Ram 5500 Service Bulletins (2015)
331 manufacturer communications on file.
- June 14, 2017•Document ID: 10219831Service Bulletin/Repair InstructionsVEHICLE SPEED CONTROL:ACCELERATOR PEDAL
- Mfr Comm. #:
- 9003413
- Date Added:
- September 15, 2022
- Manufacturer:
- JEEP
SummaryAccelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected during diagnosis. Make sure codes are active before replacing pedal. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault.
Associated Products (86)2017 Alfa Romeo Stelvio2017 Chrysler 2002017 Chrysler 3002017 Chrysler 300C2017 Chrysler Pacifica2017 Chrysler Town and Country2017 Dodge Challenger2017 Dodge Charger2017 Dodge Durango2017 Dodge Grand Caravan2017 Dodge Journey2017 Dodge Viper2017 Fiat 124 Spider2017 Fiat 5002017 Fiat 500e2017 Fiat 500X2017 Jeep Cherokee2017 Jeep Compass2017 Jeep Grand Cherokee2017 Jeep Patriot+ 66 moreAssociated Documents - June 14, 2017•Document ID: 10138856Service Bulletin/Repair InstructionsVEHICLE SPEED CONTROL:ACCELERATOR PEDAL
- Mfr Comm. #:
- 9003413
- Date Added:
- June 4, 2018
- Manufacturer:
- ALFA
SummaryAccelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected during diagnosis. Make sure codes are active before replacing pedal. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault.
Associated Products (85)2017 Chrysler 2002017 Chrysler 3002017 Chrysler 300C2017 Chrysler Pacifica2017 Chrysler Town and Country2017 Dodge Challenger2017 Dodge Charger2017 Dodge Durango2017 Dodge Grand Caravan2017 Dodge Journey2017 Dodge Viper2017 Fiat 124 Spider2017 Fiat 5002017 Fiat 500e2017 Fiat 500X2017 Jeep Cherokee2017 Jeep Compass2017 Jeep Grand Cherokee2017 Jeep Patriot2017 Jeep Renegade+ 65 moreAssociated Documents - June 10, 2017•Document ID: 10219919Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; EQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- 08-047-17
- Date Added:
- September 15, 2022
- Manufacturer:
- RAM
SummaryFlash: RA3/RA4 Radio Software Enhancements This bulletin involves inspecting and if required, updating the radio software. A small number of customers may experience one or more of the following: ? **?Navigation Failed? message is displayed. ? Navigation is inoperative or inaccurate. ? CD player will not play songs and/or locks up the radio. ? The clock will not automatically update to local time. ? The clock may be off by several hours (RA3 only). ? HVAC temperature out of sync with radio display (KL vehicles). ? Some Uconnect App remote commands do not execute with the vehicle. ? Radio Apps are inoperative. ? Radio will lock up. Radio display screen is black or blank. Battery drain due to radio staying on.** Rearview Camera image appears jittery (UF vehicles only). Inability to establish a WiFi connection when security feature is enabled (UF vehicles only). Audio distortion/popping heard while playing Apple devices through the USB port (UF vehicles only). Remote Uconnect Apps functions (i.e. door locks, remote start) inoperative while the engine is running (UF vehicles only). HVAC temperature out of sync with radio display (KL vehicles). Intermittently blind spot chime will not turn off (KL vehicles only). The radio may switch from SiriusXMT to an AM station by itself. Uconnect registration always present, can not remove Uconnect account. Audio muted after AUX device is disconnected. In addition, the following Improvements are included: **Adds Apple SiriT Eyes Free capability for iPhoneT owners. Add the ability to drag and drop icons into the menu bar. Auto Play can now be configured. Enhanced VR performance. Media devices, phone pairing and Bluetooth usage improvements. Improved tuner performance. Enhancements in Connectivity Apps (YelpT, PandoraT, AhaT, etc). Human Machine Interface (HMI) improvements. Adds ?do not disturb? text message feature.**
Associated Products (13)Associated Documents - June 7, 2017•Document ID: 10219830Service Bulletin/Repair InstructionsVISIBILITY:WINDSHIELD WIPER/WASHER
- Mfr Comm. #:
- 9003109
- Date Added:
- September 15, 2022
- Manufacturer:
- RAM
SummaryWasher Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottle anti-rotation features that surround the SENSOR. Check to determine if the issue has been resolved. Continue with repair if necessary. Please contact Chris Koch at cell (248) 248-622-6417 if you have questions or need additional information.
Associated Products (183)2018 Alfa Romeo 4C2018 Alfa Romeo Stelvio2018 Chrysler 2002018 Chrysler 3002018 Chrysler Pacifica2018 Chrysler Town and Country2018 Dodge Challenger2018 Dodge Charger2018 Dodge Durango2018 Dodge Grand Caravan2018 Dodge Journey2018 Fiat 124 Spider2018 Fiat 5002018 Fiat 500X2018 Jeep Cherokee2018 Jeep Compass2018 Jeep Grand Cherokee2018 Jeep Patriot2018 Jeep Renegade2018 Jeep Wrangler+ 163 moreAssociated Documents - March 31, 2017•Document ID: 10140015Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- D-17-12
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryShop Certification Program Guidelines
Associated Products (49)2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 moreAssociated Documents - March 29, 2017•Document ID: 10217524Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
- Mfr Comm. #:
- 9003696
- Date Added:
- August 8, 2022
- Manufacturer:
- ALFA ROMEO
SummaryDoor Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
Associated Products (112)2018 Alfa Romeo 4C2018 Alfa Romeo Stelvio2018 Chrysler 2002018 Chrysler 3002018 Chrysler Pacifica2018 Chrysler Town and Country2018 Dodge Challenger2018 Dodge Charger2018 Dodge Durango2018 Dodge Grand Caravan2018 Dodge Journey2018 Fiat 124 Spider2018 Fiat 5002018 Fiat 500X2018 Jeep Cherokee2018 Jeep Compass2018 Jeep Grand Cherokee2018 Jeep Patriot2018 Jeep Renegade2018 Jeep Wrangler+ 92 moreAssociated Documents - March 29, 2017•Document ID: 10140010Service Bulletin/Repair InstructionsEQUIPMENT; STRUCTURE:BODY:ROOF AND PILLARS
- Mfr Comm. #:
- 31115
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryCover - Roof Rack Youhave been identified aseither having stock,or have stock in transit toyour dealership. Please return allsuspect stock of part numbers:68212041AC,68141170AC,55112738AA.See attachmentsfor identifying suspect material. Please return suspect partsback toyour facing depot using Return Code 02,before 19April,2017.
Associated Products (49)2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 moreAssociated Documents - March 29, 2017•Document ID: 10140009Service Bulletin/Repair InstructionsFUEL SYSTEM, GASOLINE; FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
- Mfr Comm. #:
- 31127
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryHousing Assy - Fuel Filler Door Youhave been identified aseither having stock,or have stock in transit toyour dealership. Please return allsuspect stock of part numbers:68148794AH,68148794AF,68148794AD,68156453AH,68156453AF, 68156453AD,68161542AE,68161542AD.See attachment for identifying suspect material. Please return suspect partsback toyour facing depot using Return Code 02,before 19April,2017.
Associated Products (49)2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 moreAssociated Documents - March 29, 2017•Document ID: 10140008Service Bulletin/Repair InstructionsSEATS; EQUIPMENT
- Mfr Comm. #:
- 31056
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryRecliner - Stow and Go: Return Youhave been identified aseither having stock,or have stock in transit toyour dealership. Please return allstock of following part numbers:68241568AB,68241568AC,68241569AB,68241569AC, 68241570AB,68241571A.Replacement part numbersare 68241568AD,68241569AD,68241570AD,68241571AD, which are in stock and available. Please return suspect partsback toyour facing depot using Return Code 02,before 19April,2017.
Associated Products (49)2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 moreAssociated Documents - March 29, 2017•Document ID: 10139997Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- 9003059
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryPark Assist Sensor 1) Active or Stored DTC of Signal Shape / Waveform Failure fault: B128E-25, B128F-25, B1290-25, B1291-25, B1292-25, B1293-25, B1295-25, B1296-25, B1297-25, and/or B1298-25, check for snow/mud/ice/obstruction and clean the Sensors, both front and back (behind bumper) of sensor. The snow/mud/ice can be behind the bumper, sensor retainer and/or the sensor which may cause customers to think they have an issue since they cleaned the front of the sensor/bumper, but not behind where dirt/mud/ice snow can accumulate. Once the Bumper and Sensors are completely cleaned and clear of snow, mud, ice, and/or obstruction, the sensors must activate in order for the faults to go STORED. After cleaning the Bumper and Sensors, turn off the engine, wait 10 seconds, turn on the engine and then place the vehicle in REVERSE so that the sensors activate. The faults will go STORED. 2) Active or Stored DTC code of Short to Ground fault: B128E-11, B128F-11, B1290-11, B1291-11, B1292-11, B1293-11, B1294-11, B1295-11, B1296-11, and/or B1298-11, or if you have an active or stored DTC code of Performance or Incorrect Operation fault: B128E-92, B128F-92, B1290-92, B1291-92, B1293-92, B1294-92, B1295-92, B1296-92, B1297-92, and/or B1298-92, then check the wiring behind the sensor. Specifically, ensure that the connector behind the park assist sensor is fully mounted. Ensure also, there is no dirt, corrosion, or damage in this connector behind the park assist sensor as this will also cause a Short to Ground fault. With potential wiring issues addressed, the sensors must activate in order for the faults to go STORED. After all sensors are properly connected (you will likely hear a click once the connector is fully seated on the sensor), turn off the engine, wait 10 seconds, turn on the engine and then place the vehicle in REVERSE so that the sensors activate. The faults will go STORED.
Associated Products (23)Associated Documents - March 29, 2017•Document ID: 10139992Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR
- Mfr Comm. #:
- 9003696
- Date Added:
- June 11, 2018
- Manufacturer:
- JEEP
SummaryDoor Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.
Associated Products (105)2018 Alfa Romeo Stelvio2018 Chrysler 2002018 Chrysler 3002018 Chrysler Pacifica2018 Dodge Challenger2018 Dodge Charger2018 Dodge Durango2018 Dodge Grand Caravan2018 Dodge Journey2018 Jeep Cherokee2018 Jeep Compass2018 Jeep Grand Cherokee2018 Jeep Renegade2018 Jeep Wrangler2018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City+ 85 moreAssociated Documents - March 27, 2017•Document ID: 10140007Service Bulletin/Repair InstructionsINTERIOR LIGHTING; EQUIPMENT
- Mfr Comm. #:
- 30948
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryMolding Assy ?Frt door day light opening Rt/Lt: Return You have been identified as either having stock, or have stock in transit to your dealership. Please return all suspect stock of following part numbers: 57010364AI, 57010365AI, 57010504AJ, 57010505AJ, 68224368AB, 68224369AB. Please return suspect parts back to your facing depot using Return Code 02, before 17 April, 2017.
Associated Products (49)2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 moreAssociated Documents - March 27, 2017•Document ID: 10140006Service Bulletin/Repair InstructionsENGINE; ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 30731
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
Summary04627694AA Purge Control - Valve You have been identified as either having stock, or have stock in transit to your dealership. Suspect stock of part number: 04627694AA must be returned. See attached for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 17 April, 2017.
Associated Products (49)2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 moreAssociated Documents - March 22, 2017•Document ID: 10140014Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- D-17-11
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryVehicle Restriction Program - Cummins Enhanced Customer Satisfaction (ECS)
Associated Products (49)2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 moreAssociated Documents - March 21, 2017•Document ID: 10140005Service Bulletin/Repair InstructionsVISIBILITY:WINDSHIELD
- Mfr Comm. #:
- 30928
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
Summary55395241AG Weatherseal - Windshield to Cowl Please return allstock of following part numbers:55395241AG,55395241AE.Replacement ispart number 55395241AH which isin stock and available. Please return suspect partsback toyour facing depot using Return Code 02,before 12April,2017
Associated Products (49)2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 moreAssociated Documents - March 17, 2017•Document ID: 10140013Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- D-17-08
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
SummaryEssential Flash Management
Associated Products (49)2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 moreAssociated Documents - March 17, 2017•Document ID: 10140004Service Bulletin/Repair InstructionsLATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK; STRUCTURE:BODY:HATCHBACK/LIFTGATE
- Mfr Comm. #:
- 30865
- Date Added:
- June 11, 2018
- Manufacturer:
- RAM
Summary04589131AG, 04589243AG - Inspect and Return: Liftgate - Latch Assy You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 04589131AG, 04589243AG . See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 7 April, 2016.
Associated Products (49)2019 Ram 15002018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002018 Ram Promaster City2017 Ram 15002017 Ram 25002017 Ram 35002017 Ram 45002017 Ram 55002017 Ram Promaster City2016 Ram 15002016 Ram 25002016 Ram 35002016 Ram 45002016 Ram 55002016 Ram ProMaster 35002016 Ram Promaster City+ 29 moreAssociated Documents - March 15, 2017•Document ID: 10217521Service Bulletin/Repair InstructionsFUEL SYSTEM, GASOLINE
- Mfr Comm. #:
- 9003694
- Date Added:
- August 8, 2022
- Manufacturer:
- DODGE
SummaryOil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump replacement and hold part for return to FCA via Fastrack system
Associated Products (179)2017 Alfa Romeo Stelvio2017 Chrysler 2002017 Chrysler 3002017 Chrysler 300C2017 Chrysler Pacifica2017 Chrysler Town and Country2017 Dodge Challenger2017 Dodge Charger2017 Dodge Durango2017 Dodge Grand Caravan2017 Dodge Journey2017 Dodge Viper2017 Fiat 124 Spider2017 Fiat 5002017 Fiat 500e2017 Fiat 500X2017 Jeep Cherokee2017 Jeep Compass2017 Jeep Grand Cherokee2017 Jeep Patriot+ 159 moreAssociated Documents - March 15, 2017•Document ID: 10217520Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 9003693
- Date Added:
- August 8, 2022
- Manufacturer:
- RAM
SummaryGasket, Rocker Cover If you are replacing this gasket for an oil leak, please call Steve Alvarado @ (866) 799-1695 ext: 4720271 to arrange for Fastrac shipper
Associated Products (14)Associated Documents - March 15, 2017•Document ID: 10139989Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 9003694
- Date Added:
- June 11, 2018
- Manufacturer:
- CHRYSLER
SummaryOil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 [email protected], or Joe Lovell (734) 309-6467 [email protected] before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump replacement and hold part for return to FCA via Fastrack system
Associated Products (175)2017 Chrysler 2002017 Chrysler 3002017 Chrysler 300C2017 Chrysler Pacifica2017 Chrysler Town and Country2017 Dodge Challenger2017 Dodge Charger2017 Dodge Durango2017 Dodge Grand Caravan2017 Dodge Journey2017 Dodge Viper2017 Fiat 124 Spider2017 Fiat 5002017 Fiat 500e2017 Fiat 500X2017 Jeep Cherokee2017 Jeep Compass2017 Jeep Grand Cherokee2017 Jeep Patriot2017 Jeep Renegade+ 155 moreAssociated Documents