DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
CERTAIN DELPHI AFTERMARKET FUEL PUMP MODULES / MODULE RESERVOIR ASSEMBLIES (MRA) THAT WERE SOLD FOR USE ON THE ABOVE LISTED VEHICLES. DURING PRODUCTION THE MRAS VENT AND FUEL RETURN TUBES WERE REVERSED. THIS CONDITION CAN RESULT IN THE VEHICLE NOT RUNNING CORRECTLY (IDLE ROUGH AND/OR STALL) DUE TO AN OVERLY RICH FUEL BLEND OR THE VEHICLE'S EVAPORATIVE EMISSION CARBON CANISTER MAY LEAK FUEL.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
TL* THE CONTACT OWNS A 1997 PONTIAC SUNFIRE. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, SMOKE STARTED TO EMIT FROM THE VENTS AND A FIRE ERUPTED UNDER THE DASHBOARD. THE CONTACT AND THE FRONT PASSENGER WERE ABLE TO SAFELY EXIT THE VEHICLE WITHOUT ANY INJURIES. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS DESTROYED AND TOWED TO THE CONTACTS RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
TL * THE CONTACT OWNS A 1997 PONTIAC SUNFIRE. THE CONTACT STATED THAT SMOKE WAS EMITTING FROM THE STEERING COLUMN. THE CONTACT MENTIONED THAT AFTER INSPECTING THE VEHICLE HE NOTICED THAT THERE WAS AN ELECTRICAL SHORT CAUSING THE WIRES TO MELT TOGETHER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE IGNITION SWITCH MALFUNCTIONED. AS A RESULT, THE STEERING COLUMN AND WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 200,000.
FUEL TANK RUSTED AND CAUSED GAS TO LEAK OUT. *TR
No injuries · No fire · No crash
HEARD AND FELT A LOUD THUD SOUND FROM STEERING AREA DRIVING HOME. POWER STEERING FEELS LIKE IT IS GONE WHEN TURNING LEFT, BUT TURNS EASIER WHEN TURNING RIGHT AT LOW SPEEDS. STEERING WHEEL BECOMES OFF CENTERED AT TIMES. ALMOST FEELS AS IF I MIGHT LOOSE CONTROL OF FRONT TIRES DURING TURNS OR AT HIGHER SPEEDS. *TR
No injuries · No fire · No crash
TL*THE CONTACT OWNS A 1997 PONTIAC SUNFIRE GT. THE CONTACT STATED THAT HE LOST TWO ENGINES DUE TO HIS ENGINE OIL WARNING LIGHT NOT ILLUMINATING AND WARNING HIM THAT THE OIL LEVEL WAS LOW. THE VEHICLE HAD NOT BEEN INSPECTED BY A DEALER NOR HAD IT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000. THE VIN WAS UNAVAILABLE.
No injuries · No fire · No crash