Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2006 Verona vehicles manufactured June 2003 to October 2005. In the affected vehicles, there may be heat generated within the DRL module located in the instrument panel, which could melt the DRL module.
ON CERTAIN PASSENGER VEHICLES, THE POWER STEERING PUMP PULLEY MAY SEPARATE FROM THE POWER STEERING PUMP DUE TO INADEQUATE WALL THICKNESS OF THE PULLEY.
ON CERTAIN PASSENGER VEHICLES, THE BRAKE LIGHT SWITCH MAY BECOME MISADJUSTED IF AN UPWARD/REARWARD FORCE IS APPLIED TO THE BRAKE PEDAL. IF THIS SHOULD OCCUR, THE BRAKE LIGHT SWITCH WILL NOT FUNCTION PROPERLY, CAUSING THE BRAKE LIGHTS, INCLUDING THE HIGH MOUNTED STOP LAMP, TO REMAIN ILLUMINATED CONTINUOUSLY WITHOUT BRAKE PEDAL APPLICATION, WITH THE IGNITION SWITCH IN THE ON OR OFF POSITION.
IN CERTAIN PASSENGER VEHICLES, A FAULT IN THE ADAPTIVE FUEL CONTROL LOGIC CAN CAUSE SOME VEHICLES TO USE AIR/FUEL RATIOS DURING DECELERATION THAT ARE LEAN ENOUGH TO CAUSE ENGINE STALLING.
ON CERTAIN PASSENGER CARS, THE DUAL STAGE DRIVER'S AIR BAG DEPLOYS IN AN IMPROPER SEQUENCE.
This issue pertains to Safety Recall Notice No. XC - All 2004-2006 Suzuki Verona Vehicles - DRL System. Please note, the vehicle manufacturer provided documentation service was performed and the DRL Module (part 38860-84Z21-RX0) was replaced at mileage 49470. My wife and I are the original owner and the mileage is 61,000-62,000 currently. Approximately 1 month ago we experienced a slight odor like something electrical was burning. Recently, we noticed 1) That the Daytime Running Lights glow at first and gradually reach full intensity. 2) When switching from low headlights to high beams, all headlights go completely out for about 6 seconds before coming on gradually. Because Suzuki automobiles are no longer sold in the United States, the nearest support dealer is located 150 miles away. A local auto repair shop diagnosed and determined the DRL Module part mentioned in the original recall needs to be replaced. We contacted the support dealer, who, in turn, contacted Suzuki USA about the issue. Suzuki USA indicates they complied with the original recall and refuse to comply a second time. The original recall service report indicated a $122.60 cost for the part. Currently, Suzuki has the part and wants $294 for it, and they consider the repair to be a billable service. We have not been able to locate any alternate part sources and must rely on Suzuki for this item. I am [XXX] old and if I have to drive 150 miles (one way) to make the repair, it will involve the additional cost of an overnight hotel. My local repair guy can do the repair, which I'm willing to pay for if Suzuki can supply the part at $0 or at least for only their product cost. Otherwise, I do not feel safe driving the car with the possibility of having a fire (per the recall notice). Even if no fire occurs, it certainly is not safe without dependable headlights. Won't you please help us? Thank you in advance for your assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
The contact's fiancé owns a 2004 Suzuki Verona. The contact stated that on multiple occasions after starting the vehicle, the engine was lagging and then revved inadvertently. The contact also stated that while driving at various speeds and coming to a stop at a red light or stop sign, the vehicle stalled and lost motive power on multiple occasions. The vehicle was able to be restarted. Additionally, the contact stated that the driver's seat belt failed to latch, and the front passenger’s side seat belt locked without movement. The check engine, air bag, seat belt, and oil warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the timing chain and lifters needed to be replaced. The mechanic was unable to duplicate the additional failures. The vehicle was then taken to another independent mechanic, where a diagnostic tool retrieved various failure codes for unknown sensors and failure with the engine. The contact made a local dealer aware of the failures and the dealer confirmed there was no related recalls for the VIN. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 180,500.
No injuries · No fire · No crash
VEHICLE DRIVES NORMAL THEN BRAKES LOCK UP CAUSING TIRES TO SKID TO SUDDEN STOP KILLING THE ENGINE AT RANDOM TIMES AND RANDOM SPEEDS THEN STARTS RIGHT BACK UP THEN DOES IT AGAIN AT A RANDOM TIME. *TR
No injuries · No fire · No crash
SCOTT WAS TRAVELING ON A HIGHWAY AND ATTEMPTED TO EXIT THE HIGHWAY; HOWEVER, AS HE ATTEMPTED TO BRAKE, HE NOTICED H WAS NOT SLOWING DOWN, AND THAT IT APPEARED THAT HIS BRAKES HAS GIVEN OUT. HE WAS ABLE TO SAFELY SLOW DOWN THE VEHICLE AND PULL TO THE SHOULDER. HE OBSERVED A SMALL AMOUNT OF SMOKE EMANATING FROM HIS VEHICLE. UPON EXITING THE VEHICLE AND OPENING THE HOOD, HE SAW MORE SMOKE AND FLAMES BETWEEN THE ENGINE AND FIREWALL. HE ADVISED HIS PASSENGER TO EXIT THE VEHICLE.
TL* THE CONTACT OWNS A 2004 SUZUKI VERONA. WHILE DRIVING, THE CHECK ENGINE INDICATOR ILLUMINATED AND FIFTEEN CODES APPEARED AS A TEXT TO HER CELLPHONE. THE VEHICLE STALLED, BUT THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND DRIVE HOME SAFELY. AFTERWARDS, WHEN THE VEHICLE WAS STARTED, ALL THE INSTRUMENT PANEL INDICATORS ILLUMINATED AND THE SERVICE INDICATOR REMAINED ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 144,000.
No injuries · No fire · No crash