Toyota Tacoma Complaints (2008)

450 consumer complaints on file.

#11774354October 29, 2026
POWER TRAIN, FUEL/PROPULSION SYSTEM
While the vehicle was in park outside running after a diagnostic was completed to determine the reverse gear was no longer working while the vehicle was in park sitting outside it started to drive forward by itself until it drove it self into a parked car in the parking lot , currently with the vehicle in the park gear it is still driving forward , this could have killed someone , this is a defect that Toyota needs to make people aware of
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11772177October 19, 2026
SUSPENSION, UNKNOWN OR OTHER, STEERING
Toyota Corporation refuses to replace the frame and other essential parts on our 2008 Toyota Tacoma, which has had 2 previous recalls for frame replacement. We were never made aware of the previous recalls by Toyota or it's dealer who sold us the truck. We were made aware of the serious condition of the frame when our mechanic personally inspected the vehicle and notified us that the frame needed replacement. Toyota refuses to inspect or acknowledge the unsafe condition of our truck frame. Photos supplied speak for themselves. Our Toyota Case # is XXX has resulted with no benefit or consideration from Toyota. Therefore we request #XXX Request for NEW recall. Our mechanic [XXX] informed us the local Toyota dealer (Lithia Toyota Missoula) and it's parent company are notorious for not informing owners about recalls. We were never told when we bought the vehicle used that there was a previous recall. Also, two years after our purchase we just learned there was a follow-up frame recall, which nobody informed us of it's existence. We are sure the NHTSA does not want this vehicle in service on the road. So, again, please issue another follow-up recall for full frame replacement to match the 2018 recall. We offered to Toyota to pay for the removal and installation costs if they would supply all parts (defined in the original recall). However, Toyota ignored our offer to share replacement costs. So please issue an enforceable recall for 2008 Toyota Tacoma total frame replacement. The vehicle is available for inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11771303October 15, 2026
STRUCTURE:BODY
The contact owns a 2008 Toyota Tacoma. The contact stated that while the vehicle was at an independent shop for new tires, a certified mechanic inspected the vehicle and informed the contact that the subframe was severely rusted and the vehicle was unsafe to drive. The mechanic advised that the subframe required replacement. The contact learned of a manufacturer program offering to replace or coat the subframe due to insufficient coating. The dealer was contacted and informed the contact that the coverage had expired. The manufacturer was notified and confirmed that the program coverage had expired. The failure mileage was approximately 170,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11770583October 12, 2026
STRUCTURE:BODY
Significant rusting of frame noted on safety inspection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766391September 23, 2026
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2008 Toyota Tacoma. The contact stated that while taking the vehicle to a service center for a tire replacement, the contact was informed that the entire rear sub frame was extremely rusted. The mechanic informed the contact that the tires could not be replaced because the vehicle was unsafe to drive and stated that the VIN might be associated with a recall. The vehicle was not repaired. The manufacturer was made aware of the failure via telephone. The failure mileage was approximately 165,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748891July 7, 2026
STRUCTURE:BODY, UNKNOWN OR OTHER
I have major rust on the frame of the truck and I was told by Toyota the warranty period is over. I just gave Toyota the Vin number and was told it was not covered. The rust is major and a safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739231May 21, 2026
UNKNOWN OR OTHER
Got oil changed and they found frame is rusted out. Called Toyota corp and they said they sent a notice to have it looked at on 04/12/2020 but we never received anything. This truck has always been garaged and we bought it new and has only 78148 miles. They refused to do anything.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734605April 29, 2026
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Odometer Fraud. The contact was previously interested in a 2008 Toyota Tacoma. The contact discovered that there was a mileage discrepancy before the purchase was made, and the vehicle was not purchased. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 114,000. It was later discovered, upon checking with the local DMV, that the mileage was 196,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705095December 15, 2025
STRUCTURE:BODY, SERVICE BRAKES, SUSPENSION
The brakes on my 2008 Toyota Tacoma were failing so I took it to a mechanic, who said that the brake lines had failed and needed to be replaced. However, he said that it wasn't worth putting any money into the truck, as the leaf springs were corroded along with the frame, which could crack apart at any time. As we only purchased the truck one year ago, he advised us to take it to the dealership where we purchased it, and informed us of the recalls on both of these issues. I spoke with the mechanic at the dealership because when we purchased the vehicle, they did the inspection and said that everything was fine. When I asked the mechanic about this, he said that he didn't have anything to do with sales and we needed to speak to the owner (who is out on medical leave). The mechanic said that when the dealership purchased the vehicle at auction, the frame must have been undercoated and so they missed it. When I mentioned the recall, he told me to call Toyota. I have checked the VIN and it is not showing an open recall for this vehicle. However, it is experiencing the exact same safety issues as the recalls for leaf spring corrosion and frame rust and cracking. I have only had this truck for a little over one year and do not know what to do. It is too dangerous to drive as it could cause a serious accident. Neither the dealership nor Toyota want to take responsibility and offer a solution.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689496September 24, 2025
STRUCTURE
The contact owns a 2008 Toyota Tacoma. The contact stated that while his wife was entering the vehicle on the passenger’s side, the sidestep was stepped on, and there was an abnormal crunching sound coming from the step. The contact went to the passenger’s side front door and yanked on the sidestep, which caused the sidestep to almost separate from the sub frame. The contact looked underneath the vehicle and observed severe corrosion extending the length of the passenger’s and driver's side. The contact had not taken the vehicle to a local dealer or independent mechanic due to the extent of the corrosion. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 173,807.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688715September 21, 2025
WHEELS
I am reporting a serious safety incident with my 2008 Toyota Tacoma. While driving at approximately 65 mph on the highway last week, my spare tire detached from the vehicle (unknown at that time). The Tire Pressure Monitoring System (TPMS) light activated, and I later discovered the spare had broken free and fallen off. This was unknown until a week later when the dealership said the TPMS went off due to a missing spare tire. The failure was caused by severe corrosion of the spare tire carrier/hoist assembly, which gave way without warning. This created an immediate highway hazard for vehicles behind me. Toyota has previously issued recalls for spare tire carrier corrosion on earlier Sequoia and Tundra models. However, my 2008 model year was not included — yet the exact defect has now occurred. This is not a matter of convenience or maintenance. A spare tire falling off at highway speeds is a life-safety defect that should be investigated by Toyota and NHTSA before someone is seriously injured or killed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11682857August 25, 2025
ELECTRICAL SYSTEM
Wire connection on passenger side, under carpet. It is to the heater Temperature Control. The heater only works on High until you hit a bump or move the connector then it will start working until you bump it again. It is available for inspection upon request. A Certified Mechanic told me, It could potentially cause a fire by shorting out. I have two other friends with the same issue on their Toyota Tacoma's. .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11682454August 22, 2025
STRUCTURE:BODY, UNKNOWN OR OTHER
report a paint defect on my 2008 Toyota Tacoma, painted in Super White (040). Over time, I have noticed significant paint peeling on multiple areas of the truck, including the roof, hood, and door frames. The paint is deteriorating down to the primer, and in some places, the metal is now exposed. I am aware of Toyota’s Customer Support Program T-SB-0162-19, which extends warranty coverage for similar paint issues on various Toyota models using the same Super White (040) and Blizzard Pearl (070) paints. However, I am disappointed to learn that the Tacoma—despite having identical paint and similar defects—was excluded from the original program. This paint failure is clearly not due to age or wear, but rather a manufacturing defect that has been documented by thousands of Tacoma owners nationwid
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678586August 5, 2025
SERVICE BRAKES, AIR BAGS, ELECTRICAL SYSTEM
Loss of brakes
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673615July 15, 2025
STRUCTURE:BODY
I have a 2008 Tacoma with a severely rusted frame. I just bought it a few months ago but didn’t know the frame was this bad. It’s unsafe to drive in its current state. Toyota will not honor their now expired recall for their faulty frames. Their frames were not coated properly from the factory and almost all tacomas had this issues that were in the cooler states of the US, and around the world for that matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672410July 10, 2025
SUSPENSION, STEERING, STRUCTURE:BODY
Toyota has had a long history of excessive frame rust. This truck has excessive frame rust. There was a recall to fix this frame rust and my truck has not been fixed. Toyota will not fix the current recall for the spring replacement because of the frame rust. My life and my children’s lives are in danger due to the possible leaf suspension failure that may puncture the gas tank.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652296April 2, 2025
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2008 Toyota Tacoma. The contact stated that during a routine oil change, he was advised that the sub frame had extensive corrosion on the rear and front passenger’s side of the vehicle. There was no warning light illuminated. The contact was informed that the sub frame needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 139,950.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649372March 19, 2025
SUSPENSION, SERVICE BRAKES
Hope to be able to get this solved. My 2008 Toyota Tacoma had a recall with the previous owner but they didn't take it in. On the rear section of the frame on the inside beside the gas tank and on the driver side there is a lot of rust there the frame has expanded and is starting to go all away through also same place back beside the muffler on the passenger side. Also there are a few spots on the front part of the frame under the fire wall area on both sides. I had a recall on the truck and took it in and had it fixed which Toyota replaced the leaf springs on both sides and hardware. Says there was a recall when the previous owner had the truck. Will they validate that still? I've owned the truck almost a year now. But it's getting worse. Within a year I'm gonna have to park it because it liable to possible break in half. Toyota should of let me known when they had it on the lift replacing the rear leaf springs. Not my fault the previous owner didn't take the truck in to have them look at it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11639479January 29, 2025
STEERING, ENGINE AND ENGINE COOLING, SERVICE BRAKES
The contact owns a 2008 Toyota Tacoma. The contact stated while driving 60 MPH, the steering wheel failed to move as intended and the vehicle became difficult to maneuver. An unknown warning light was illuminated. The contact continued driving at a slow speed. The vehicle was taken to an independent mechanic who determined that the pinion steering gear failed and needed to be replaced. The vehicle was repaired. The contact stated that on a separate occasion while driving 40 MPH, there was an abnormal revving sound coming from the engine. The vehicle was taken to an independent mechanic who determined that the engine was leaking oil and the entire braking system needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631812December 20, 2024
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2008 Toyota Tacoma. The contact stated that while inspecting the vehicle, it was discovered that underneath the vehicle there was an abnormal amount of rust on the frame. The front passenger side frame was deteriorating. The dealer was called and made aware of the failure however the vehicle was not diagnosed or repaired. The contact mentioned that the vehicle was parked and driven when necessary as they feared for their safety when the vehicle was driven. The manufacturer was notified of the failure and confirmed that the failure was a known issue. The approximate failure mileage was 106,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma