Lincoln Aviator Service Bulletins (2023)
131 manufacturer communications on file.
- February 23, 2023•Document ID: 10232481Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51380
- Date Added:
- March 4, 2023
- Manufacturer:
- LINCOLN
SummarySome 2020-2023 Explorer/Aviator vehicles may exhibit the A/C blowing warm air with DTCs P0645, P2CFC, and/or P2CFD present in the heating ventilation and air conditioning (HVAC) module. This may be due to spread terminal/terminal pushout in wire harness 14290 and on the corresponding pins to the body control module C (BCMC). Before replacement of the BCMC, disconnect all connectors from the BCMC and check the BCMC pins and wire terminals for damage. Refer to Workshop Manual (WSM), Section 419-10. If spread terminals or terminal pushout is present, repair as necessary. Refer to Wiring Diagram, Cell 005 for repair procedures. Reconnect all connections to the BCMC as indicated by the procedure in the WSM. Test the function of the A/C to verify that it is blowing cold air.
Associated Products (8)Associated Documents - February 3, 2023•Document ID: 10232400Service Bulletin/Repair InstructionsBACK OVER PREVENTION:DISPLAY FUNCTION; ELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51338
- Date Added:
- March 4, 2023
- Manufacturer:
- LINCOLN
SummarySome 2020-2023 Aviator vehicles may exhibit a concern where the center display screen will not shift to night mode or has lines on the center display screen with multi color or rainbow hue. This may be due to accessory protocol interface module (APIM) software. To correct the condition, run the APIM-SYNC Module (APIM) Standard Programming application using the latest software level of the Ford Diagnosis and Repair System (FDRS). For claiming, use causal part 14G371 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (4)Associated Documents - January 19, 2023•Document ID: 10230835Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51306
- Date Added:
- February 2, 2023
- Manufacturer:
- LINCOLN
SummarySome 2018-2023 F-150, Expedition, Navigator, Transit, Aviator and Explorer vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0627, P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs, damaged pins/terminals, or loose/corroded grounds. Inspect FPCM connector, applicable grounds (F-150 - G401, Expedition/Navigator - G403, Transit - G401, 2018-2019 Explorer G302, 2020-2022 Explorer/Aviator - G407) and confirm FPCM connector (F-150 - C4336, Expedition/Navigator - C433, Transit - C433, 2018-2019 Explorer - C3239, 2020-2022 Explorer/Aviator - C4033) is fully seated prior to performing PC/ED diagnostics or replacing any components.
Associated Products (34)2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Transit2022 Lincoln Aviator2022 Lincoln Navigator2021 Ford Expedition2021 Ford Explorer2021 Ford F-1502021 Ford Transit2021 Lincoln Aviator2021 Lincoln Navigator2020 Ford Expedition2020 Ford Explorer+ 14 moreAssociated Documents - January 13, 2023•Document ID: 10230800Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 51297
- Date Added:
- January 31, 2023
- Manufacturer:
- FORD
SummarySome 2020-2023 Explorer/Aviator/Police Interceptor Utility vehicles equipped with a hybrid powertrain may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2D40. This may be due to the high voltage battery thermal system not cooling as it should. Follow the updated WSM Section 414-03 including listed possible sources, visual inspection and prechecks, and diagnostic procedures.
Associated Products (8)Associated Documents - January 11, 2023•Document ID: 10230795Service Bulletin/Repair InstructionsSEATS
- Mfr Comm. #:
- SSM 51293
- Date Added:
- January 31, 2023
- Manufacturer:
- LINCOLN
Summary2022-2023 Lincoln Aviator vehicles equipped with multi-contour front seats have driver seat control module G (SCMG) and passenger seat control module H (SCMH) seat modules available separately at a lower level service part from the seat back frame (5461018/7861018/7861019). If diagnosis determines that replacement of either multi-contour front seat module is required, it is not necessary to replace the complete seat back frame. Refer to the service part catalog for the correct front seat module part number (14F548/14F549) and Workshop Manual (WSM) Section 501-10A for replacement procedures.
Associated Products (2)Associated Documents - December 20, 2022•Document ID: 10228881Service Bulletin/Repair InstructionsEQUIPMENT; VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
- Mfr Comm. #:
- SSM 51265
- Date Added:
- January 6, 2023
- Manufacturer:
- FORD
SummarySome vehicles equipped with power folding mirrors may exhibit power folding mirrors that are inoperative or exhibit a clicking sound. This may be due to the mirrors being manually folded in, during transportation, going through a car wash, bumped in a parking lot, or found during pre-delivery inspection (PDI). Prior to the replacement of any components, attempt to synchronize the mirrors by following the Power Mirrors Synchronization procedure. Refer to Workshop Manual (WSM) Section 501-09 Rear View Mirrors - General Procedures - Power Mirrors Synchronization.
Associated Products (55)2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Lincoln Aviator2022 Lincoln Navigator2021 Ford Expedition2021 Ford Explorer2021 Ford F-1502021 Ford F-2502021 Ford F-3502021 Ford F-450+ 35 moreAssociated Documents - December 16, 2022•Document ID: 10228876Service Bulletin/Repair InstructionsSERVICE BRAKES
- Mfr Comm. #:
- SSM 51261
- Date Added:
- January 6, 2023
- Manufacturer:
- FORD
SummarySome Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotors should only be machined if directed by the WSM because one or more of the following conditions are present on the braking surface: scoring, excessive corrosion/rust or pitting, bluing/discoloration and/or heat spots. For additional information, refer to WSM section 206-00.
Associated Products (145)2023 Ford Bronco2023 Ford Bronco Sport2023 Ford E-1502023 Ford E-2502023 Ford E-3502023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Maverick2023 Ford Mustang2023 Ford Mustang Mach-E2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Bronco2022 Ford Bronco Sport2022 Ford E-1502022 Ford E-2502022 Ford E-350+ 125 moreAssociated Documents - December 1, 2022•Document ID: 10228846Service Bulletin/Repair InstructionsCOMMUNICATION:MANUFACTURER TELEMATICS
- Mfr Comm. #:
- SSM 51228
- Date Added:
- January 5, 2023
- Manufacturer:
- FORD
SummarySome 2020-2023 Ford and Lincoln vehicles equipped with a telematic control unit (TCU) may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization, and/or modem electronic serial number (ESN) could not be displayed in the center display screen. To correct this condition prior to programming, remove the TCU fuse for 5-minutes then reinstall. Delete all previous session files for the vehicle. Start a new Ford Diagnosis and Repair System (FDRS) session. Perform a TCU provisioning and Program the TCU to the latest FDRS version level. If the concern is still present, follow normal diagnostics in Workshop Manual (WSM), Section 415-00. Refer to PTS OASIS home page for TCU version identification. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (40)2023 Lincoln Aviator2022 Ford Bronco Sport2022 Ford Escape2022 Ford Explorer2022 Ford Maverick2022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Ford Transit Connect2022 Lincoln Aviator2022 Lincoln Corsair2021 Ford Bronco Sport2021 Ford Escape2021 Ford Expedition2021 Ford Explorer2021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford Mustang+ 20 moreAssociated Documents - November 21, 2022•Document ID: 10226769Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51215
- Date Added:
- November 30, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2023 Lincoln Aviator and 2020-2022 Lincoln Corsair vehicles may exhibit courtesy lamps not illuminating with a door open or always on. Also, ambient lighting may be inoperative or always on. If this concern occurs, check the center console cup holder area for evidence of liquid intrusion first. Liquid can short the local interconnect network (LIN) circuit. Temporarily disconnect the console inline connector(s) during diagnosis to isolate circuit shorts. Search Wiring Diagram (WD) for *cup holder ambient* to display the related connectors. If a short is found in cup holder ambient light ring light emitting diode (LED) connector, repair as necessary. If no evidence of liquid intrusion is found, continue with normal Workshop Manual (WSM) diagnostics.
Associated Products (8)Associated Documents - October 13, 2022•Document ID: 10224334Service Bulletin/Repair InstructionsCOMMUNICATION:MANUFACTURER TELEMATICS; UNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 51131
- Date Added:
- October 19, 2022
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Ford and Lincoln vehicles equipped with a telematic control unit (TCU) may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization, and/or modem electronic serial number (ESN) could not be displayed in the center display screen. To correct this condition prior to programming, remove the TCU fuse for 5-minutes then reinstall. Delete all previous session files for the vehicle. Start a new Ford Diagnosis and Repair System (FDRS) session. Perform a TCU provisioning and Program the TCU to the latest FDRS version level. If the concern is still present, follow normal diagnostics in Workshop Manual (WSM), Section 415-00. Refer to PTS OASIS home page for TCU version identification. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (44)2023 Lincoln Aviator2022 Ford Bronco Sport2022 Ford Escape2022 Ford Explorer2022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford Maverick2022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Ford Transit Connect2022 Lincoln Aviator2022 Lincoln Corsair2021 Ford Bronco Sport2021 Ford Escape2021 Ford Expedition2021 Ford Explorer2021 Ford F-250+ 24 moreAssociated Documents - September 12, 2022•Document ID: 10219657Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SSM 51074
- Date Added:
- September 13, 2022
- Manufacturer:
- LINCOLN
SummarySome 2022 Explorer/Police Interceptor Utility and 2022-2023 Aviator vehicles built on or before 19-Aug-2022 and equipped with 3.0L Ecoboost engines may exhibit an engine coolant leak at the water pump output spigot to the transmission oil cooler inlet hose connection. This may be due to the connection at the water pump outlet to coolant hose. To correct this condition, replace the coolant hose assembly with service part number L1MZ-7G071-A.
Associated Products (3)Associated Documents