Mazda North American Operations (Mazda) is recalling certain 2009-2011 RX-8 and 2006-2007 MazdaSpeed6 vehicles. Fuel may leak from the fuel pump mounting rings.
Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Mazda North American Operations (Mazda) is recalling certain 2010-2011 Mazda RX-8 vehicles that were previously recalled under recall 18V-716 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Mazda North America Operations (Mazda) is recalling certain 2009-2010 Mazda RX-8 vehicles that were previously recalled under recall 18V-017 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Mazda North America Operations (Mazda) is recalling certain 2005-2006 Mazda MPV vehicles sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. On July 9, 2019 this recall was expanded to include certain 2005-2009 RX-8 vehicles that were previously recalled under 17V-011 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
The contact owns a 2004 Mazda RX-8. The contact stated that while the vehicle was being serviced at Valvoline for a scheduled oil change, the contact was informed that fuel was leaking. The contact was advised not to drive the vehicle. The dealer was contacted and notified of the failure. The vehicle was taken to the dealer, where a diagnostic evaluation revealed a fractured fuel system discharge pipe. The contact was informed that the fuel pump required replacement. The contact associated the failure with NHTSA Campaign Number: 17V354000 (Fuel System, Gasoline), which was completed on the VIN in 2009. The manufacturer was notified of the failure and informed the contact that the repair was not covered under warranty. The failure mileage was approximately 70,000.
No injuries · No fire · No crash
No worries — here it is trimmed to under 2,000 characters: I am reporting a recurring safety defect on my 2004 Mazda RX-8 (VIN: [XXX] a repair under NHTSA Recall 1017E (Fuel Pump Ring / Discharge Pipe). Recall 1017E was completed on my vehicle on September 19, 2017. The same fuel leak has since recurred, with fuel vapor now entering the passenger cabin. Only a few thousand miles have been driven since the recall repair. The vehicle is currently at Della Mazda, Queensbury, NY at approximately 72,000 miles. On May 8, 2026, I contacted Mazda Customer Experience Center. Mazda confirmed the dealer submitted a pre-authorization request for recall coverage, which Mazda corporate denied, stating the recall was previously completed and further repairs are my responsibility. I have a chat transcript documenting this. A recall remedy that fails to correct the covered defect should not be considered complete. I am requesting NHTSA review whether Recall 1017E has produced recurring failures, direct Mazda to honor the recall remedy, and advise on available consumer reimbursement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
Safety concerns of Sam Leman Mazda located in blooomington IL installed a radiator from auto zone instead of using Mazda-approved parts. Sam Lemans modified other vehicle components to make the auto zone part fit and initially suggested using zip ties. My vehicle was held from Nov 5-25, 2025 while the dealership attempted to figure out how to alter components to fit the Auto Zone part - my choices were use the (1) Auto Zone part or (2) supply my own. Mazda corporate was then involved due to the unnecessary vehicle modifications due to Sam Lemans using a non approved Mazda part (Auto Zone radiator). Sam Leman compromised safety & my vehicle has been compromised due to component alternations and non Mazda approved parts. The auto zone part was not designed for my specific car and could fail during normal driving conditions. By altering the fan housing to make the unauthorized Mazda part fit, Sam Lemans created a risk of mechanical failure or accident. I am have a video showing the dealership discussing “zip tie” repair to hold the weight of the radiator (but this site will not allow me to upload a .mov video for your review only a photo of the video is there an alternate email I can send the video for review of Sam Leman’s mechanic discussing using zip ties to)? I am requesting NHTSA review this as a safety risk due to the wrong part, alteration of other parts, and non mazda approved part used by an authorized Mazda dealership, even after Mazda corporate was notified.
No injuries · No fire · No crash
For a year I have responded to every notice for a recall repair (7 total) Mazda has not repaired my vehicle or scheduled its repair. My recall ID is 016742248 and my Campaign Number is 100409. My car has a DO NOT DRIVE status and Mazda tells me I MUST drive the car 2 hours to get it repaired each way. And they refuse to transport y vehicle even thought I have told them in phone conversations about my cars do not drive status. The latest attempt for filing for a repay was 7-21-25 at 9:40am central time.
No injuries · No fire · No crash
The contact owns a 2004 Mazda RX-8. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the engine. The dealer determined that the engine had no compression. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 60,000.
No injuries · No fire · No crash