Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model S and 2021-2025 Model X vehicles. An air bag with the incorrect horn pad may have been installed, preventing the horn from sounding.
Tesla, Inc. (Tesla) is recalling certain 2021-2025 Model S and Model X vehicles. The driver's air bag could tear during deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208, "Occupant Crash Protection" and 212, "Windshield Mounting."
Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
This vehicle has a recurring suspension defect causing a chassis or suspension component to make physical contact with the inner shoulder of the rear tires during normal operation, producing a sharp linear cut progressing to full cord exposure and fraying of internal steel and aramid belts. This has occurred on at least three sets of rear tires between July 2025 and June 2026. Tesla's own service records document the damage pattern on multiple occasions. No root cause has ever been identified or corrected by Tesla's service department. A tire with exposed and fraying cords on a vehicle producing over 1,000 horsepower presents a serious risk of catastrophic blowout at speed.
No injuries · No fire · No crash
Turn signal inaccessible.
No injuries · No fire · No crash
See attached document for complaint.
No injuries · No fire · No crash
The vehicle was being driven northbound in the regular (non-HOV) lanes of Route I-95 under the control of Version 12 of FSD software. I believe that the vehicle would have crashed into the lowered gates preventing vehicles from entering the HOV lanes, which operate in only one direction at a time. Beyond the gates, the HOV lanes contained high-speed oncoming traffic. The problems occurred south of the Dale City exit from northbound I-95. The car’s navigation system gave an audio instruction to keep left to bear onto northbound I-95 and the car did exactly that. Twice. I believe that both crashing into the lowered gates or crashing head-on into oncoming vehicles would likely have resulted in multiple deaths, including my own. I saw the developing problem and took control of the vehicle before it could bear left onto the closed ramp to the HOV lanes.
No injuries · No fire · No crash
This car does not have reliable horn system. I have the steering wheel version (not the “yoke” version) but I believe it’s a similar problem on both. The steering wheel center (airbag) does NOT operate as a horn. Instead there is only a extremely small horn sensor on one side of the wheel that cannot be reliably accessed in an emergency situation b/c of its tiny size and b/c its position depends on where the steering wheel has been turned. This is EXTREMELY DANGEROUS. On a recent drive a car pulled into our lane from a side street and I was unable to locate the horn in a timely manner. Fortunately the car braked and I was able to pull around but it was very close and could have resulted in a head on crash. I contacted Tesla about this issue. The service rep acknowledged the problem and said it was an “issue” that had gotten numerous complaints but that all he could offer was a Tesla aftermarket replacement that would cost nearly $1,000 to install. I presume NTSB has gotten many complaints about this incredibly dangerous and egregious latent safety defect in the car’s design. Tesla (at least for the 2024 and on Model 3 - which I also own) has corrected this design defect such that the center area does operate as a horn (as I am sure 99% of cars do). The NTSB should investigate and require Tesla to retrofit any of its cars which have this safety defect. I have no doubt that people will (or likely have been) seriously injured (or even killed) in car crashes that could have been avoided had Tesla retrofitted its vehicles built with this dangerous safety design defect. Please, please open an investigation and require Tesla to correct this inherent safety design defect. Tesla already has the fix (and have implicitly recognized the defect by correcting it on its current models). NTSB’s failure to require Tesla to act will result in many avoidable accidents/injuries. Owners should not have to pay nearly $1k to correct Tesla’s latent/non-obvious safety defect.
No injuries · No fire · No crash