Toyota Tacoma Complaints (2010)

294 consumer complaints on file.

#11766074September 22, 2026
UNKNOWN OR OTHER
The vehicle's structure (frame) is failing. A recall for corrosion susceptibility was disseminated for the make and model of my vehicle. A coating was applied to the frame, and I was then told by Malloy Toyota that rust will now NOT become a problem for the frame, as "it's been properly treated according to Toyota's standards following the recall." However, upon State Inspection yesterday, 9/21/26, I was told that much Rust Damage exists on the frame. The vehicle is available now for immediate inspection. My safety is immediately put at risk because I'm driving a vehicle whose structure is now compromised by the recall Toyota said they "prevented" and therefore fixed. The problem has indeed been confirmed by an independent service center. The vehicle has only been inspected by the independent service center for VA State Inspection. No warning indicating that the vehicle's frame was rusting. The issue was first brought to my attention after yesterday's VA State Inspection on 9/21/26
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759154August 24, 2026
STRUCTURE
The contact owns a 2010 Toyota Tacoma. The contact stated that while the vehicle was in for inspection, the mechanic informed the contact that the entire subframe was rusted. The contact was advised that the vehicle was unsafe to drive due to the rust on the subframe. The cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer and local dealer were contacted and informed the contact that the extended warranty for the failure had expired. No additional assistance was provided. The failure mileage was 49,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758737August 22, 2026
STRUCTURE:BODY
Took 2010 Toyota Tacoma to independent garage for a problem with tire pressure sensor. The sensor was fixed, however employee of the garage made us aware that there was substantial rust/corrosion on the Tacoma frame. Have made 2 calls this last week to the Toyota Customer Relations/Brand Engagement specialist. Gave the representative all information that we have on the truck and talked to them about the rusted/corroded frame. They had stated that on our particular vehicle that Toyota had sent us out on 11/2017 and 11/2018 a warranty enhancement letter that had addressed this problem. We have never received either of these communications from Toyota, because if we had, we would have pursued this information with them. The main reason I know we would have pursued this, is that prior to the purchase of this truck we owned a 2000 Toyota Tacoma with a rusted frame recall and was able to have that issued resolved with Toyota. Toyota now says that the Warranty Enhancement program has expired, and there is nothing that they can do for us to resolve the rust issue. I stated to them that their records may showed that it was mailed twice to us, but we never received it, because if we had, we would have remembered it, given our prior Tacoma truck rust issue, and not just disregarded it. We have taken several pictures of the rust on the frame of the Tacoma, and never once did Toyota asked to have us forward them on to them. The pictures that we have show the degree of rust/corrosion/holes on the frame. I feel as they were not at all concerned with the safety of driving this truck and it’s declining frame safety. We were the only owner of this truck and bought it brand new in 2009. Because we feel there is definite safety issue to us, we are very disappointed with Toyota’s response.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754384August 3, 2026
STEERING, SUSPENSION, UNKNOWN OR OTHER
The passenger side lower A arm frame mount broke, due to frame rust. The truck has been taken to Toyota, they had the truck for about 6 weeks and have refused to fix the safety issue.This year model had a recall on the frame, it was taken in for the recall, but the recall has failed. When the lower A arm frame mount broke, I just happened to be in a parking lot. If I had been driving it, I could have killed someone, or could have been killed myself.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745667June 22, 2026
STRUCTURE
The contact owns a 2010 Toyota Tacoma. The contact stated that while the vehicle was with an independent mechanic for a scheduled service, the contact was informed that the frame underneath the engine was rusted. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer, where the contact was informed that an unknown recall associated with the failure had expired. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729653April 7, 2026
SUSPENSION
2010 Toyota Tacoma with 91K miles have frame corrosion and now has holes. I contacted Toyota motor sales USA, Inc. and informed them why I NEVER received a recalled and they said it was mailed May 2019 and expired in 2022-there’s nothing they can do and if I went to the dealership for my inspections they would of known of the recall instead of going to an independent dealer. I’ve attached current photos showing the extent of corrosion over the years. Unbelievable, the recall should still be open.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719158February 19, 2026
AIR BAGS
Our son hit a guardrail and the airbags didn't deploy. Accident and failure was reported to insurance company
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11714253January 29, 2026
STRUCTURE:BODY
I am the original owner of a 2010 Toyota Tacoma TRD Sport, 4 door, 4WD, with a 6' bed, VIN # [XXX] , with 215902 miles. During the replacement of the leaf springs on 1/27/26, under recall #14V-604, I was informed by the Toyota dealership that installed the leaf springs that there was extensive corrosion on various points on the frame to the point where it was unsafe to drive. The frame has developed severe perforation and rust-through. There are large holes in the frame, and sections missing. The corrosion is spreading across multiple points, making the vehicle unsafe and at risk of structural failure while driving. I called Toyota and they said the frame recall expired in 2022. I will be asking Toyota if they will still replace the frame as a "Goodwill " replacement. I told Toyota that I was never made aware of this recall or warranty extension and never received any letter regarding it. I did receive other recall notices for this VIN but none for the frame issues. I am waiting for a response from Toyota on what action they will take, if any, to support their product. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710966January 14, 2026
UNKNOWN OR OTHER
chassis/frame was recalled on warranty that Toyota did not inform me of and they refused to do anything about it. They said two regular mail letters were sent out to me. I have never received them. The framing of my vehicle is so bad that an accident was waiting to happen when I took my vehicle foreign oil exchange. I asked them to look at the muffler because it was hanging and that’s when they noticed the situation and they stated that you are very lucky that you are alive because the framing could have collapse on the road. I called Toyota and they said the warranty expired on 2019. I told them that I was never aware of this recall but and never received any letter regarding it. I am filing this complaint. I am asking for the company to provide a part and labor it. If they first have contacted me this situation could have been fixed. There has been lawsuits regarding the same situation. if they refuse to fix this situation, I will have to file a lawsuit against Toyota for the labor and part that cost roughly $16,500 plus tax. The car runs very well with no other major issues. They did not either send me a letter of the spring leaf recall. I am asking this agency to get involved this has been a major accident
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693795October 16, 2025
UNKNOWN OR OTHER
My 2010 Toyota Tacoma frame is rusted and deteriorated. This has been confirmed by my local Toyota dealership (Ira Toyota of Saco , ME) The vehicle has approximately 130,000 miles and is in otherwise good working order. I do not expect a 15 year old Toyota to have a rusted frame, which has become entirely unsafe. Indeed, the Toyota dealership refused to even put the truck up on the lift given the unsafe condition of the frame . I understand that 2005 -2010 Tacoma trucks had this same issue and there was a class action on 21 May 2017. I also understand that the frame recall expired in 2022. Regardless, I contacted Toyota asking if they would still replace the frame and they responded in the negative. I have attached photos of the frame and a copy of Toyota’s response. Please advise. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689067September 23, 2025
STRUCTURE:BODY, SUSPENSION, UNKNOWN OR OTHER
The frame on my 2010 Toyota Tacoma has developed severe perforation and rust-through. There are large holes in the frame, and the exhaust hanger has broken completely off the frame rail. The corrosion is spreading across multiple points, making the vehicle unsafe and at risk of structural failure while driving. I purchased the truck in May 2020 and brought it to a Toyota dealer for a paid multi-point inspection that included the undercarriage. At that time, Toyota’s ZH6 frame corrosion program was still active. No frame concerns were reported, and the program was never disclosed to me. Toyota has since denied assistance, even though the condition now represents a clear safety hazard. This frame corrosion is not cosmetic. It is structural and has already caused parts of the vehicle to detach.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11677258July 30, 2025
SUSPENSION
FRAME IS RUSTING. BADLY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668769June 23, 2025
SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
[XXX] I ordered lower control arms from [XXX] . Not even a year later I had experienced a clunking noise when I turned the steering wheel. That weekend my wife and I rode up to our campsite. Seeing a deer in the road I slowed down only for the truck to veer to the left and almost hitting a logging truck. Talking to a mechanic, he told me that it was the bushings of the lower control arms at fault. Having no choice I bought two new control arms and had a shop put them on. Calling extreme terrain, they told me even though it has not been a year they couldn't give me a refund if I returned the old ones back to them. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661195May 15, 2025
SUSPENSION
FRAME IS RUSTING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659926May 9, 2025
STRUCTURE
The contact owns a 2010 Toyota Tacoma. The contact stated that upon previous ownership; the vehicle was repaired under an unidentified NHTSA Campaign Number; however, the failure failed to prevent the failure from occurring. The contact stated that upon further inspection, the main frame of the vehicle had rusted. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656321April 23, 2025
STRUCTURE
The contact owns a 2010 Toyota Tacoma. The contact stated that while upon taking the vehicle for an annual inspection, he was informed that the sub frame was excessively corroded. The contact stated that the vehicle failed the State Inspection and was deemed unworthy to be driven on the road. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647351March 10, 2025
UNKNOWN OR OTHER
2010 Toyota Tacoma frame is rusting and deteriorating. vin [XXX] . Lou Fusz Toyota [XXX] on [XXX]. 138,748 miles. This vehicle is in good condition except for frame. at 15 year I would not expect a frame to rust and cause a possible dangerous situation. My local shop, GT's Auto, pointed out this frame deterioration during an oil change on [XXX]. The dealership agreed that this will become dangerous soon. I understand that 2005 -2010 Tacoma trucks had this same issue and a Class action on 21 May 2017. Please advise. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629062December 5, 2024
SUSPENSION, STRUCTURE:BODY
Recently had routine service done on my 2010 Toyota Tacoma. Mechanic noted a lot of corrosion of the frame, including where leaf springs and axles are connected. He said that he had difficulty putting the vehicle on the lift for service due to the amount of corrosion and that he could not assure me that the vehicle is safe to drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623444November 4, 2024
STRUCTURE:BODY
The chassis/ frame work of the pickup is rusted, corroded/ rotted. This is a known issue in there was a settlement on a lawsuit related to the problem for this year model and make vehicle and Toyota was responsible to fix the problem at no cost to the customer. I called the Toyota dealership and is being told that there is no outstanding recall for this issue for this VIN#. The fact remains that the vehicle has this safety issue and I’m asking for the repairs to be done at no cost to me. Thanks for your attention to this matter
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620531October 18, 2024
STRUCTURE
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma