Toyota Prius Complaints (2012)

449 consumer complaints on file.

#11702529December 2, 2025
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Odometer Fraud. The contact’s son recently purchased a 2012 Toyota Prius. The vehicle was a private sale. After the purchase, it was discovered that there was a mileage discrepancy based on the Carfax report. At the time of purchase, the vehicle displayed 137,000 miles. However, the Carfax report listed the mileage as 281,586 miles, and the current mileage on the vehicle was 151,103.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701919November 28, 2025
SERVICE BRAKES
While driving on a city road below the speed limit, braking was compromised leading to loss of traction and failure of the ABS system. During the incident, the brake, ABS, and engine warning lights all turned on and a collision was only avoided due to pumping of the brakes. Further investigation by a mechanic revealed a failure of the brake actuator system. Failure of this system has increased the stopping distance of the vehicle considerably and makes braking unreliable and unpredictable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697829November 6, 2025
ELECTRICAL SYSTEM
The hybrid system fails to enter “Ready” mode with no SMR engagement audible from the junction box. Dashboard displays ABS, brake, engine, and master warning lights. OBD codes include U0142, U0155, and previously U0073 . Rear brake lights function normally when pedal is pressed. Dealer said to pay 250$ for diagnostic and diagnosed incorrect voltage from brake light switch and quoted $348.94 to replace, but refused to proceed with open safety recall J0V / 18V684 (NHTSA 18V684000) citing inability to achieve “Ready” mode. Recall covers inverter failure leading to loss of motive power. Dealer declined to jump 12V battery or use external power to perform required software update and inverter inspection. Vehicle remains inoperable and poses safety risk due to sudden power loss potential. Component (inverter G9200-47141) available for inspection. Problem confirmed by dealer diagnostics. No police or insurance inspection. Warning lamps appeared after 12V battery replacement three months ago.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696848October 31, 2025
SERVICE BRAKES
While driving 60 mph in highway, ABS, traction control and brake lights lit up and vehicle lost its effective braking power. There were no prior warnings prior to this failure. It was a sudden incident. Since it wasn't rush hour, I could safely reduce speed and bring the car to stop. Situation could have been much different if it was normal hours. After taking the car to dealership, it indicated DTC code 1391, Brake Assembly Failure. The car was fixed at dealership at cost of $3,000. When researched further, it appeared that there is broader pattern of failures. Numerous reports have been made by owners of 2010–2015 Toyota Prius, Prius PHV, 2012–2015 Prius V, 2012–2014 Camry Hybrid, and 2013–2015 Avalon Hybrid vehicles, all of which share the same brake booster pump assembly design manufactured by Advics Co., Ltd. Dealerships, including Capistrano Toyota and Claremont Toyota in California, have previously petitioned NHTSA regarding this very defect. Their 2019 letter to the agency documented that Toyota: * Knowingly excluded hundreds of thousands of hybrids from prior safety recalls (DOH 13V-235 and KOL 19V-544) despite identical failures. *Issued “post-failure” repair programs (Warranty Enhancements ZJB, ZKK, ZKC, ZLM, 20LE03, 23TE06 and 23TE07) only after owners experienced brake failure. * Identified the same DTC codes (C1252, C1253, C1256, C1391, U0293) in both recalled and unrecalled vehicles—codes that correspond to accumulator leaks, loss of brake pressure, and failure of brake assist and stability control systems. * Admitted through Technical Service Bulletin TSB-0130-19 that these defects caused loss of hydraulic pressure, increased stopping distance, and total loss of brake assist in affected hybrids. In short, the defect pattern across multiple hybrid models is identical to those already recognized by Toyota and NHTSA under prior recall campaigns, but for reasons unexplained, Toyota limited the recall population and left many consumers unprotected
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696581October 30, 2025
SERVICE BRAKES
Traction control.Abs and brake warning lights all came on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689732September 25, 2025
SERVICE BRAKES
2012 Toyota Prius. The brake system malfunctioned and my daughter was almost in a wreck. The ABS, traction control, and brake warning lights on the bashboard all illuminated at the same time. The brake pedal feels soft and is less responsive requiring more effort to stop the vehicle. The brake actuator assembly is making a hissing noise. Ran a ABS test using a scan tool and received a C1391 error code. The Code points to a leak within the brake actuator system. Upon research I have found that this is a very common and costly repair that Toyota has known about for many years. Toyota issued a customer support program related to this issue that ran for 10 years or 150,000 miles from the vehicle's date of first use. This car, being a 2012, is beyond the support program. I contacted Toyota, hoping they would do the right thing and cover the repair. I was told that they would not cover the repair or supply the parts to cover the repair. I told the Rep. for Toyota that I did not feel like it was fair for Toyota to continue to put millions of drivers at risk for a product that they clearly realize for years now is defective and could hurt or kill someone. The code and the braking issue did not appear until after the customer support program ended and therefore we had no warning or way to anticipate this braking issue or the danger to my daughter and anyone else riding with her in the car or on the roadway near her travel routes. I traveled 300 miles, rented a Uhaul car tow trailer and brought the car back home. My mechanic confirmed the code C1391 and the fact that the brake actuator has failed. The mechanic has ordered the parts (the same defective parts) to replace the broken ones. Toyota is still selling the same part as a replacement part clearly knowing that it is not safe and no warning came with the replacement part explaining the potential for a braking issue. Based on internet research this same part is in many 2005 to 2013 Toyota and Lexus
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681161August 17, 2025
SERVICE BRAKES, UNKNOWN OR OTHER
While pulling out of a parallel parking spot going slightly uphill, I braked as I looked around the back of a double parked truck. I saw a car coming, braked hard, and suddenly my car surged forward across the street and hit a parked car. I looked down and saw that my foot was squarely on the brake pedal pressing down as hard as I could. The parked car was unoccupied, and I was uninjured. There were no warning lamps, messages, or other symptoms of the problem. I turned my car into the dealer for repairs and a fix to the sudden unexpected acceleration. They could offer no fix until a Toyota representative examined the car. On August 14, by an emailed letter, Toyota claimed it found no defects and it must be the result of driver error, specifically, my mistakenly hitting the accelerator. This is gaslighting denialism. (a) The EDR data sent to me does not indicate that I hit the accelerator unless that data is in the page of hexadecimal numbers. (b) Toyota's claim that I hit the breaks at "-0.2 seconds prior to the collision" is physically impossible. No one can move their foot from the accelerator to the brake that fast. (c) Toyota's claim is contrary to what I experienced and observed.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11680736August 14, 2025
HYBRID PROPULSION SYSTEM
The contact owns a 2012 Toyota Prius. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the check engine and the hybrid warning lights were illuminated, and the vehicle decelerated. The contact received notification of NHTSA Campaign Number: 18V684000 (Hybrid Propulsion System). The vehicle was taken to the dealer; however, the contact was informed that parts were not yet available for the recall repair. The contact was informed that the parts might be available within a week. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 137,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676307July 25, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Brake getting stuck on the floor would have to press on brake really hard just to get a response, this will happen out of the blue! Driving in highway or just driving off the driveway. I almost hit a car in front of me due to lack of brake, i had to swerve to the side! First appear 1 day after buying the car..This issue needs to be worked on right away.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675051July 21, 2025
SERVICE BRAKES
While driving on the freeway I applied the brakes and the brakes suddenly felt soft and not very responsive. At that moment 3 dashboard lights turned on: ABS, BRAKE, and the slip indicator lights. I carefully got out of the freeway, parked the car, and had the car towed to an independent mechanic. The mechanic detected brake booster and actuator problems, code C1391.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668479June 22, 2025
SERVICE BRAKES
C1391 - Abnormal Leak in Accumulator
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665922June 9, 2025
UNKNOWN OR OTHER
CA No problem
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665925June 9, 2025
SERVICE BRAKES
My Prius, along with the thousands of others this has apparently happened to according to a quick online search, has had the C1391 code appear, indicating a failed brake actuator and accumulator. It, like the thousands of Priuses from this generation, have had these faulty brake pump systems develop a leak and begin to fail. You will hear a whirring and hissing noise constantly when it starts going out, eventually resulting in a Christmas tree of dash warning lights and reduced braking due to a failsafe kicking on. Toyota apparently issued a "customer service bulletin" that is now ineffective as it only covered if you had the system fail within 10 years of manufactor or 150,000 miles AND had the codes appear. Most people's Priuses go out AFTER this, unless you're driving it like you stole it. It is a hefty repair too, being quoted at over $3000 at the Toyota STEALSRSHIP!! I have since gone to an independent mechanic and had one portion replaced in hopes that would fix the issue, but it turns out both the actuator and accumulator are needed to be replaced, which is extremely expensive, more so for the actuator than the accumulator, but still exorbitantly expensive. In conjunction with this, Toyota further added difficulties by making their paet numbers they have listed different from the mark number engraved on the part, so buying third party is made a bigger hassle by this as they will not know for certain the part number. This is a huge safety concern as this affects the vehicle's ability to brake. Their service bulletin was the equivalent of offering people bandaids years before they'd be anywhere to getting a cut!! Please investigate and please please PLEASE lead to Toyota issuing an actual recall, regardless of miles or year from manufacture. More and more Priuses are reaching the time where this will occur and it's a huge safety concern, if not an environmental concern when people start disposing of Priuses due to this massive failure with hefty repair bills.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665104June 5, 2025
SERVICE BRAKES
The brake booster and brake booster pump assemblies had to be replaced at the dealership. Parts are not available for inspection as far as I know. We were warned by the dealership that we should not be driving the car because the brakes could completely fail at any moment if we didn't have parts replaced. That would have been dangerous for us and anyone else sharing the road with us. On a Sunday, leaving our house and driving down our street, three lights turned on on the dashboard display - traction, brakes, and ABS - and the brakes felt softer and less responsive than normal. After having gotten a diagnosis and repair estimate from the dealership, we carefully drove the car home to consider our options. We tried to get a second opinion from a trusted mechanic, but it sounded like the parts we needed were tightly monitored by Toyota and the original estimate for the repair from the dealership was above $3,000. After a few days, the dashboard warning lights turned off and the brakes felt back to normal. The whirring noise which had been happening roughly every 4 seconds had slowed to roughly every 10-12 seconds. We were told that this turning off of the lights sometimes happened, but that the issue was still the same. Prior to these lights turning on, the car had been making a lot of the whirring noises for some time, but it had never thrown the codes before that would have been picked up by a mechanic. At the time, we didn't recognize the sounds as a sign of an impending commonly recognized failure - only after doing some research did we find that this was a very common problem for a lot of Prius owners, especially for the given year and number of miles we had. There is an "extended warranty" for this part and repair, but while we were within the mileage limit, we were outside of the time limit and we were told at the dealership that Toyota would be inflexible about paying for the repairs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663086May 27, 2025
SERVICE BRAKES
While driving my 2012 Toyota Prius, the traction control, brake, and ABS warning lights all came on at the same time. I used a home OBD scanner but it didn’t show any diagnostic codes. After some research and inspection, I discovered that the issue was related to a faulty brake booster and accumulator—something I’ve learned is a common problem with this model. I was relieved to hear that Toyota has an extended warranty on these parts. However, last night while driving, the brakes suddenly stopped functioning properly. It became very difficult to slow down, which put me in a dangerous situation. I’m deeply concerned about the safety risks this defect poses and believe this issue deserves further attention.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661457May 16, 2025
SERVICE BRAKES, HYDRAULIC
The contact owns a 2012 Toyota Prius. The contact stated while driving 30 MPH, the ABS and traction control warning lights illuminated. The contact stated that while attempting to depress the brake pedal, the vehicle hesitated while responding. The contact stated that there was a buzzing sound coming from accumulator pump. The dealer was contacted. The contact stated that the failure had occurred on several occasions. The vehicle was taken to Nico's Auto Repair where it was diagnosed and determined that the brake booster and accumulator assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661320May 15, 2025
SERVICE BRAKES
I am reporting a sudden and dangerous failure of the brake booster in my 2012 Toyota Prius. While driving, I experienced a loss of braking power, accompanied by several warning lights including ABS, Brake, and the Traction Control system. The brake pedal became extremely stiff and unresponsive, significantly increasing the stopping distance. This failure nearly caused an accident, as I was unable to stop quickly enough when traffic slowed unexpectedly. This issue happened without warning and is a serious safety risk. I later discovered this is a common and widely reported defect in 2010–2015 Toyota Prius models. Toyota issued an extended warranty (Customer Support Program ZE3) to cover this known brake booster defect — but only for vehicles within 10 years or 150,000 miles. While my Prius has well under 150,000 miles, it is just over 10 years old, which disqualifies me from coverage, leaving me with a repair estimate over $4,000 for a well-documented manufacturer defect. This seems grossly unfair, especially for responsible owners with low-mileage, well-maintained vehicles. Toyota’s refusal to issue a formal recall and instead offering only limited support puts millions of Prius drivers at risk. A brake system failure of this kind should qualify as a safety defect and trigger a mandatory recall, not a quietly limited program with arbitrary expiration dates. I urge NHTSA to investigate this issue further and consider a recall of the defective brake booster system in these Prius models to protect public safety and ensure fair treatment for affected owners. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661343May 15, 2025
SERVICE BRAKES
This Prius Hybrid is my [XXX] mother's car which she got thinking is was a very safe and reliable vehicle. She purchased the vehicle from a Toyota dealership here in Maine on [XXX]. Last week while driving down the road, all of a sudden, every brake warning light lit up the dashboard and the brakes became extremely unresponsive. It scared us both to death but thank goodness, I was driving when this happened. After doing some research, I have discovered that this a very well known brake issue with the 2010-2015 Prius cars. I cannot for the life of me understand how this major safety defect has not been made into an actual safety recall. I did contact Toyota customer service and they will not help us at all. Even though my mother has only had the car for just under 9 years and is well under the allotted mileage, they said their Customer Support Program (ZJB) only covers 10 years from the day the car was first driven after production. Her Prius now is inoperable and the repair costs are in the thousands. We are so incredibly disappointed with Toyota and the safety board for allowing this to happen to all of the defective Prius owners. I hope you will reconsider and do the right thing and recall these cars before someone does get into an accident where they are injured or killed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11660790May 13, 2025
TIRES:TREAD/BELT
On three of the four tires at different times the tires were separating. They had bulges in the tire. Caused extreme vibration and noise. The last tire was today with 22k miles. The other two were a year ago with 15k miles. I’ve had to replace all 4 tires
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659408May 7, 2025
SERVICE BRAKES
Brake booster failures are a common safety issue with 2012-2015 Toyota Prius' this one included is starting to fail which can lead to ABS deactivating and shorter braking distances. There was a recall for this part but most tend to fail after the warranty period. Leaving many vehicles unrepaired and dangerous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Prius