Toyota FJ Cruiser Complaints (2010)

66 consumer complaints on file.

#11757740August 18, 2026
UNKNOWN OR OTHER
The truck's frame was found to be cracked / rusted through in spots. It was discovered during another attempted repair 8/17/26. Because of the split / crack in the frame, the vehicle is now not drivable as it is deemed not road worthy. This problem is known to Toyota as well as the NHTSA. The Tacomas of the same years, on which this vehicle is built (same frame, same faulty rust-proofing operation from the manufacturer), was identified and Toyota was required to address it. Why this vehicle was NOT included in the fix is a complete mystery as this problem is well-known and well-documented, far and wide (see YouTube, FJ Cruiser forums, etc., etc.). NHTSA and Toyota have really let FJ Cruiser owners down on this one.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745754June 22, 2026
TIRES, TIRES:SIDEWALL
Tires were purchased April 2026. Vehicle was then driven in June 2026 for off-road use, minimal usage prior to June due to mechanical issues). A structural failure occurred on 3 new truck tires (Size: 275/60R20, DOT: 0225) within 24 hours while driving under 10 MPH on a basic off-road trail. Day 1: Rear driver tire suddenly deflated with a loud thwapping sound. The tire separated from the bead and suffered a 3-4" sidewall tear. Vehicle was at 15 PSI (standard trail pressure). 10 companion trucks ran identical terrain without issue, isolating the failure to this tire batch. Swapped to spare. Day 2: Remaining tires aired up to 20 PSI to mitigate risk. Despite higher pressure and slow speeds, the exact same failure mode recurred on the replacement tire in the same rear driver location, causing another 3-4" sidewall tear. Trail patches failed. Borrowed a spare from another vehicle. 15 minutes later, a 3rd identical failure occurred on the rear passenger tire, causing a blowout and tearing on the inside sidewall. Vehicle was stranded, requiring a 2nd borrowed spare to exit. Tires had only 300 miles of total use. Failed components include the tire sidewalls and internal casing structures. All 3 failed tires are preserved and available for material inspection. Rapid, consecutive loss of multiple tires severely compromised vehicle stability, leaving me repeatedly stranded. Had these structural failures occurred at highway speeds rather than 10 MPH, a catastrophic loss of control or rollover could have occurred. The selling dealer has explicitly refused to file a warranty claim or inspect the failed casings. No prior warning lamps, pressure alerts, or symptoms occurred before the sudden, catastrophic failures.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700752November 21, 2025
FUEL/PROPULSION SYSTEM
The rear fuel tank mounting strap rusted in half. After filling vehicle with fuel and driving 10 miles home, I noticed the skid plate hanging down that covers the fuel tank. The plastic skid plate started to crack from the weight of the tank. The design of the skid plate to the tank allows moisture and contaminants to reside between the two, rotting the straps. Thankfully I noticed this as if I had kept driving I fear the tank would have completely fallen out of the vehicle. I ordered new straps and hardware, but during the parts search I found many owners of the Toyota FJ, all years, are having the same problem. Apparently the straps are just mild steel and were not treated with any corrosion preventative from the factory. I feel they should have been at least stainless steel. Part numbers for the straps are 77602-35050 and 77601-35110. I'll have photos once the parts come in and I take the vehicle apart. Currently I have a floor jack holding up the tank. Also to clarify, the skid plate is mounted to the fuel tank straps. Once both straps let go, the fuel tank is coming out with the skid plate. The fuel tank is located in front of the rear axle, the vehicle would run over it's own fuel tank, at least until the engine shuts off.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613380September 9, 2024
ENGINE, UNKNOWN OR OTHER
No proper rust protection causing corrosion and irreparable transmission damage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11512618March 19, 2023
STRUCTURE:BODY
The frame has rusted so badly it no longer is road safe and the frame needs to be replaced. Large hole in frame on front passenger side, and bad rusting all over. Mechanics said this is a known issue with FJ and Tacoma frames , and in my case the only solution is to replace the frame, which will cost (with associated work) $22K.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11482639September 2, 2022
STEERING, WHEELS
I have a dangerous steering issue. I tried to get my Toyota dealer to fix it, or adjust it but they said nothing was wrong. I feel they didn't want to even try. This issue has almost led to head-on collisions many times. I have replaced the tires, no help there. I had it aligned, (at dealer I purchased it from) with no improvements at all. What it does is, to stay in the center of the road I can not turn my head away from constantly adding steering input. This is an issue a big one, my car Drifts left or right but rarely goes straight when steered straight, I must constantly make adjustments to its direction. Before I replace the tires again, (the car has only 53,000 miles on it) and align it again I feel this problem must be fixed or properly adjusted to work without constant steering input to stay in my lane. I replaced tires with better than it came with, costing around $750 these are now showing bad wear after less than 20,000 miles and purchase information said I should not need to replace them for 60,000 miles. Additional information is the last 300 feet to my house is a dirt road, but it's not that bumpy and shouldn't be the reason that I can't steer it straight on asphalt.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450948February 8, 2022
STRUCTURE:BODY
The frame has alot of rust on metal and on welds affraid of frame failing and coming apart.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11441352November 22, 2021
STRUCTURE:BODY
Owner of a 2010 FJ Cruiser. The amount of corrosion on the frame and components is very high for the age of the vehicle, it leads to significant safety concerns (Including gas tank straps are corroded). Toyota should rectify this issue as it seems like they did a poor job on this model to isolate against rust the frame. There should be a Recall for a re-treatment of the frame (Just like they did on the Tundra and Tacoma models).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11432203September 8, 2021
STRUCTURE:BODY, UNKNOWN OR OTHER, FUEL/PROPULSION SYSTEM
Single Toyota 2010 FJ Cruiser Owner. Over the last 10/11 have been really diligent taking care of my truck, unfortunately due to what seems very poor quality steel or treatment of the frame and some parts when was build by Toyota, it has cause severe rust/rotten issue leading not only to significant safety concerns (broken gas tank straps and fuel lines) but also a significant amount of money spend treating the frame and part to prevent further corrosion that could\will eventually lead to complete failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11420477June 10, 2021
SUSPENSION
The contact owns a 2010 Toyota FJ Cruiser. The contact stated while driving at various speeds over speed bumps, the vehicle would shake abnormally and was not stable while driving. The contact stated there was no warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with the rear axle needing to be replaced. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 66,731.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11378030December 5, 2020
FUEL/PROPULSION SYSTEM, SUSPENSION, UNKNOWN OR OTHER
WHILE VIEWING THE UNDERCARRIAGE OF THE VEHICLE I NOTICED EXCESSIVE FRAME AND STRUCTURAL RUST AND CORROSION ON A MAJORITY OF THE FRAME, SUSPENSION, FUEL TANK STRAPS, AND OTHER METAL PARTS OF THE VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11337260July 2, 2020
AIR BAGS
PASSENGER AIRBAG COVER IS WARPED AND IS GETTING WORSE. POSSIBLE DEPLOYMENT OF PASSENGER AIRBAG IS POSSIBLE AND CAN CAUSE SERIOUS INJURY OR DEATH. THIS SAFETY ISSUE IS DUE TO DEFECTIVE SRS PASSENGER AIRBAG COVER. COMPLAINTS ARE HIGH IN NUMBER AS SEEN ON 'FJ FORUMS' WEBSITE AS WELL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11307104February 4, 2020
STRUCTURE:BODY, SUSPENSION
CATASTROPHIC FRAME FAILURE FROM DELAMINATION AND RUST HOLES IN FRAME AND GAS TANK STRAPS, AND SUSPENSION COMPONENTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11289694December 17, 2019
TIRES:SIDEWALL
TL* THE CONTACT OWNS A 2010 TOYOTA FJ CRUISER EQUIPPED WITH FOUR GOODYEAR TRAILMARK AT TIRES, SIZE: P265/65/R18 (NA). THE CONTACT INDICATED THAT ALL FOUR TIRES EXPERIENCED SIDEWALL RUBBER SEPARATION AND CRACKED. THE FAILURE CAUSED THE TIRES TO DEFLATE APPROXIMATELY 1 TO 2 LBS PER WEEK. WALMART INSPECTED THE TIRES AND DID NOT IDENTIFY A DEFECT. THE MANUFACTURER WAS ALSO NOTIFIED AND REFERRED THE OWNER TO A DEALER. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 5,000. THE VIN WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11287733December 8, 2019
STRUCTURE:BODY
OWN A 2010 TOYOTA FJ CRUISER. THE FRAME IS COVERED IN RUST. I HAVE RESEARCHED THIS AND KNOW THIS IS AN ON GOING PROBLEM WITH THESE VEHICLES. TOYOTA SHOULD BE DOING SOMETHING ABOUT THIS. WE FOUND EVEN MORE RUST RECENTLY ONCE WE HAD A CHANGE TO GET UNDER THE VEHICLE. NO CAR I HAVE OWNED AT THIS MUCH RUST ON IT IN SUCH A SHORT TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11281681November 22, 2019
SERVICE BRAKES
UNDERCARRIAGE OF 2010 FJ CRUISER RUSTED. FRONT BRAKE LINES RUSTED OUT AND I LOST FLUID. COULD HAVE GOTTEN KILLED. THANK GOD ONLY GOING 25 MPH NEAR HOME
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11268815October 16, 2019
STRUCTURE:BODY, SUSPENSION
FRAME AND GAS STRAP RUST. POSSIBLE SAFETY HAZARD WITH RUSTING. NEEDS TO BE ADDRESSED WITH TOYOTA.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11268664October 15, 2019
SEAT BELTS
TL* THE CONTACT OWNS A 2010 TOYOTA FJ CRUISER. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SEAT BELT DID NOT RETRACT. THE VEHICLE WAS TAKEN TO PLAZA TOYOTA (347-554-6090, LOCATED AT 2721 NOSTRAND AVE, BROOKLYN, NY 11210) WHERE IT WAS STATED THAT THE VEHICLE WAS OUT OF WARRANTY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE CONTACT WOULD BE CALLED BACK. THE CONTACT WAS NOT CALLED BACK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11235209July 26, 2019
SERVICE BRAKES
WHEN APPROACHING AN INTERSECTION TO TURN OR STOP, WITH BRAKES APPLIED, AND VEHICLE ENCOUNTERS A POT HOLE OR BROKEN PAVEMENT, BRAKE PEDAL GOES TO THE FLOOR AND VEHICLE LOSES BRAKES. THIS HAS HAPPENED TO ME ON MULTIPLE OCCASIONS. OTHER DRIVERS OF THE SAME MODEL VEHICLE HAVE ENCOUNTERED SAME ISSUE ACROSS MULTIPLE YEAR MODELS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11221649June 21, 2019
SEAT BELTS
I WENT TO THE POST OFFICE CAME OUT AND MY SEAT BELT WAS FROZEN UP WONT MOVE AT ALL HAD TO DRIVE ALL THE WAY HOME WITH NO SEAT BELT ON STILL CANT GET IT TO WORK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota FJ Cruiser