE FRAME'S CROSS MEMBERS 4) A SIGNIFICANTLY RUSTED BODY MOUNT SOMEHOW, ONLY MODEL YEARS 2000-2003 WERE RECALLED FOR THE TUNDRA BY TOYOTA, AS IF THE REST OF THE GEN 1 TUNDRAS DIDN'T HAVE THE EXACT SAME FRAME PART NUMBER. WORSE YET, I REGISTERED ON TOYOTA.COM AND FOUND THAT THE PREVIOUS OWNER REQUESTED A FRAME REPLACEMENT 60,000 MILES AGO IN 2014. TOYOTA DID NOTHING AND INSTEAD APPLIED A "CRC" OR CORROSION RESISTANT COMPOUND TO THE TRUCK. BASED ON WHAT I'VE READ ONLINE THE APPLICATION OF THIS COATING THIS CAN MAKE YOUR TRUCK INELIGIBLE FOR THE RECALL SERVICE THIS ISSUE EFFECTIVELY TOTALS THE TRUCK AS IT WON'T PASS A SAFETY INSPECTION WITHOUT RECTIFYING THIS ISSUE. I AM IN QUITE AN UNFORTUNATE SITUATION AS A RESULT AS THIS IS MY ONLY VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11403240March 16, 2021
STRUCTURE:BODY, SUSPENSION
LIMITED SERVICE CAMPAIGN DSD 2004-11006 TUNDRA FRAME INSPECTION. I BOUGHT AN 05 TUNDRA LAST YEAR. CALLED TOYOTA AND THEY SAID THIS RECALL IS OVER. MY FRAME NEEDS REPAIRING. THEY ARE NOT HELPING. DO I HAVE ANY RECOURSE?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11399878March 9, 2021
STRUCTURE:BODY, POWER TRAIN, SUSPENSION
WHILE DRIVING DOWN THE ROAD MY SPARE TIRE MOUNT FAILED DO TO RUST CORROSION CAUSING MY SPARE TIRE TO FALL OFF OF MY VEHICLE. UPON INSPECTION THE ENTIRE REAR FRAME AS WELL AS PARTS OF THE FRONT ARE CORRODED AND FLAKING CHUNKS OF METAL OFF. THIS RUSTING ALSO AFFECTS SUSPENSION MOUNTS AND THE ENTIRETY OF THE REAR AXLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11399055March 4, 2021
STEERING, SUSPENSION
CATASTROPHIC BALL JOINT FAILURE (DRIVER SIDE UPPER BALL JOINT) WHILE DRIVING AT SLOW SPEED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11396960February 19, 2021
SUSPENSION
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED WHILE DRIVING 40 MPH, THE DRIVER'S SIDE FRONT BALL JOINT BENT UNDERNEATH MAKING THE VEHICLE DIFFICULT TO STEER. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR AN INDEPENDENT MECHANIC TO BE DIAGNOSED OR REPAIRED. THE CONTACT REPLACED THE PART HIMSELF. THE FAILURE RECURRED WITH THE FRONT PASSENGER'S SIDE BALL JOINT BEING BENT. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 300,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11383049December 11, 2020
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT WHEN THE VEHICLE WAS INSPECTED, HE LEARNED THAT THE VEHICLE WAS SEVERELY RUSTED. THE CONTACT CONTACTED DCH AUTO GROUP (955 U.S. 9, SOUTH AMBOY, NJ 08879; (877) 324-2886) WHO INFORMED THE CONTACT THAT PARTS OF THE VEHICLE HAD RUSTED THROUGH AND THE VEHICLE WAS NOT SAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND OPENED CASE. THE APPROXIMATE FAILURE MILEAGE WAS 193,000.*DT *TR*DT*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11376469November 26, 2020
STRUCTURE:BODY
I PURCHASED TRUCK 2 YEARS AGO WITH A INSPECTION STICKER GOOD FOR 5 OR 6 MONTHS. WHEN INSPECTION WAS DUE I BROUGHT IT INTO HAVE IT INSPECTED. IT WOULDN'T PASS INSPECTION DO TO THE ADVANCED STATE OF CORROSION. I WAS TOLD THAT THERE WAS RECALL FOR FRAME REPLACEMENT DUE TO THIS PROBLEM AND ALL THESE TRUCKS ARE RUSTING OUT AND MANY STILL ON RD PUTTING LIVES IN JEOPARDY AS THOUSANDS ARE UNSAFE GOING DOWN HIGHWAYS. I BROUGHT IT INTO BERLIN TOYOTA IN PORTLAND ME ON RIVERSIDE DR. THEY BROUGHT ME TRUCK IN AND DID THE INSPECTION AND AGREED FRAME WAS NOT SAFE. THEY SAID MY TRUCK HAD TOO MANY MILES ON IT. I ASKED ABOUT THIS SAME TOYOTA THAT THEY BOUGHT BACK FROM A CUSTOMER WITH OVER A MILLION MILES ON IT ORIGINAL DRIVE TRAIN AND THEY HAVE BRAGGED THAT THESE TRUCK GO MORE THAN A MILLION MILES IF MAINTAINED PROPERLY. THEY KEPT TRYING TO TALK ME INTO BUYING A NEW TRUCK AND WERE ADAMANT ABOUT MY MILES BEING TOO HIGH. 220,009 MILES PLUS OR MINUS THIS WAS JUST OVER A YEAR AGO. I EXPLAINED TO THEM THAT I STILL OWED CLOSE TO 10,000 FOR THIS VEHICAL AND THAT THEY NEEDED TO STAND BEHIND IT. WELL LEFT EMPTY HANDED AND WENT BACK TO MY MECHANIC AMD TOLD HIM WHAT WAS SAID. HE INFORMED ME THAT THAT WAS RIDICULOUS BECAUSE HE HAD A CUSTOMER COME IN LAST WEEK THAT JUST HAD THEIR FRAME REPLACED AT 300,000 MILES AND IM JUST GETTING BLOWN OFF BY THEM. A YEAR LATER AMD I CANT EVEN GET TOYOTA TO RESPOND. THEY KEEP SENDING ME RECALL INFO ABOUT AIRBAG RECALL BUT WON'T ACKNOWLEDGE THE FRAME RECALL. ABOUT TWO WEEKS AGO MY MECHANIC CALLED ME TO SEE IF THEY REPLACED MY FRAME YET AND TOLD HIM NO. HE SAID THAT REALLY STRANGE BECAUSE HE'S HAD 3 CUSTOMERS OVER PAST 6 MONTHS WITH SAME TRUCK SAME YEAR AMD THEY WERE ABLE TO GET THEIR FRAMES REPLACED BY TOYOTA AND THEIR MILEAGE WAS AROUND THE SAME WITH THE EXCEPTION OF ONE BEING ALMOST 290,000. IM A SINGLE PARENT WITH CHILDREN AND IM MAKING PAYMENTS ON THIS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra