Tesla Model Y Complaints (2021)

1,096 consumer complaints on file.

#11718843February 18, 2026
STEERING, LANE DEPARTURE: WARNING, LANE DEPARTURE: ASSIST
The car suddenly reduced lane assistance and steering assistance functionality. After calling Tesla they said it is not a software issue. I checked the service mode and it indicated a malfunction in the steering assist motor, which apparently costs $3500 to replace. Online, I have found many complaints about this problem that are not resolved by software updates. In addition, there was a large number used steering assist motors for sale online which indicates a more wide spread problem. This is not normal for cars to have this failure prematurely and is a serious safety hazard. I read online that some had their steering EPAS get locked while driving on the highway and nearly destroyed their Teslas
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718301February 16, 2026
STEERING
front subframe and both front lateral links came loose due to welded nut not present
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718296February 16, 2026
SUSPENSION
Vehicle experienced front suspension lateral link failure. The links separated from the sub-frame due to improperly secured fasteners. This is the exact defect described in existing recall SB-21-31-003 / NHTSA Campaign 21V835000. The existing recall states 'front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.' This vehicle has this identical manufacturing defect but was not included in the recall database. Tesla Service confirmed the links 'fell out' and separated from the sub-frame at approximately 65,000 miles. Technician notes indicate a 'speed mismatch between wheel and motor' caused by the link separation - this is the symptom of the underlying fastener defect. The failure resulted in loss of steering control and made the vehicle undriveable (VOR - Vehicle Off Road). This is a safety-critical manufacturing defect affecting front suspension, creating crash risk due to sudden loss of vehicle stability and control. Owner is being charged for repair of a known manufacturing defect that should have been covered under the existing recall. This suggests the recall scope was too narrow and did not capture all affected vehicles with this defect. Request investigation into whether recall should be expanded to include additional affected vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718136February 15, 2026
SUSPENSION
The upper control arm bolt came loose on its own.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717262February 11, 2026
STEERING
Received a notice that steering assist may be reduced. Other model year Ys have been recalled due to the same issue. It doesn’t make sense that this should fail in a vehicle that is 5 years old with no accidents and low mileage. This is a safety issue due to manufacturing defect and should be covered under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715486February 4, 2026
ELECTRICAL SYSTEM, STRUCTURE:BODY
On [XXX], after placing my young child in my Tesla and closing the door, the 12V battery failed suddenly and the vehicle became inaccessible. I was unable to unlock or enter the car. I did not receive any warning or alert that the 12V battery was about to fail. The vehicle was in my garage, and the window automatically cracked, which allowed me to monitor my child while I sought help. I called Tesla Roadside Assistance at 8:59 AM. During the call, the representative reassured me that help was being dispatched and at times described the service provider as “on the way” (timing details such as “within ~45 minutes” and the length of the initial call are my best estimates). After continued waiting with my child confined inside the vehicle, I contacted emergency services due to the safety risk. I called 911 at 10:03 AM. I later had the 12V battery replaced at my own expense. This incident involved a sudden electrical failure without warning that resulted in a child being trapped inside a disabled vehicle, and I am also concerned about the accuracy and effectiveness of roadside assistance dispatch communications during the incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713780January 27, 2026
STEERING
Lower front control arms are bad. Was told by tire company they need replaced. Quote about 2k
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713621January 27, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
When driving with cruise control engaged the car randomly brakes and shows a "curvature assist " indication. The car quickly slows from 55 to 35 with no warning. This primary happens on a straight road, not a curve. I am concerned about the traffic behind me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713129January 24, 2026
SUSPENSION, STEERING
There is a rip in the lower control bushing making steering difficult to control. I see that this is a common issue but no recall yet. My car has only 28k miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712905January 23, 2026
ELECTRICAL SYSTEM
The contact's client owned a 2021 Tesla Model Y. The contact stated that while his client was driving at an undisclosed speed under 60 MPH, the vehicle caught fire in an unknown location. The origin of the fire was unknown. The contact stated that his client attempted to unlock the vehicle doors, but the driver's handle did not work as intended, trapping the contact's client in the burning vehicle. The contact stated that the police and fire department arrived, but were not able to get close enough to the vehicle due to the inferno. The contact's client succumbed to the fire. The fire department extinguished the fire after approximately 40 minutes. The vehicle was destroyed but towed to a tow yard. The manufacturer was notified of the fatality. No further information was available as of yet. The failure mileage was unknown.
Crash:
Yes
Fire:
Yes
Injuries:
0
Deaths:
1
#11712754January 22, 2026
POWER TRAIN
My heat pump and ac unit went out and Tesla wants me to pay $4000 for a faulty part that broke in less then 3 years
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711113January 15, 2026
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
After charging the vehicle threw error code “BMS_a079 Unable to charge - Maximum charge level reached Reduced maximum charge level - Schedule service”. The car would no longer charge and had to be taken in for service. Tesla advised the High Voltage battery needed to be replaced. Replacing the High Voltage battery resolved the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710416January 12, 2026
UNKNOWN OR OTHER, ENGINE, ELECTRICAL SYSTEM
I parked my Tesla vehicle in a friend’s driveway. When I returned and opened the driver’s door, I entered the vehicle and attempted to put it into Drive. At that point, the vehicle display went completely blank and the vehicle became inoperable. I then attempted to open the door from inside the vehicle, but the door would not open and I was unable to exit the car. I was effectively locked inside the vehicle. I contacted Tesla customer support and remained on the call for approximately 1.5 hours before receiving assistance. Tesla customer support confirmed that the issue was caused by failure of the 12-volt battery. At the time of the incident, the outside temperature was below 0 degrees centigrade. The incident occurred in Cedar Rapids, Iowa. There was no prior warning or notification from the vehicle or the Tesla mobile app indicating that the 12-volt battery was at risk of failure. The failure resulted in loss of vehicle function and inability to exit the vehicle, creating a serious safety concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709822January 9, 2026
VISIBILITY/WIPER, UNKNOWN OR OTHER, LANE DEPARTURE: BLIND SPOT DETECTION
I noticed the windshield washer nozzle on the passenger side isn't either working or not there. I reached out to Tesla, and also stopped by a Local Dealership and they told me that it would cost me out of pocket, since it's out of warranty. Secondly, the left side driver repeater camera has a Glare when turned at night time only. which is quite dangerous due to very less visibility due to the Glare of the Turn signal light that causes the repeater camera to function properly. this is a on going known problem. I have reached out to Tesla for this matter. and I was advised that it would not be covered since it's not under warranty. This issue should be a recall that Tesla should fix. this isn't an issue caused by normal wear and tear it's a manufacturer defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708722January 5, 2026
STEERING
On Monday 12/29/2025, while driving my 2021 Tesla Model Y on the highway at approximately 70 mph returning from DTW Airport to my home with my children in the vehicle, the steering suddenly locked / the steering wheel would not turn. I was able to pull over to the shoulder. There were no warning lamps or warning messages displayed before or during the failure. After pulling over, I powered the vehicle off and back on. The steering partially worked again, and I was able to drive home. Later the same day at my friend’s house/driveway, the steering locked out again and this time it was completely locked, making the vehicle not safely drivable. Again, there were no warning messages or symptoms prior to the lockout. Tesla Service provided a written estimate documenting the complaint “steering locked out / cannot drive” and proposed replacing the steering gear/steering rack (“Steering Gear LHD,” part number 1188832-00-B) plus alignment, total about $3,127.70, at 96,042 miles. The vehicle and component are available for inspection upon request (Tesla can retain the replaced part). This is a safety defect concern because sudden loss of steering control on a highway without warning could lead to a crash, especially with passengers/children in the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708542January 3, 2026
SUSPENSION
Both front half shafts failed and had to be replaced by Tesla. I did research and this part is known to be substandard, was recalled in China, and remains a problem in the US.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708424January 2, 2026
ELECTRICAL SYSTEM
The contact owns a 2021 Tesla Model Y. The contact stated that while the vehicle was parked, the contact observed the code BMSA079 on the computer, and messages "Vehicle Unable to Charge to Maximum Charge Level" and “Maximum Charge Level Reached - Reduced Maximum Charge Levels" were displayed. The vehicle was taken to a dealer, and it was determined that one coil in the battery was inoperative, and the dealer reduced the charge and refused to increase the battery charging level. The manufacturer was notified of the failure. The failure mileage was 155,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708085December 31, 2025
SERVICE BRAKES, UNKNOWN OR OTHER
Picked up car from tesla service on 12/30/2025. On [XXX] at around [XXX] I had pressed the car break and suddenly accelerated and lead to crashing into the pole. I am concerned about the safety and if it is drivable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11708023December 31, 2025
ELECTRICAL SYSTEM
The vehicle’s high-voltage battery and charging system experienced repeated failures, preventing charging while the vehicle was parked. This issue occurred three times: January 2024: Charging error “BMS_a079. Unable to charge” appeared. Vehicle was stranded and required service intervention. Mileage ~28,125. November 2024: Same charging error during winter travel, vehicle stranded mid-trip, creating safety risk for passengers. Mileage ~38,744. September 2025: Charging error recurred mid-trip, vehicle had to be left at a service location. Mileage ~48,918. All incidents were reported to Tesla under battery warranty. Repairs were attempted each time, but the problem recurred. A repurchase request was submitted after the third incident and was denied, with only a goodwill service credit offered. Safety concerns include the risk of being stranded, particularly during long trips or in winter conditions, which could affect passengers and other road users. The battery and charging system were inspected by Tesla service personnel after each incident, and the failure was confirmed each time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705202December 15, 2025
VISIBILITY/WIPER, UNKNOWN OR OTHER, ELECTRICAL SYSTEM
In May 2025, Tesla pushed an over-the-air (OTA) software update overnight while the vehicle was parked. When the vehicle was started the following morning, the update had failed mid-process and stalled at approximately 50%. Immediately upon startup, the backup camera and navigation/maps stopped functioning. The vehicle has been unable to complete subsequent software updates since. Tesla service later inspected the vehicle and indicated that the main computer/ECU was stuck in a loop and required replacement. The backup camera and navigation loss occurred immediately following the OTA update and persisted for several months despite multiple service attempts. Due to the vehicle’s rear design and limited rear window visibility, operating the vehicle in reverse without a functioning backup camera significantly impairs visibility. Even when using mirrors or physically turning to look backward, rearward visibility is restricted. As a result, the loss of backup camera functionality presents an ongoing, daily safety hazard during normal vehicle operation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Tesla Model Y